Table Of Contents; Introduction - Toro 03422 Operator's Manual

Warning
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safe Operating Practices
Toro Mower Safety . . . . . . . . . . . . . . . . . . . . . . . .
Sound Pressure Level . . . . . . . . . . . . . . . . . . . . . . .
Vibration Level . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals
Slope Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications . . . . . . . . . . . . . . . . . . . . .
Measurements . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Equipment . . . . . . . . . . . . . . . . . . . . . . . .
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loose Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installing the Rear Wheel
Installing the Seat . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting the Rear Carrier Frame Height
Mounting the Carrier Frames to the Cutting Units
Installing the Front Lift Arms
Mounting the Cutting Unit Drive Motors
Mounting the Cutting Units
Installing the Counterbalance Springs
Adding Rear Ballast . . . . . . . . . . . . . . . . . . . . . . . .
Affixing the Decals . . . . . . . . . . . . . . . . . . . . . . . .
Activating and Charging the Battery
Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the Crankcase Oil
Filling the Fuel Tank . . . . . . . . . . . . . . . . . . . . . . .
Checking the Cooling System
Checking the Hydraulic System Fluid
Inspecting the Fuel Filter
Checking the Tire Pressure
Checking the Reel to Bedknife Contact
Checking the Torque of the Wheel Nuts
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting and Stopping the Engine
Bleeding the Fuel System
Checking the Operation of the Interlock Switches
2001 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Page
2
3
. . . . . . . . . . . . . . . . . . . . 3
4
5
5
. . . . . . . . . . . . . . . . . 6
9
11
11
12
12
12
12
. . . . . . . . . . . . . . . . . . . . 14
14
. . . . . . . 15
15
. . . . . . . . . . . . . . . . 15
. . . . . . . 16
. . . . . . . . . . . . . . . . . . 17
. . . . . . . . . . 17
19
20
. . . . . . . . . . . 20
21
. . . . . . . . . . . . . . . . . . 21
21
. . . . . . . . . . . . . . . . 22
. . . . . . . . . . 22
. . . . . . . . . . . . . . . . . . . . 23
. . . . . . . . . . . . . . . . . . 24
. . . . . . . . . 24
. . . . . . . . 24
24
24
. . . . . . . . . . . . . . 27
. . . . . . . . . . . . . . . . . . . . 27
28
Towing the Traction Unit
Operating Characteristics
Selecting the Clip Rate (Reel Speed)
Training Period . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Before Mowing . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transport Operation . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Clean-Up After Mowing
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Maintenance Schedule
Daily Maintenance Checklist
Service Interval Chart
Greasing the Bearings and Bushings
Removing the Hood . . . . . . . . . . . . . . . . . . . . . . . .
General Air Cleaner Maintenance
Cleaning the Radiator and Screen
Changing the Engine Oil and Filter
Changing the Hydraulic System Fluid and Filter
Hydraulic System Test Ports
Replacing the Fuel Filter
Adjusting the Transmission for Neutral
Adjusting the Belts . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting the Traction Pedal
Adjusting the Traction Pedal Damper
Adjusting the Hand Brake
Battery Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storing the Battery . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Backlapping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Schematic . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Schematic (Model No. 03422-2WD)
Hydraulic Schematic (Model No. 03427-3WD)
California Emission Control System Warranty
Statement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty

Introduction

Read this manual carefully to learn how to operate and
maintain your product properly. The information in this
manual can help you and others avoid injury and product
damage. Although Toro designs and produces safe
products, you are responsible for operating the product
properly and safely.
Whenever you need service, genuine Toro parts, or
additional information, contact an Authorized Service
Dealer or Toro Customer Service and have the model and
serial numbers of your product ready. The two numbers are
stamped into a plate that is riveted to the frame at the rear
of the mower.
2
Page
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
.
.
. . .
All Rights Reserved
Printed in the USA
28
29
29
30
30
30
30
31
31
32
33
33
35
35
36
36
36
37
37
38
39
39
40
40
40
41
41
41
43
44
45
49
52