Measuring The Engine Oil Pressure - Yamaha 2009 Diversion XJ6S Service Manual

4. Drain:
Engine oil
G
(completely from the crankcase)
5. If the oil filter cartridge is also to be replaced,
perform the following procedure.
MMMMMMMMMMMMMMMMMMMMMMMMMMMMMMMM
a. Remove the oil filter cartridge "1" with an oil
filter wrench "2".
Oil filter wrench
90890-01426
YU-38411
2
b. Lubricate the O-ring "3" of the new oil filter
cartridge with a thin coat of engine oil.
ECA13390
NOTICE
Make sure the O-ring "3" is positioned cor-
rectly in the groove of the oil filter cartridge.
c. Tighten the new oil filter cartridge to specifi-
cation with an oil filter wrench.
Oil filter cartridge
17 Nm (1.7 m·kgf, 12 ft·lbf)
LLLLLLLLLLLLLLLLLLLLLLLLLLLLLLLL
6. Check:
Engine oil drain bolt gasket
G
7. Install:
Engine oil drain bolt
G
(along with the new gasket)
1
New
3-25
PERIODIC MAINTENANCE
Engine oil drain bolt
43 Nm (4.3 m·kgf, 31 ft·lbf)
8. Fill:
Crankcase
G
(with the specified amount of the recom-
mended engine oil)
Engine oil quantity
Total amount
3.40 L (3.59 US qt, 2.99 Imp.qt)
Without oil filter cartridge re-
placement
2.50 L (2.64 US qt, 2.20 Imp.qt)
With oil filter cartridge replace-
ment
2.80 L (2.96 US qt, 2.46 Imp.qt)
9. Install:
Engine oil filler cap
G
Bottom cowling
G
Refer to "GENERAL CHASSIS" on page 4-1.
10.Start the engine, warm it up for several min-
utes, and then turn it off.
11.Check:
Engine
G
(for engine oil leaks)
12.Check:
Engine oil level
G
Refer to "CHECKING THE ENGINE OIL
LEVEL" on page 3-23.
EAS20820

MEASURING THE ENGINE OIL PRESSURE

1. Check:
Engine oil level
G
Below the minimum level mark → Add the
recommended engine oil to the proper level.
2. Start the engine, warm it up for several min-
utes, and then turn it off.
ECA13410
NOTICE
When the engine is cold, the engine oil will
have a higher viscosity, causing the engine
oil pressure to increase. Therefore, be sure
to measure the engine oil pressure after
warming up the engine.
3. Remove:
Main gallery bolt "1"
G
EWA12980
WARNING
The engine, muffler and engine oil are ex-
tremely hot.