Draining The Fuel Tank; Electrical System Maintenance; Servicing The Battery - Toro 22322 Operator's Manual

Draining the Fuel Tank

DANGER
In certain conditions, fuel is extremely flammable
and highly explosive. A fire or explosion from fuel
can burn you and others and can damage property.
• Drain fuel from the fuel tank when the engine is
cold. Do this outdoors in an open area. Wipe
up any fuel that spills.
• Never smoke when draining fuel, and stay away
from an open flame or where a spark may ignite
the fuel fumes.
1. Lower the loader arms, shut off the engine, and remove
the key.
2. Syphon the fuel from the tank using a pump-type
syphon.
Note: Now is the best time to install a new fuel filter because
the fuel tank is empty.
Electrical System
Maintenance

Servicing the Battery

Service Interval: Every 100 hours—Check the battery
electrolyte level (replacement battery
only).
Every 100 hours—Check the battery cable
connections.
CALIFORNIA
Proposition 65 Warning
Battery posts, terminals, and related
accessories contain lead and lead compounds,
chemicals known to the State of California
to cause cancer and reproductive harm.
Wash hands after handling.
Important: The following procedures apply when
servicing a (dry) battery that has replaced the original
battery. The original (wet) battery does not require
service.
Always keep the battery clean and fully charged. Use a paper
towel to clean the battery case. If the battery terminals are
corroded, clean them with a solution of 4 parts water and
1 part baking soda. Apply a light coating of grease to the
battery terminals to reduce corrosion.
Voltage: 12 V, 585 A (cold cranking)
Checking the Electrolyte Level
1. Shut off the engine and remove the key.
2. Remove the 4 bolts securing the battery cover and
remove it from over the battery.
3. Look at the side of the battery. The electrolyte must
be up to the Upper line
electrolyte to fall below the Lower line
32
WARNING
(Figure 41). Do not allow the
(Figure 41).