Procedure: Install Ds-1 Amp Champ Cables On The Amp Champ Eia - Cisco 15454-TCC - Network Processor Card Operation Manual

Chapter 1 Hardware Installation
Table 1-6
64-Pin Blue Bundle
Signal/Wire
Tx Tip 5
white/slate
Tx Tip 6
red/blue
Tx Tip 7
red/orange
Tx Tip 8
red/green
Tx Tip 9
red/brown
Tx Tip 10
red/slate
Tx Tip 11
black/blue
Tx Tip 12
black/orange
Tx Tip 13
black/green
Tx Tip 14
black/brown
Tx Tip 15
black/slate
Tx Tip 16
yellow/blue
Caution Always use the supplied ESD wristband when working with a powered ONS 15454. Plug the
wristband cable into the ESD jack located on the lower-right outside edge of the shelf assembly.
When using DS-1 AMP Champ cables, you must equip the ONS 15454 with an AMP Champ connector
EIA on each side of the backplane where DS-1 cables will terminate. Each AMP Champ connector on
the EIA corresponds to a slot in the shelf assembly and is numbered accordingly. The AMP Champ
connectors have screw-down tooling at each end of the connector. To install an AMP Champ backplane
cover, see the

Procedure: Install DS-1 AMP Champ Cables on the AMP Champ EIA

Step 1 Prepare a 56-wire cable for each DS-1 card you will install in the shelf assembly. See
page 1-41
Connect the male AMP Champ connector on the cable to the female AMP Champ connector on the ONS
Step 2
15454 backplane.
November 2001
Pin Assignments for AMP Champ Connectors (shielded DS1 cable) (continued)
Pin Pin Signal/Wire
5 37 Tx Ring 5
slate/white
6 38 Tx Ring 6
blue/red
7 39 Tx Ring 7
orange/red
8 40 Tx Ring 8
green/red
9 41 Tx Ring 9
brown/red
10 42 Tx Ring 10
slate/red
11 43 Tx Ring 11
blue/black
12 44 Tx Ring 12
orange/black
13 45 Tx Ring 13
green/black
14 46 Tx Ring 14
brown/black
15 47 Tx Tip 15
slate/black
16 48 Tx Tip 16
blue/yellow
"AMP Champ EIA" section on page
for the ONS 15454 AMP Champ connector pin assignments.
64-Pin Orange Bundle
Signal/Wire Pin
Rx Tip 5 21
white/slate
Rx Tip 6 22
red/blue
Rx Tip 7 23
red/orange
Rx Tip 8 24
red/green
Rx Tip 9 25
red/brown
Rx Tip 10 26
red/slate
Rx Tip 11 27
black/blue
Rx Tip 12 28
black/orange
Rx Tip 13 29
black/green
Rx Tip 14 30
black/brown
Rx Tip 15 31
black/slate
Rx Tip 16 32
yellow/blue
1-20.
Cisco ONS 15454 Installation and Operations Guide
DS-1 Cable Installation
Pin Signal/Wire
53 Rx Ring 5
slate/white
54 Rx Ring 6
blue/red
55 Rx Ring 7
orange/red
56 Rx Ring 8
green/red
57 Rx Ring 9
brown/red
58 Rx Ring 10
slate/red
59 Rx Ring 11
blue/black
60 Rx Ring 12
orange/black
61 Rx Ring 13
green/black
62 Rx Ring 14
brown/black
63 Rx Tip 15
slate/black
64 Rx Tip 16
blue/yellow
Table 1-5 on
1-43