Suzuki Grand Vitara XL-7 Service Manual page 420

STEP 10. CHECK FOR INTERMITTENT PROBLEM
Check parts where an intermittent trouble is easy to occur (e.g., wire harness, connector, etc.), referring to "INTER-
MITTENT AND POOR CONNECTION" in Section 0A and related circuit of DTC recorded in Step 2.
STEP 11. FINAL CONFIRMATION TEST
Confirm that the problem symptom has gone and the A/T is free from any abnormal conditions.
If what has been repaired is related to the malfunction DTC, clear the DTC once, set conditions under which DTC
was detected and A/T and/or vehicle was repaired and confirm that no DTC is indicated.
CUSTOMER PROBLEM INSPECTION FORM (EXAMPLE)
User name:
Date of issue:
j Engine does not start
j Vehicle does not move
j
(forward, rearward)
j No lock-up (TCC clutch operation)
j Shift point too high or too low
j Excessive gear change shock
VEHICLE/ENVIRONMENTAL CONDITION WHEN PROBLEM OCCURS
j Fair/j Cloudy/j Rain/j Snow/j Always/j Other (
Weather
j Hot/j Warm/j Cool/j Cold/j ( _C _F)/j Always
Temperature
j Always/j Sometimes/j ( times/
Frequency
j Urban/j Suburb/j Highway/j Mountainous (uphill/downhill)/j Paved road/j Gravel/
Road
j Other (
Transmission range
Transmission temp.
Vehicle
Engine
Brake
O/D off switch
Diagnostic trouble code
NOTE:
The above form is a standard sample. It should be modified according to conditions characteristic of each
market.
Model:
Date of Reg:
PROBLEM SYMPTOMS
Environmental Condition
)
Vehicle Condition
j (P, R, N, D, 2, L) range/j ( ! ) range
j Cold/j Warming up phase/j Warmed up
j At stop/j During driving (constant speed/accelerating /decelerating/
j
right hand corner/left hand corner)/j Other ( )/j Speed ( km/h mile/h)
j Speed ( r/min)/j Throttle opening (idle/about %/full)
j Apply/j Not apply
j ON/j OFF
: j No code
First check
Second check : j No code
AUTOMATIC TRANSMISSION (4 A / T) 7B1-15
VIN:
Date of problem:
j Engine stops
j Transmission does not shift
j
(1st, 2nd, 3rd, 4th, Rev) gear
j Automatic shift does not occur
j Transmission slipping in
j
(1st, 2nd, 3rd, 4th, Rev) gear
j Other:
)
day, month)/j Only Once
j Malfunction code (
j Malfunction code (
Mileage:
)
)