Molex Connector Assembly Procedure; Solderless Contact Terminal Assembly Using Pliers - Honeywell BENDIX KING KT 73 Installation Manual

Preliminary - Subject To Change Without Notice
BENDIX/KING
In retrofit installations where a Configuration Module does not exist, the KT 73 will recognize this
condition and operate from the data contained in the internal memory. In this arrangement, the
configuration data will be lost when the KT 73 is replaced with a different unit, such as a loaner,
and must be re-entered.
To program the aircraft address and/or the maximum air speed please refer to Section 3.2.
2.3.5.5 Antenna
For L-band blade antenna outline drawing, installation procedures, and mounting dimensions, re-
fer to the manufacturer's instructions.
2.3.6

MOLEX CONNECTOR ASSEMBLY PROCEDURE

The KT 73 uses a special connector that mates directly with the printed circuit board inside the
unit (see Figure 2-1). Assemble the connector using the following procedure:
2.3.6.1 Solderless Contact Terminal Assembly using Molex Crimper
Refer to instructions in Figure 2-1.
2.3.6.2

Solderless Contact Terminal Assembly using Pliers

(1) Strip each wire 5/32 inches for contact terminal (P/N 030-01107-0024). The last two
digits of the contact terminal part number indicates the number of terminals fur-
nished.
(2) Tin the exposed conductor.
(3) Using needle nosed pliers, fold over each conductor tab, in turn, onto the exposed
conductor. when both tabs have been folded, firmly press the tabs against the con-
ductor.
(4) Repeat step (3) for insulator tabs.
(5) Apply a small amount of solder (using minimum heat) to the conductor/tab connec-
tion to assure a good electro-mechanical joint.
Rev 0, October/2002
NOTE:
THE AIRCRAFT MODE S ADDRESS MUST BE OB-
TAINED FROM FAA AND PROGRAMMED INTO
THE KT 73 OR EXTERNAL ADDRESS EEPROM.
FOR US REGISTERED AIRCRAFT, THE ICAO
AIRCRAFT ADDRESS CODE CAN BE FOUND ON
THE AIRCRAFT REGISTRATION.
AIRCRAFT MODE S ADDRESSES MAY BE OB-
TAINED BY CALLING THE FAA AIRMAN AND AIR-
CRAFT REGISTRY DIVISION AT (405)-954-3116.
IF THREE (3) OR MORE ADDRESSES ARE NEED-
ED, WRITE TO AIRCRAFT REGISTRATION
BRANCH, ANV-450, P.O. BOX 25082, OKLAHOMA
CITY, OK 73125.
10563I00.JA
KT 73
Page 2-9