Service And Repairs; Caring For The Battery - Toro Sand Pro 3040 Service Manual

Service and Repairs

Caring for the Battery

Electrical System: Service and Repairs
Note: For engine component repair information, see the
V-Twin Engine Service
• Wear safety goggles and rubber gloves when working with
electrolyte.
• Charge battery in a well ventilated place so gasses produced
while charging can dissipate.
• Since the gases are explosive, keep open flames and electrical
sparks away from the battery; do not smoke.
• Nausea may result if the gases are inhaled.
• Unplug charger from electrical outlet before connecting or
disconnecting charger leads to or from battery posts.
The original machine battery is a maintenance free battery. A maintainable
battery of the same size and power may be used as a replacement.
1. When using a maintainable battery, the battery-electrolyte must be kept at
the proper level.
2. The top of the battery must be kept clean.
3. If the machine is stored in a location where the temperatures are extremely
high, the battery will discharge more rapidly than if the machine is stored in a
location where the temperatures are cool.
4. Check battery condition weekly or after every 50 hours of operation. Keep
terminals and entire battery case clean because a dirty battery will discharge
slowly.
Do not remove fill caps while cleaning.
A. Clean battery by washing entire case with a solution of baking soda and
water. Rinse with clear water.
B. Coat battery posts and cable connectors with battery terminal protector or
petroleum jelly to prevent corrosion; refer to
(page 2–17).
Connecting the cables to the wrong battery post could result in
personal injury and/or damage to the electrical system.
Ensure that the cables are properly connected to the correct battery
posts before operating the machine.
5. Tighten the battery cables on the battery terminals to provide a good
electrical contact.
Manual.
WARNING
IMPORTANT
WARNING
Page 6–28
Briggs & Stratton
Battery Terminal Protector
Sand Pro ® 3040 and 5040
20251SL Rev A