Think Safety First - Toro Sand Pro 3040 Service Manual

Think Safety First

Sand Pro ® 3040 and 5040
20251SL Rev A
Toro Products are evaluated for compliance with existing safety standards and
specifications. Although hazard control and accident prevention are partially
dependent upon the design and configuration of the machine, hazard control
and accident prevention are also dependent upon the awareness, concern
and proper training of the personnel involved in the operation, transport,
maintenance, and storage of the machine. Improper use or maintenance of the
machine can result in injury or death.
To reduce the potential of injury or death, comply with the safety
instructions in this manual, as well as information found in the
Operator's Manuals and the Operator and Safety Training Materials
found on www.toro.com.
•
Avoid unexpected starting of the engine...
Always turn off the engine, remove the key and unplug the 48V battery
disconnect before cleaning, adjusting, or repair.
•
Avoid lacerations and amputations...
Stay clear of all moving parts whenever the engine is running. Treat all
normally moving parts as if they were moving whenever the engine is
running or has the potential to start.
•
Avoid burns...
Do not touch the engine, muffler, or other components, which may be hot
during operation, while the unit is running or shortly after it has been
running. Allow the engine, muffler, and other components to cool before
working near them.
•
Avoid fires and explosions...
Use extreme care in handling fuel. Fuel is flammable and its vapors are
explosive.
– Extinguish all cigarettes, cigars, pipes, and other sources of ignition.
– Avoid spilling fuel and never smoke while working with any type of fuel
or lubricant.
– Wipe up any spilled fuel or oil immediately.
– Never remove the fuel cap or add fuel when the engine is running.
– Always use approved, labeled containers for storing or transporting fuel
and lubricants.
– Do not add or drain fuel in an enclosed space.
– Do not store the machine or fuel container where there is an open flame,
spark, or pilot light, such as on a water heater or other appliance.
•
Avoid asphyxiation...
Do not operate an engine in a confined area without proper ventilation.
•
Avoid injury from batteries...
– Battery acid is poisonous and can cause burns. Avoid contact with skin,
eyes and clothing.
– Battery gases can explode. Keep cigarettes, sparks and flames away
from the battery.
•
Avoid injury due to inferior parts...
WARNING
Page 1–3 Safety: Safety Instructions