Toro 59192 Installation Instructions Manual page 5

POTENTIAL HAZARD
A worn grass bag could allow small stones
and other similar debris to be thrown in
operator's or bystanders direction.
WHAT CAN HAPPEN
Thrown objects can cause serious personal
injury or death to operator or bystanders.
HOW TO AVOID THE HAZARD
Check the grass bag frequently. If it
damaged, install a new genuine TORO
replacement bag that has this or a similar
warning.
POTENTIAL HAZARD
Thrown objects may result if discharge
door does not close completely.
WHAT CAN HAPPEN
Thrown objects can cause serious personal
injury or death.
HOW TO AVOID THE HAZARD
If discharge door cannot be closed because
grass clippings clog discharge area, stop
engine and gently move discharge door
handle back and forth until door can be
closed completely. If door still cannot be
closed, remove obstruction with a stick, not
your hand.
Using Discharge Tunnel Plug
1. Make sure engine is shut off. Open the discharge
door by moving handle rearwards (Fig. 8). Hold
the discharge door handle to prevent the
spring–loaded door from closing while inserting
the plug.
2. Since the plug is slightly wider than the
discharge tunnel opening, you must rotate the
plug clockwise slightly while inserting it
(Fig. 8). Make sure the arrow on the plug decal
is pointing upwards.
Figure 8
1. Discharge door handle
3. Push the plug all the way in until the spring clip
on the bottom of the plug clicks into place,
locking the plug securely into the discharge
tunnel (Fig. 9) Release the discharge door handle
to lock the top of the plug.
4. To remove the plug, move the discharge door
handle rearwards while at the same time lift up
the spring clip on the bottom of the plug. When
the plug is unlocked, pull it out of the discharge
tunnel.
Figure 9
1. Spring clip
1
2
1914
2. Plug rotated clockwise
1
1915
5