Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for SpeeCo LS401221N
Summary of Contents for SpeeCo LS401221N
- Page 1 VERTICAL/HORIZONTAL LOG SPLITTERS MODEL NO. LS401216N MODEL NO. LS401221N 22 TON 25 TON Owner’s Manual ASSEMBLY & OPERATING INSTRUCTIONS MODEL NO. LS401224N MODEL NO. LS401213N 34 TON 28 TON THIS SAFETY ALERT SYMBOL IDENTIFIES IMPORTANT SAFETY MESSAGES IN THIS MANUAL...
-
Page 2: Table Of Contents
Towing Safety ........................Assembly Instructions ........................Operating Instructions ........................Engine Oil Recommendations ....................Starting Instructions ....................... Towing ..........................Operation ..........................Maintenance ............................Parts List for Models LS401221N, LS401213N, LS401216N and LS401224N ..........10-11 Parts Breakdown Illustration ....................... Notes ..............................Specifications ..........................Back Cover... -
Page 3: Important Safety Information
WARNING: Read and thoroughly understand all instructions and safety information before assembling or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone to operate this log splitter who has not read this manual. As with all power equipment a log splitter can be dangerous if assembled or used improperly. - Page 4 PART NUMBER: 510105700 LOCATION: TOP, FORWARD SECTION OF HYDRAULIC CYLINDER PART NUMBER: 52023200 LOCATION: HYDRAULIC TANK LOWER TANK, RIGHT CORNER PART NUMBER: 51018900 LOCATION: TOP OF HYDRAULIC CYLINDER Page 2...
-
Page 5: General Safety
GENERAL SAFETY Failure to follow these instructions may result in serious injury or death. EVER NEVER allow children or adults lacking proper instructions and understanding to operate this log splitter. KEEP all people and pets a minimum of 10 feet away from your work area when operating this log splitter. Only the operator is to be near the log splitter during use. -
Page 6: Repair And Maintenance Safety
KNOW how to stop the log splitter and disengage the controls before operating it. NEVER place hands or feet between the log and splitting wedge during forward or reverse stroke. Serious injury or death could result. NEVER straddle or step over the log splitter during operation. NEVER reach or bend over the log splitter to pick up a log. -
Page 7: Hydraulic Safety
HYDRAULIC SAFETY The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to replace frayed, kinked, cracked or otherwise damaged hydraulic hose and components. NEVER check for leaks of hydraulic fluid with your hand. Fluid escaping from a small hole can be almost invisible. Escaping fluid under pressure can have sufficient force to penetrate skin causing serious personal injury or even death. -
Page 8: Towing Safety
IMPORTANT NOTE: This log splitter is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark ar- rester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in efffective working order by the operator. -
Page 9: Assembly Instructions
EMBLY INSTRUCTIONS NOTE: The following instructions pertain to four SpeeCo log splitters, the 22 ton (LS401221N), 25 ton (LS401216N), 28 ton (LS401213N) and the 34 ton (LS401224N). The four models share most of the component parts. Any differences are noted in the parts list and assembly instructions. -
Page 10: Engine Oil Recommendations
STEP 2: The hydraulic reservoir should be filled with an SAE 20 hydraulic oil. If hydraulic oil is difficult to obtain, automatic transmission fluid can be substituted and should be used instead of hydraulic oil when temperatures are below 32 degrees F. Use only clean oil and take care to prevent dirt from entering the hydraulic reservoir. -
Page 11: Towing
STEP 3: The engine maximum governed speed is preset at the factory at 3600 RPM no load speed. When splitting wood, the throttle should be set at the maximum setting to develop the horsepower required for the pump. TOWING The log splitter is equipped with pneumatic tires, a Class I coupler (2 in. diameter ball required) and safety chains. Before towing, the safety chains must be secured to the hitch or bumper of the vehicle. -
Page 12: Parts List For Models Ls401221N, Ls401213N, Ls401216N And Ls401224N
PARTS BREAKDOWN FOR LS401221, LS401216, LS401213 AND LS401224 LOG SPLITTERS c i t / l a i r o t t i l c i t / l a i r o t t i l c i t / l a i r o t t i l c i t... - Page 13 PARTS BREAKDOWN FOR LS401221, LS401216, LS401213 AND LS401224 LOG SPLITTERS " 6 " 6 " 4 " 4 " 4 " 4 " 4 ) s l i t s i t s " 2 " 2 " 2 " 2 I "...
-
Page 14: Parts Breakdown Illustration
Page 12... -
Page 15: Notes
NOTES Model No. ____________________ Serial No. _____________________________ Date of Purchase _______________ Place of Purchase _______________________ _______________________ _______________________ _______________________ Page 13... -
Page 16: Specifications
SPECIFICATIONS i r e . P . g i r & r t S t t a . P . g i r & r t S t t a . P . g i r & r t S t t a g i r &...
Need help?
Do you have a question about the LS401221N and is the answer not in the manual?
Questions and answers