Lubrication Contents; Lubrication Service Information; Lubrication Service Data - Honda Motorcycle Service Manual

SERVICE INFORMATION 4 - 1 OIL PUMP INSPECTION 4 - 9
SERVICE DATA 4 - 1 PRESSURE RELIEF VALVE 4-10
TROUBLESHOOTING 4 - 2 OIL PUMPlOlL LINE BLEEDING
SYSTEM DESCRIPTIONS 4-3
(2-Stroke Engine) 4-1 1
OIL PUMP DESCRIPTIONS 4-7
OIL COOLER INSPECTION 4 - 1 2
OIL PRESSURE CHECK 4-9
SERVICE INFORMATION
4-Stroke Engines:
Refer to the Model Specific manual for:
- Oil pump removallinstallation
- Oil strainer screen cleaning
- Oil filter replacement
- Oil level inspectionloil change
.
The service procedures in this section can be performed with the engine oil drained.
.
When removing and installing the oil pump use care not to allow dust or dirt to enter the engine.
.
If any portion of the oil pump is worn beyond the specified service limits, replace the oil pump as an assembly
.
After the oil pump has been installed check that there are no oil leaks and that oil pressure is correct.
2-Stroke Engines:
When removing and installing the oil pump, clean the engine around the pump and oil pump itself.
DO not attempt to disassemble the oil pump.
Bleed air from the oil pump if there is air in the oil inlet line and each time the oil line is disconnected
-
Fill the oil outlet line with oil whenever the oil outlet line is disconnected.
Refer t o section 2 for oil strainer screen cleaning and oil pump control cable adjustment.
SERVICE DATA
Use only recommended oil for your vehicle. Viscosity requirements vary according to the air temperature range encountered
during operation. Refer to the Model Specific manual for specific oil recommendations for the model you are servicing.
GENERAL
Oil recommendations:
4-Stroke engine1
transmission and
2-Stroke transmission oil
2-Stroke engine oil
API Service Classification:
SF
or SG
Viscosity: SAE 1 0 W - 4 0
Other viscosities shown i n the chart may be used
OIL VISCOSITIES
when the average temperature in your riding area
is within the indicated range.
0 20 40 60 80 100°F
,
-20-10
0
10 20 30 40°C
Separate lubrication
Mechanical lubrication
Date o f Issue: March,
1995
O
HONDA MOTOR CO.,LTD.
4- 1
Pro-Honda Two-Stroke oil or equivalent
systems
Premix-Type systems
Pro-Honda Two-Stroke oil or equivalent (no concentrates)
Refer t o Model Specific manuals for recommended fuel/oil ratios.