Yamaha E115A Service Manual page 252

Index
Checking the hydraulic pressure .............7-35
Checking the ignition coil ...........................8-7
Checking the ignition spark gap ................8-6
Checking the ignition timing.......................3-8
Checking the internal anode....................5-38
Checking the lighting coil .........................8-16
Checking the lower case..........................6-15
Checking the lower unit for air
leakage ..................................................3-13
Checking the main valve..........................7-45
Checking the neutral switch (WH) ...........8-11
Checking the outboard motor mounting
height .....................................................1-12
Checking the pinion and forward gear .....6-14
Checking the piston clearance.................5-37
Checking the piston diameter ..................5-36
Checking the piston pin ...........................5-38
Checking the piston pin boss bore ..........5-38
Checking the piston ring ..........................5-37
Checking the piston ring side
clearance ...............................................5-38
Checking the propeller.............................3-13
Checking the propeller shaft ......................6-9
Checking the propeller shaft housing ........6-9
Checking the pulser coil.............................8-8
Checking the reed valve ..........................5-24
Checking the remote control cable
(Remote control model) .........................1-13
Checking the reservoir.............................7-45
Checking the spark plug ............................3-3
Checking the spark plug cap .....................8-6
Checking the spiral spring (MH, WH) ......5-15
Checking the starter motor operation ......8-15
Checking the starter motor pinion ...........8-14
Checking the starter relay (WH, E, ET) ...8-11
Checking the starter rope (MH, WH) .......5-15
Checking the steering system .................1-14
Checking the thermostat............................3-3
Checking the thermoswitch........................8-9
Checking the throttle cable and shift
cable ........................................................7-4
Checking the tilt cylinder and trim
cylinder...................................................7-51
Checking the tilt operation
(MH, WH, E) ..........................................3-11
Checking the top cowling...........................3-2
Checking the trim sensor .........................7-57
Checking the upper case .........................7-13
Checking the water pump and shift rod .....6-5
Clamp bracket and swivel bracket ...........7-20
Control system...........................................3-4
Crankcase................................................5-31
Cylinder head...........................................5-27
i-2
D.
Dimension ................................................2-15
Disassembling the PTT motor .................7-39
Disassembling the bearing housing.........5-34
Disassembling the carburetor ..................4-12
Disassembling the crankshaft..................5-36
Disassembling the drive shaft housing ....6-13
Disassembling the forward gear ..............6-13
Disassembling the fuel pump...................4-16
Disassembling the gear pump housing ...7-44
Disassembling the lower case .................6-14
Disassembling the manual starter
(MH, WH) ...............................................5-14
Disassembling the oil seal housing .........5-35
Disassembling the piston and connecting
rod assembly .........................................5-35
Disassembling the propeller shaft
assembly..................................................6-8
Disassembling the propeller shaft
housing ....................................................6-8
Disassembling the swivel bracket
(MH, WH, E) ..........................................7-25
Disassembling the tilt cylinder and trim
cylinder...................................................7-50
Disassembling the upper case.................7-12
Disassembly and assembly .......................1-4
Drive shaft and lower case ......................6-12
E.
Electrical (115B, 140B models) ...............2-12
Electrical (E115A models) .........................2-7
Electrical component .................................8-2
Exhaust cover ..........................................5-25
F.
Fire prevention ...........................................1-3
Fuel hose and breather hose.....................4-1
Fuel line .....................................................4-3
Fuel pump................................................4-15
Fuel system ...............................................3-2
G.
Gear pump...............................................7-42
General ....................................................3-13
General specification .................................2-1
General torque .........................................2-21
Good working practice ...............................1-4
H.
Hose routing ..............................................4-1
How to use this manual .............................1-1
61U5H11