Black & Decker 2 MILLION Power Series User Manual page 13

Corded, cordless, rechargeable

Hide thumbs Also See for 2 MILLION Power Series:

User's manual and warranty information (6 pages)

Table Of Contents

Table of Contents

Available languages

U U s s i i n n g g t t h h e e B B u u i i l l t t - - I I n n W W o o r r k k s s t t a a n n d d

Turn the Spotlight upside-down on a smooth even surface, and rest it on the

Workstand/Carry Handle.

U U s s i i n n g g t t h h e e B B u u i i l l t t - - I I n n C C a a r r r r y y L L a a n n y y a a r r d d

The Carry Lanyard may be used to store or carry the Spotlight. Adjust the slide on the

cords to keep the Lanyard secure around the supporting object.

C C A A R R E E A A N N D D M M A A I I N N T T E E N N A A N N C C E E

All batteries lose charge with time, especially when they are warm. Recharge the unit

every two months when not in frequent use, preferably using the 120 volt AC method.

Never submerge the unit in water. If the unit gets dirty, gently clean the outer surfaces of

the spotlight unit with a soft cloth moistened with a mild solution of water and detergent.

The quartz halogen bulb is the only user-replaceable part in the Spotlight. Periodically

inspect the condition of adapters, connectors and wires. Contact your Service Center

to replace any components that have become worn or broken.

S S p p o o t t l l i i g g h h t t B B u u l l b b R R e e p p l l a a c c e e m m e e n n t t

To replace the bulb, you will need a small Phillips screwdriver and a 12 volt H3 75

watt replacement bulb. During installation, avoid touching the glass part of the bulb.

Bulb life may be shortened by installing a bulb with dirt or fingerprints on it. The bulb

can be wiped clean with a cloth moistened with alcohol.

Q Q U U A A R R T T Z Z H H A A L L O O G G E E N N

B B U U L L B B

R R E E T T A A I I N N I I N N G G R R I I N N G G

R R U U B B B B E E R R G G U U A A R R D D C C O O V V E E R R

1. Disconnect the unit from any charging adapters.

2. Push the rubber bezel forward toward the front of the spotlight to reveal two

small Phillips screws in the retaining ring.

3. Using the screwdriver, remove (counterclockwise) the two screws. Set them aside.

4. Lift off the retaining ring, glass lens and rubber "O" ring and set them aside.

5. Carefully remove the reflector and bulb assembly.

T T R R I I G G G G E E R R

R R E E F F L L E E C C T T O O R R

T T R R I I G G G G E E R R L L O O C C K K

R R U U B B B B E E R R

" " O O " " R R I I N N G G

B B U U L L B B

6. Disconnect the bulb wire from the red power wire.

7. Unsnap the hairpin retaining wires from the reflector's flange.

8. Using the screwdriver, loosen the retaining screw to remove the bulb from the

reflector (no need to completely remove this screw).

9. Lift out the bulb and detach wire.

10. Insert the replacement bulb into the reflector's flange.

11. Put back and secure the hairpin retaining wires.

12. Connect the bulb power wire to the red power wire.

13. Tighten the retaining screw on the flange.

14. Place the reflector in position in the body of the spotlight.

15. Replace the rubber "O" ring in the groove around the perimeter of the reflector.

16. Replace glass and retaining ring so the screw holes are aligned.

17. Secure retaining ring with two screws.

18. Replace rubber bezel.

19. Operate switch to ensure proper operation of spotlight.

R R U U B B B B E E R R

E E N N D D

W W A A R R N N I I N N G G

C C A A P P

T T o o r r e e d d u u c c e e t t h h e e r r i i s s k k o o f f e e l l e e c c t t r r i i c c s s h h o o c c k k , , r r e e p p l l a a c c e e b b u u l l b b w w i i t t h h 1 1 2 2 v v o o l l t t H H 3 3 7 7 5 5 w w a a t t t t o o n n l l y y . .

B B a a t t t t e e r r y y R R e e p p l l a a c c e e m m e e n n t t / / D D i i s s p p o o s s a a l l

B B a a t t t t e e r r y y R R e e p p l l a a c c e e m m e e n n t t

The battery should last the service life of the unit. Contact your Service Center for any

information you may need.

S S a a f f e e B B a a t t t t e e r r y y D D i i s s p p o o s s a a l l

Contains a maintenance-free, sealed, non-spillable, lead acid battery, which must

be disposed of properly. Recycling is required, contact your local authority for

information. Failure to comply with local, state and federal regulations can result in

fines, or imprisonment.

W W A A R R N N I I N N G G S S

• • D D o o n n o o t t d d i i s s p p o o s s e e o o f f t t h h e e b b a a t t t t e e r r y y i i n n f f i i r r e e a a s s t t h h i i s s m m a a y y r r e e s s u u l l t t i i n n a a n n e e x x p p l l o o s s i i o o n n . .

• • B B e e f f o o r r e e d d i i s s p p o o s s i i n n g g o o f f t t h h e e b b a a t t t t e e r r y y , , p p r r o o t t e e c c t t e e x x p p o o s s e e d d t t e e r r m m i i n n a a l l s s w w i i t t h h h h e e a a v v y y - -

d d u u t t y y e e l l e e c c t t r r i i c c a a l l t t a a p p e e t t o o p p r r e e v v e e n n t t s s h h o o r r t t i i n n g g ( ( s s h h o o r r t t i i n n g g c c a a n n r r e e s s u u l l t t i i n n i i n n j j u u r r y y

o o r r f f i i r r e e ) ) . .

• • D D o o n n o o t t e e x x p p o o s s e e b b a a t t t t e e r r y y t t o o f f i i r r e e o o r r i i n n t t e e n n s s e e h h e e a a t t a a s s i i t t m m a a y y e e x x p p l l o o d d e e . .

H H A A I I R R P P I I N N R R E E T T A A I I N N I I N N G G

W W I I R R E E S S

P P H H I I L L L L I I P P S S

H H E E A A D D

S S C C R R E E W W S S

R R E E F F L L E E C C T T O O R R

Table of Contents