Table of Contents
Advertisement
CHECKING GEARBOX OIL LEVEL
(1) The gearbox is fitted with a dip-
stick and oil filler plug, see fig 2e.
(2) Each engine is supplied with a
gearbox operators manual which
specifies the type of lubricating
oil to be used, the capacity and
frequency of changing of the oil.
Gearbox
TMC40M
TMC60M
PRM 80
PRM 120
PRM 150
PRM 260
ZF10M
ZF15M
TTMC 35A-2
Note: ATF is Automatic Transmission Fluid
FUEL SYSTEM
IMPORTANT
• Always fit a fuel/water separator
in the fuel supply system. Water
in the fuel can seriously damage
the injection system.
• If a fuel supply shutoff valve is
fitted do not use a taper tap, only
use a ball valve tap. The ball
valve type are more reliable and
less likely to let air into the fuel
system.
• Be sure to use a strainer when
filling the fuel tank. Dirt or sand
in the fuel may cause trouble in
the fuel injection pump.
• Always use diesel fuel.
• Do not use kerosene, which is
very low in cetane rating, and
adversely affects the engine.
• Be careful not to let the fuel tank
become empty, or air can enter
the fuel system, necessitating
bleeding before next engine start.
(3) New engines are normally
supplied with the gearbox topped
up with lubricant but Check the
level before starting the engine
for the first time.
(4) The oil can be changed via the
drain plug at the bottom of the
Lubricant
Use ATF Oil
Use ATF Oil
Use Engine Oil 15W40
Use Engine Oil 15W40
Use Engine Oil 15W40
Use Engine Oil 15W40
Use ATF Oil
Use ATF Oil
Use Engine Oil 15W40
(see page 28 for a typical installation)
• The fuel lift pump will only lift
fuel through 0.25 metres. If this
is insufficient then an electric fuel
lift pump must be fitted. Drawing
202-06421, illustrating the
wiring of a typical electric fuel lift
pump with ignition switched
relay can be supplied upon
request..
FUEL FILTER REPLACEMENT
1. The fuel filter is a spin on type.
Remove by turning anti-clockwise
when viewed from below.
2. Replace the fuel filter cartridge
every 750 hours. See fig. 2g.
3. Apply fuel oil thinly over the
gasket and tighten into position -
hand tight.
4. Bleed as detailed - see initial
start up.
(5) A guide to the type of oil to be
Capacity (approx)
0.2 litres
0.8 litres
0.6 litres
0.8 litres
1.4 litres
1.5 litres
0.35 litres
0.55 litres
0.65 litres
5. Check for leaks.
6. Do not get fuel on the flexible
box or sucked out with a hand
pump via the filler plug.
used is as follows:
Fig 2e
mounts.
Fig. 2g
Dip
stick
Oil
filler
plug
Oil drain
plug
Hide quick links:
Advertisement
Table of Contents
