Maintenance & Adjustment - Cub Cadet RZT-S Zero Operator's Manual

Maintenance & Adjustments
Maintenance Schedule
Lube Front Caster Wheels and Wheel Spindles
Lube Pedal Pivot Points
Grease Front Castings
Check Blades
Charge Battery
Check Hardware
NOTE: The electrical components on this rider are not
serviceable. Please contact an authorized Cub Cadet service
dealer for any service needs.
WARNING!
service personnel using only identical replacement
parts. This will ensure that the safety of the rider is
maintained.
Maintenance
WARNING!
repairs, stop the rider, disengage blades, set parking
brake and remove key to prevent unintended starting
of the blades or movement of the rider.
Battery Storage
1. The batteries should be stored with a full charge. Discharged
batteries can freeze faster than charged batteries in cold
temperatures.
2. The battery charger should remain connected to the charging
port on the rider when not in use.
3. If keeping the charger connected during off-season storage is
not possible, the batteries should be fully charged once every
month.
NOTE: It will take approximately 16 hours to fully charge the
batteries. Leaving the batteries connected to the charger
for more than 16 hours will not damage the batteries.
4. Batteries should not be kept in a discharged state. Permanent
damage to the batteries can occur.
5. Fully charge batteries once a month during off-season storage.
6. Fully recharge the batteries before returning to service.
20
Prior to Use
P
P
P
Have your rider serviced by qualified
Before performing any maintenance or
Every Every
10 Hours 25 Hours
P
P
P
Charging the Batteries
CALIFORNIA PROPOSITION 65 WARNING
Battery posts, terminals, and related accessories
contain lead and lead compounds, chemicals known
to the State of California to cause cancer and
reproductive harm. Wash hands after handling.
WARNING:
The battery contains corrosive fluid
and toxic material — HANDLE WITH CARE. Keep
away from children. Do not puncture, disassemble,
mutilate, or incinerate. Explosive gases could be
vented during charging or discharging. Use in a well
ventilated area, away from sources of ignition.
WARNING!
Recharge only with the charger
specified by the manufacturer. A charger that is
suitable for one type of battery pack may create a
risk of fire when used with another battery pack.
WARNING!
Do not charge or operate the rider in the
rain or in wet locations.
NOTE: The batteries in your rider are not expected to last for
the life of your rider. Rechargeable batteries degrade with time
and use. The batteries may eventually need to be replaced. To
have the batteries replaced, contact your authorized Cub Cadet
Service Dealer.
NOTE: Replace batteries if battery capacity drops below 50% of
initial capacity
NOTE: Using old or faulty batteries could cause a system fault
that results in loss of power
6
Every Prior to Off-Season
50 Hours Storage
P
P
P
P
!