Safety Information - Black & Decker BD17204 Instruction Manual

SAFETY INFORMATION

WARNING
Before you assemble or operate this unit, please
carefully read this entire manual. Failure to do
so may result in a fire, explosion, injury or death.
• The installation of this unit must adhere to
local codes or Propane Storage and Handling
Code, CSA B149.2.
• THIS UNIT IS INTENDED FOR OUTDOOR
USE ONLY! This product shall be used
outdoors, in a ventilated space and shall not
be used in any enclosed area.
• This unit is to be used with propane gas only!
(sold separately)
• Do not attach a remote gas supply to this
unit.
• Only use propane gas for this unit.
• This unit is not intended for natural gas.
• Converting this unit to natural gas is
dangerous and not recommended. The
conversion of this unit will void the
manufacturer warranty.
• Do not use any solid fuel or charcoal for this
unit.
• If the propane gas tank is leaking gas, you
may see or smell it, or hear a hiss. Do the
following:
1. Disconnect the propane gas tank. 2. Do
not attempt to fix the problem yourself. 3.
Contact your propane gas supplier or fire
department for help.
• Applying too much propane may result in
gas pooling and will not burn. Allow fresh air
into the unit so that the remaining gas may
escape.
• Do not use a flame to check for gas leaks.
• Manifold pressure: 11 in w.c. (2.74kPa).
• Use propane tanks with the following
dimensions: diameter 12 in, height 18 in. -
capacity 20 lbs.
• You must use a propane tank that has a collar
to protect the gas valve.
• DO NOT fill tank over 80 percent full.
• The tank system must be set up for vapor
withdrawal.
• Discontinue use if any part of the propane
tank is damaged. Rust and dents may be
hazardous and should be inspected by a gas
supplier.
• Do not burn anything other than the
provided materials for this patio heater.
• Do not operate unit until all parts are fully
assembled.
• Do not paint or color any part of this heating
unit.
• Unit may be hot while in use, do not attempt
to move it while in use.
• Never leave this heating unit unattended
while in use.
• This unit is not intended for cooking.
• Keep any flammable items away.
• Keep a safe distance from heating unit to
avoid burning skin or clothing.
• Do not sit or rest hands or feet on this
heating unit.
• Never place hands or fingers on upper
portion of this unit while in use.
• Keep all electrical cords and fuel supply hose
away from heated surfaces.
• Combustible material should not be within
48 inches of the top of the unit, or within 48
inches around the entire unit.
• Keep the appliance area clear and free from
combustible material, gasoline and other
flammable vapors and liquids.
• If the flame goes out while burning, turn
the gas valve off. Wait 5 minutes before
repeating the initial lighting procedure. Once
you have a flame started, hold down the
control knob for 1 minute.
• Do not add water into the unit.
• Do not operate unit if any part has been
under water. Call a service technician to
replace any damaged parts should this occur.
• Do not disconnect any part while unit is in
use.
• Do not store a spare propane tank under or
near this appliance.
• If the heating unit is indoors, detach the
propane tank and leave outdoors.
• Do not operate on a boat or vehicle. This
unit must be used on a flat level surface and
outdoors ONLY.
• Always remove protective cover before
operating (if applicable).
• Check for leaks after not using the unit for
long periods of time.
• Children should never operate this unit.
Children must be supervised while near this
unit.
• Keep gas tank at least 5 feet away from unit
when lit. (if external tank)
• The maximum gas supply: 250psi; Min. gas
supply:10 psi.
• All installation and repair should be done
by a qualified professional. This unit
should be inspected annually and cleaned
regularly.
• Inspect all elements of this heating unit
before each use. If there is damage, the
burner must be replaced.
• Be aware of the hazards of high
temperatures and stay away from the unit to
avoid any burns or injury.
• The gas supply tank should be constructed
and marked in accordance with the
specifications for the LP-gas cylinders of the
U.S. Department of Transportation (DOT) or
CSA B339;
• The propane gas tank must have a listed
5