Toro BC-25 Operator's Manual page 4

Towing
Check with your local county or state safety towing
regulations, in addition to meeting Department of
Transportation (DOT) Safety Towing Regulations, before
towing the machine.
•
In order to reduce the possibility of an accident while
transporting the machine on public roads, make sure
the towing vehicle is mechanically sound and in good
operating condition.
•
Shut down the engine before transporting the machine.
•
Inspect the hitch and coupling for wear. NEVER tow the
machine with defective hitches, couplings, chains, etc.
•
Check the tire air pressure on both of the towing vehicle
and the machine. The chipper tires should be inflated to
60 psi (410 kpa) cold.
•
Check the tire tread for wear.
•
Properly attach the safety chains to the towing vehicle.
•
Ensure that the towing vehicle's directional, backup, and
brake lights are working properly.
•
Avoid sudden stops and starts. This can cause skidding,
or jack knifing. Smooth, gradual starts and stops will
improve towing.
•
Avoid sharp turns to prevent rolling. Tow only with a
vehicle that has a hitch designed for towing. Do not
attach towed equipment except at the hitch point.
Before towing check to make certain your machine is correctly
and securely attached to the towing vehicle.
•
Ensure that the ball hitch you are using is the proper size
for the hitch coupler on the machine.
•
Ensure that the safety chains are properly hooked to the
vehicle, leaving enough slack for turning.
•
Ensure that the jack stand is secured in the Up position.
•
Do not tow the machine faster than 45 mph (75 km/h).
•
Use caution when backing up; use a spotter outside the
vehicle to guide you.
•
Do not allow anyone to sit or ride on the unit.
•
Do not carry any cargo or wood on the unit when towing.
•
Disconnect the unit from the tow vehicle before using it.
•
Place chock blocks underneath the wheel to prevent
rolling while the unit is parked.
Preparation
Become familiar with the safe operation of the equipment,
operator controls, and safety signs.
•
Evaluate the terrain to determine what accessories and
attachments are needed to properly and safely perform
the job. Only use accessories and attachments approved
by the manufacturer.
•
Wear appropriate clothing including hard hat, face shield,
safety glasses, long pants, safety shoes, and hearing
protection. Long hair, loose clothing or jewelry may get
tangled in moving parts. Wear tight fitting gloves without
drawstrings or loose cuffs.
•
Use extra care when handling gasoline and other fuels.
They are flammable and vapors are explosive.
– Use only an approved container
– Never remove the gas cap or add fuel with the engine
running. Allow the engine to cool before refueling.
Do not smoke.
– Never refuel or drain the machine indoors.
– Replace the gasoline cap and tighten it securely.
– Keep the container nozzle in contact with the tank
during filling.
– If gasoline is spilled, wipe it off the engine and
equipment.
•
Ensure that the machine is on a level surface before
operating.
•
Always operate the machine from the side of the hopper.
•
Block the wheels of the machine to prevent unintended
movement.
Operation
•
Before starting this machine, review the
Safety (page 3) section. Failure to follow these
rules may result in serious injury to the operator or
bystanders.
•
Never run an engine in an enclosed area.
•
Only operate the machine in good light, keeping away
from holes and hidden hazards.
•
Only start the engine from the operator's position.
•
Do not pass or stand on the discharge side of the machine
when the engine is running or when the flywheel is
turning.
•
Ensure that all the guards and shields are securely in place
before operating.
•
Ensure that all interlocks are attached, adjusted properly,
and functioning properly.
•
Do not change the engine governor setting or overspeed
the engine.
•
Stop on level ground, and shut off the engine before
leaving the operator's position for any reason.
•
Chock the machine or keep it attached to the towing
vehicle when not in use to prevent the unit from rolling.
•
Keep hands and feet away from any moving parts.
•
Never carry passengers, and keep pets and bystanders
away.
•
Do not operate the machine under the influence of
alcohol or drugs.
4