Adjusting The Front Disc Brake; Checking The Front Brake Pads - Yamaha 2009 Diversion XJ6S Service Manual

a
A. Front brake
B. Rear brake
EWA13090
WARNING
Use only the designated brake fluid. Other
G
brake fluids may cause the rubber seals to
deteriorate, causing leakage and poor
brake performance.
Refill with the same type of brake fluid that
G
is already in the system. Mixing brake flu-
ids may result in a harmful chemical reac-
tion, leading to poor brake performance.
When refilling, be careful that water does
G
not enter the brake fluid reservoir. Water
will significantly lower the boiling point of
the brake fluid and could cause vapor lock.
ECA13540
NOTICE
Brake fluid may damage painted surfaces
and plastic parts. Therefore, always clean up
any spilt brake fluid immediately.
TIP
In order to ensure a correct reading of the brake
fluid level, make sure the top of the brake fluid
reservoir is horizontal.
EAS21160

ADJUSTING THE FRONT DISC BRAKE

1. Adjust:
Brake lever position
G
(distance "a" from the throttle grip to the
TIP
G
G
a
EWA13060
G
G
After adjusting the brake lever position,
make sure there is no brake drag.
EAS21250

CHECKING THE FRONT BRAKE PADS

The following procedure applies to all of the
brake pads.
1. Operate the brake.
2. Check:
3-12
PERIODIC MAINTENANCE
brake lever)
While pushing the brake lever forward, turn the
adjusting dial "1" until the brake lever is in the
desired position.
Be sure to align the setting on the adjusting dial
with the arrow mark "2" on the brake lever hold-
er.
Position #1
Distance "a" is the largest.
Position #5
Distance "a" is the smallest.
WARNING
After adjusting the brake lever position,
make sure the pin on the brake lever holder
is firmly inserted in the hole in the adjusting
dial.
A soft or spongy feeling in the brake lever
can indicate the presence of air in the brake
system. Before the vehicle is operated, the
air must be removed by bleeding the brake
system. Air in the brake system will consid-
erably reduce in loss of control and possi-
bly an accident. Therefore, check and if
necessary, bleed the brake system.
ECA13490
NOTICE
Front brake pad
G
Wear indicator groove "a" has almost disap-
peared → Replace the brake pads as a set.
Refer to "FRONT BRAKE" on page 4-23.