The Generator; Specifications - Honeywell 10 kW Owner's Manual

For generators 12 kW and greater, the Emission Control System
code is EM (Engine Modification) and consists of the following
components:
• Air Induction System
~ Intake Pipe / Manifold
~ Air Cleaner
• Fuel Metering System
~ Carburetor/Mixer Assembly
~ Fuel Regulator
• Ignition System
~ SparkPlug
~ Ignition Module
• ExhaustSystem
~ Exhaust Manifold
~ Muffler
Ts THE generator
Figure 1.1 - 10kW, V-twin, GT-530 Engine
(door removed)
Exhaust
Enclosure
Composite Base Oil Filter Battery Compartment
Figure 1.2-12, 15and20kW, V-twin,
GT-990/GT-999 Engine (door removed)
Fuel
Regulator
Fuel Inlet
(back)
— Fuel
Regulator
Composite Base
Oil Filter Battery Compartment
General Information
1.6 SPECIFICATIONS
1.B.1 GENERATOR
Model
10 kW 12 kW
15 kW 20 kW
RatedVoltage
240
Rated Maximum Load Current
(Amps) at 240Volts (LP)*
41.6
50.0
62.5
83.3
Main Circuit Breaker
45 Amp
50 Amp
65 Amp
100 Amp
Phase
1
Number ot Rotor Poles
2
Rated AC Frequency
60 Hz
Battery Requirement
Group 26R, 12 Volts and 525 CCA Minimum
Weight (unit onlyin lbs.)
353
439
421 450
Enclosure
Aluminum Steel
Aluminum
Normal Operating Range
This unit is tested in accordance to UL 2200 standards
with anoperating temperature of20 °F (-29 °C) to 122
°F. (50 °C). For areas where temperatures fall below 32
°F (0°C), a cold weather kit is highly recommended.
When operated above 77° F (25° C)there may be a
decrease inengine power. (Please reference the engine
specifications section).
These generators are rated in accordance with UL2200, Safety Standard for Stationary
Engine Generator Assemblies; and CSA-C22.2 No. 100-04 Standard for Motors and
Generators.
* Natural Gas ratings will depend onspecific fuel Btu content. Typical derates are
between 10-20%offthe LPgas rating.
**Circuits tobemoved must beprotected by same size breaker. For example, a 15amp
circuit inthe main panel must be a 15 amp circuit inthetransfer switch.
1.6.2 ENGINE
Model
10 kW 12 kW
15 kW 20 kW
Type of Engine GT-530
GT-990
GT-990 GT-999
Numberof Cylinders 2
Rated Horsepower @
3,600 rpm'
18
32
32 36
Displacement 530CC
992CC 992CC
999CC
Cylinder Block
Aluminum w/Cast Iron Sleeve
ValveArrangement
Overhead Valves
Ignition System
Solid-state w/Magneto
RecommendedSpark Plug BPR6HS RC14YC
RC14YC RC12YC
Spark Plug Gap 0.76 mm
(0.030 inch)
1.02 mm
(0.040 inch)
1.02 mm
(0.040 inch)
0.76 mm
(0.030 inch)
Compression Ratio 9.5:1 9.5:1
9.5:1 9.5:1
Starter
12VDC
Oil CapacityIncluding Filter
Approx. 1.7
Qts
Approx. 1.9
Qts
Approx. 1.9
Qts
Approx. 1.9
Qts
Recommended Oil Filter
Part # 070185F
Recommended Air Filter
Part #
0E9581
Part #
0C8127
Part #
0C8127
Part#
0G5894
Operating RPM 3,600
• Engine power is subject to andlimited bysuchfactors as fuel Btu content, ambient
temperature andaltitude. Engine power decreases about 3.5percent for each 1,000 feet
above sea level; and also will decrease about 1 percentfor each 6 C (10 F)above 16 C
(60 F) ambient temperature.