Table Of Contents; Contents - Toro 03540 Operator's Manual

Warning
The engine exhaust from this product contains
chemicals known to the State of California to cause
cancer, birth defects, or other reproductive harm.
Important The engine in this product is not equipped
with a spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered, or
grass-covered land as defined in CPRC 4126. Other states
or federal areas may have similar laws.

Contents

Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safe Operating Practices
Toro Mower Safety . . . . . . . . . . . . . . . . . . . . . . . .
Sound Pressure Level . . . . . . . . . . . . . . . . . . . . . .
Sound Power Level . . . . . . . . . . . . . . . . . . . . . . .
Vibration Level . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications . . . . . . . . . . . . . . . . . . . . .
Measurements . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Equipment . . . . . . . . . . . . . . . . . . . . . . .
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loose Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connecting the Battery . . . . . . . . . . . . . . . . . . . . .
Mounting the Hood Latch
Replacing the Panel Fasteners
Checking the Tire Pressure
Installing the Cutting Units
Adjusting the Turf Compensation Spring
Lifted Height of Outer Front Cutting Units (Enable
Position) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installing the Rear Weight
Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the Engine Oil
Checking the Cooling System
Filling the Fuel Tank . . . . . . . . . . . . . . . . . . . . . .
Checking the Transmission Fluid
Checking the Hydraulic Fluid
Checking the Rear Axle Lubricant
2001 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Page
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
10
10
11
11
12
12
12
. . . . . . . . . . . . . . . . . . 13
. . . . . . . . . . . . . . . 14
. . . . . . . . . . . . . . . . . . 14
. . . . . . . . . . . . . . . . . 14
. . . . . . . 16
17
. . . . . . . . . . . . . . . . . . 17
18
. . . . . . . . . . . . . . . . . . . 18
. . . . . . . . . . . . . . . 18
19
. . . . . . . . . . . . . 19
. . . . . . . . . . . . . . . 19
. . . . . . . . . . . . 20
Checking Reel to Bedknife Contact
Checking the Torque of the Wheel Nuts
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting and Stopping
Bleeding the Fuel System
Setting the Reel Speed
Adjusting the Lift Arm Down Pressure
Towing the Traction Unit
Diagnostic Light . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic ACE Display
Checking the Interlock Switches
Hydraulic Valve Solenoid Functions
Operating Characteristics
Logic Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Maintenance Schedule
2
Daily Maintenance Checklist
3
Service Interval Chart
3
Greasing the Bearing and Bushings
3
Servicing the Air Cleaner
4
Engine Oil and Filter
5
Servicing the Fuel System
6
Bleeding Air from the Injectors
6
Servicing the Engine Cooling System
6
Servicing the Engine Belts
Adjusting the Throttle
Changing the Hydraulic Fluid
Replacing the Hydraulic Filter
Checking the Hydraulic Lines and Hoses
Hydraulic System Test Ports
Adjusting the Traction Drive for Neutral
Adjusting the Cutting Unit Lift Rate
Checking and Adjusting the Traction Linkage
Adjusting the Service Brakes
Changing the Transmission Fluid
Replacing the Transmission Filter
Changing the Rear Axle Lubricant
Adjusting Rear Wheel Toe-In
Servicing the Battery
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Lighting
Backlapping the Cutting Units
Electrical Schematic
Hydraulic Schematic
Preparation for Seasonal Storage
The Toro General Commercial Products Warranty
2
. . . . . . . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . .
. . . . . . . . . .
. . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .
All Rights Reserved
Printed in the USA
20
20
21
21
23
23
24
25
25
26
26
26
28
28
29
30
30
31
32
32
34
35
35
36
37
38
38
39
39
40
40
40
41
42
42
42
43
43
43
44
45
45
45
47
48
49
. . 52