Page 3
Your authorized representative checked the vehicle before it was delivered to you and will provide you a copy of the completed vehicle warranty registration form. Husqvarna is not liable for errors in this manual or for incidental or consequential damages that result from the use of the material in this manual.
Page 4
We hope you will consider this owner’s manual a permanent part of your Husqvarna vehicle. If you sell the vehicle, please include the manual so that the next owner will have the important operating, safety, and maintenance information it contains.
Safety Decal and Feature Identification SAFETY DECAL AND FEATURE IDENTIFICATION The following pages contain safety decal and feature identification information. For detailed information on specific features, read the appropriate section in this manual. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Page 5...
Page 8
Decal, ROPS Warning (on ROPS) 103526501 Decal, Bed Latch Operation (on bed latch) Decal, DOT 5 Brake Fluid (inside front cargo 103532701 compartment) Page 6 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Decal, Cab CO Warning (with cab door kit 103619901 accessory)
WARNING • This product contains or emits chemicals or substances that have been determined by the state of California to cause cancer and birth defects or other reproductive harm. Page 8 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
• A CAUTION with the safety alert symbol indicates a hazard or unsafe practice that could result in minor personal injury. CAUTION • A CAUTION without the safety alert symbol indicates a potentially hazardous situation that could result in property damage. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Safety Details Page 9...
• The vehicle will not provide protection from lightning, flying objects, or other storm-related hazards. If caught in a storm while driving this vehicle, exit the vehicle and seek shelter in accordance with applicable safety guidelines for your location. Page 10 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Page 13
Forward/Reverse handle in either the FORWARD or REVERSE position. The four-wheel drive system may engage any wheel(s), front or rear, depending on the mode selected (Figure 3). 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual General Warnings Page 11...
General Information Figure 3 4x4 Drive Warning GENERAL INFORMATION This manual includes operating procedures, maintenance, and regular servicing information for all HUV 4214, HUV 4414, and HUV 4414-XP vehicles. All operating procedures, maintenance, and regular servicing are identical unless otherwise noted.
• To avoid unintentionally starting or rolling the vehicle, set the park brake, place the Forward/Reverse handle in the NEUTRAL position, turn the key switch to the OFF position, and remove the key when leaving the vehicle. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Controls and Indicators Page 13...
Page 16
Failure to heed this caution could result in damage to the transmission. Page 14 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Figure 5 Instrument Panel...
Page 17
For adjustment of park brake, see Performance Inspection on page 20. See following WARNING. WARNING • The park brake has an over-center locking feature and should be firmly locked to prevent the vehicle from rolling. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Page 15...
Page 18
DIFF with a locked padlock icon and DIFF with an unlocked padlock icon. Push the handle up to engage the differential lock or pull the handle down to disengage the differential lock. Page 16 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Page 19
See following NOTE. NOTE: Using the headlights for extended periods while the engine is either off or idling will discharge the battery. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Controls and Indicators...
WARNING. WARNING • The ROPS must be properly installed before operating the vehicle. Husqvarna strongly urges that the vehicle’s occupants be properly restrained at all times with the seat belts provided. Pregnant woman: Consult your doctor for specific recommendations. The seat belt should be worn securely and as low as possible over the hips and not on the waist.
See following WARNING. WARNING • Make sure seat hinges and latches are securely engaged before operating the vehicle. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Seat Latch and Adjustment Page 19...
1.25 inches (3.2 cm). Brakes must be maintained so the brake pedal cannot be pressed to the floorboard under any circumstance. Page 20 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
• Children requiring a child safety seat must not ride on the vehicle. Comply with state and local laws pertaining to child safety. • Operate the vehicle from the driver seat only. WARNING CONTINUED ON NEXT PAGE 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Driving Instructions Page 21...
Page 24
10. Keep the brake pedal engaged, and select direction of travel by placing the shift handle in the desired position (Figure 5, Page 14). The engine must be at idle before the shift handle is moved. Page 22 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Page 25
CAUTION • When stopped on a hill, use the brake pedal to hold your position. Do not use the accelerator pedal to hold position. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Driving Instructions Page 23...
Do not drop cargo bed; lower gently and keep entire body clear. Failure to heed this warning could result in severe personal injury or death. Figure 8 Bed Latch Page 24 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
The vehicle arrives from the factory with the rear coil-over shocks pre-adjusted for optimum vehicle performance. CAUTION • Do not adjust the rear shock absorbers. Damage to the shock absorbers could result. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Bed Locking Pin Page 25...
Maximum payload capacity must be reduced accordingly when any option or accessory is installed on the vehicle. See following NOTE. Page 26 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
• Turn the key switch to the OFF position, remove the key, and leave the Forward/Reverse handle in the NEUTRAL position during storage. This is to prevent unintentionally starting the vehicle or a fire hazard. WARNING CONTINUED ON NEXT PAGE Page 28 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Page 31
When selecting valve position, ensure that it is fully opened or fully closed. Figure 11 Fuel Shut-off Valve 4.4. Disconnect the fuel vent line from the fuel tank vent nipple. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Storage ® ). Run...
Maintenance 4.5. Plug the fuel tank vent nipple so that it is air tight. Husqvarna recommends using a slip-on vinyl cap. Remove both spark plugs, and pour 1/2 ounce (14.2 mL) of SAE 10 weight oil through each of the two spark plug holes.
Periodic Service and Lubrication Schedule. Both the Periodic Service Schedule and the Periodic Lubrication Schedule must be followed to keep vehicle in optimum operating condition. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Periodic Service Schedule Page 31...
Page 34
Monthly service by owner or trained technician Semiannual service by trained technician only (or every 50 hours of operation, whichever comes first) Page 32 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual SERVICE Pre-Operation and Daily Safety Checklist Performance Inspection Engine/exhaust area Engine...
Clutch cover vent inlet filter (if equipped) LUBRICATION SERVICE POINTS 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Periodic Lubrication Schedule Check for leaks around gaskets, fill plugs, etc. Adjust valve clearance. See Briggs and Stratton Vanguard Model 2900000 Service Manual.
(safe level). See following CAUTION. CAUTION • Do not exceed recommended oil capacity. Doing so will decrease engine performance or result in damage to the engine. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Engine Oil Page 35...
Page 38
14.5 ft-lb (20 N·m). Replace the oil filler cap. 10. Replace the center access panel (1) (Figure 16), then lower and latch the cargo bed. Page 36 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Figure 16 Center Access Panel...
Page 39
Dispose of used oil according to the environmental laws and regulations for your area. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Engine Oil ®...
Page 40
Tighten the oil filter by hand 2/3 turn after gasket contact. Do not use a band wrench or channel lock pliers. Figure 20 Add Engine Oil Page 38 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Figure 19 Coat Rubber Seal...
Page 41
Using multi-grade oils (5W-30, 10W-30, and 10W-40) may increase oil consumption. If multi-grade oil is used, check the oil level more frequently. Figure 21 Oil Viscosity Chart 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Engine Oil Page 39...
106 in-lb (12 N·m). Use a funnel when filling the front differential through the lubricant level indicator hole (1). See Periodic Lubrication Schedule on page 33. Tighten the level indicator plug to 10 ft-lb (14 N·m). Figure 22 Front Differential Lubrication Page 40 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Place the housing cover on the top of the air filter housing. Secure the housing cover with both retaining clips. Replace the center plastic access panel (1) (Figure 16) and lower and latch the cargo bed. Page 42 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Replace the fuel cap. Ensure that the cap is tightened securely. Clean any spilled fuel from the cap or around the fuel cap area. 1. Fuel Cap 2. Fuel Tank Figure 28 Fuel Tank 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Fueling Instructions Page 43...
NOTE: A starting battery is recommended but a deep cycle battery can be used if necessary. Access battery by removing the seat bottom. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Using A Booster Battery (Jump Starting) Page 45...
• The diameter of all tires on the vehicle must be equal; otherwise the four-wheel drive system will not operate as intended and could result in severe personal injury or death. Never install tires of different diameters on the vehicle. 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual Accessories Page 47...
In the event a vehicle is bought as a used vehicle, we strongly urge the new owner to register the vehicle with Husqvarna. This will enable us to contact you if the need arises. Please send your name, address, and serial number of the vehicle to Husqvarna, 7349 Statesville Rd., Charlotte, NC 28269, Attention: Vehicle Registration.
Portable Refreshment Center, and all other original equipment options and accessories supplied by Husqvarna are warranted with respect to parts and labor against defects in material and workmanship for a period of one year or 1000 hours of operation, whichever first occurs, from the date of purchase.
Page 53
(“SORE”) must be designed, built and equipped to meet the State’s stringent anti-smog standards. HUSQVARNA shall warrant the emission control system on the vehicle engine for the periods of time listed below provided there has been no abuse, neglect or improper maintenance of your small off-road engine.
Page 54
- As the vehicle engine owner, you are responsible for the performance of the required maintenance listed in your owner’s manual. HUSQVARNA recommends that you retain all receipts covering maintenance on your vehicle engine, but HUSQVARNA cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled maintenance.
MANNER OR SHOWS INDICATIONS THAT IT HAS BEEN ALTERED IN ANY WAY, INCLUDING, BUT NOT LIMITED TO, MODIFICATION OF THE SPEED GOVERNOR, BRAKING SYSTEM, STEERING, TRANSAXLE, OR OTHER OPERATING SYSTEMS OF THE VEHICLE TO CAUSE IT TO PERFORM OUTSIDE HUSQVARNA SPECIFICATIONS. 4. HOW TO MAKE A WARRANTY CLAIM:...
Page 56
Portions of this publication are subject to copyright of Briggs & Stratton Corporation. Content on this page has been reproduced with the written permission of Briggs and Stratton Corporation. Page 54 2009 HUV 4214, HUV 4414, andHUV 4414-XP Owner’s Manual...
Page 57
Publication Part Number 103472540 Edition Code 0109A00000...