Related Manuals for Toro 22472
Summary of Contents for Toro 22472
- Page 1 Form No. 3396-375 Rev B Trench Filler Compact Utility Loader Model No. 22472—Serial No. 315000001 and Up *3396-375* B Register at www.Toro.com. Original Instructions (EN)
-
Page 2: Table Of Contents
Note emphasizes general information worthy of special attention. Introduction Contents The trench filler is an attachment designed for use on Toro compact utility loaders to fill trenches dug by a trencher with loose soil left by the trenching process. Safety ................3 General Trench Filler Safety........ -
Page 3: Safety
Safety WARNING When the engine is off, attachments in the raised Improper use or maintenance by the operator or owner position can gradually lower. Someone nearby may can result in injury. To reduce the potential for injury, be pinned or injured by the attachment as it lowers. comply with these safety instructions and those in the traction unit Operator's Manual . -
Page 4: General Trench Filler Safety
Toro Trench Filler Safety safety glasses or eye shields during operation or while performing an adjustment or repair. The following list contains safety information specific to Toro • Wear appropriate clothing including substantial footwear, products or other safety information that is not included in safety glasses or eye shields, long pants, and hearing the ANSI or ISO standards. -
Page 5: Stability Ratings
Safety and Instructional replacement parts and accessories. Replacement parts and accessories made by other manufacturers could be Decals dangerous, and such use could void the product warranty. • Always transport the trench filler in a lowered position. Safety decals and instructions are easily visible to the operator and are located near any area of potential danger. -
Page 6: Product Overview
A selection of Toro approved attachments and accessories is available for use with the machine to enhance and expand its capabilities. Contact your Authorized Service Dealer or Distributor or go to www.Toro.com for a list of all approved attachments and accessories. -
Page 7: Operation
Operating Tips Operation • Clean the area of trash, branches, and rocks before trench Refer to your traction unit Operator’s Manual for more filling to prevent equipment damage. information on installing and removing attachments on your • For best trench filling, center the unit over the trench traction unit. -
Page 8: Maintenance
Maintenance Recommended Maintenance Schedule(s) Maintenance Service Maintenance Procedure Interval • Check the bolts and nuts securing the auger. Before each use or daily • Grease the auger bearing. Every 200 hours • Adjust the skids. Yearly or before storage • Paint chipped surfaces. CAUTION If you leave the key in the traction unit ignition switch, someone could accidently start the engine and seriously injure you or other bystanders. -
Page 9: Storage
Storage 1. Before long term storage, wash the attachment with mild detergent and water to remove dirt and grime. 2. Grease the auger bearings. 3. Check and tighten all bolts, nuts, and screws. Repair or replace any damaged or worn parts. 4. -
Page 10: Troubleshooting
Troubleshooting Problem Possible Cause Corrective Action The attachment does not operate. 1. A hydraulic coupler is not completely 1. Check and tighten all couplers. connected. 2. A hydraulic coupler is damaged. 2. Check the couplers and replace any that are damaged. 3. - Page 11 Notes:...
- Page 12 Notes:...
- Page 13 Notes:...
- Page 14 The method of transmission shall be electronic transmittal. This machinery shall not be put into service until incorporated into approved Toro models as indicated on the associated Declaration of Conformity and in accordance with all instructions, whereby it can be declared in conformity with all relevant Directives.
- Page 15 The Way Toro Uses Information Toro may use your personal information to process warranty claims, to contact you in the event of a product recall and for any other purpose which we tell you about. Toro may share your information with Toro's affiliates, dealers or other business partners in connection with any of these activities. We will not sell your personal information to any other company.
- Page 16 Toro importer. If all other remedies fail, you may contact us at Toro Warranty Company. Australian Consumer Law: Australian customers will find details relating to the Australian Consumer Law either inside the box or at your local Toro Dealer.