Table of Contents
Advertisement
FUEL FILTER
WARNING
Do not replace the fuel filter when engine is hot.
The engine is equipped with an inline fuel filter.
Visually inspect the filter periodically for a build-up of
residue inside the filter body, and for a dirty element
which can be indicated by discoloration. Replace the
fuel filter when dirty.
HEADLIGHTS
Refer to SPECIFICATIONS when replacement of a
headlight bulb is necessary.
WARNING
Allow the engine and surrounding surfaces to
cool before changing the headlight bulbs.
Replace headlight bulbs as follows: (See Figure 30)
1. Unplug the wire harness leads from the headlight
socket terminals. Note which wire connects to
each terminal before disconnecting.
2. Rotate the socket assembly as follows to remove
from the reflector housing:
• Left headlight — appoximately 1/4 turn counter-
clockwise.
• Right headlight — approximately 1/4 turn clock-
wise.
3. Push the bulb inward and turn counterclockwise to
remove from the socket.
SOCKET TAB
REFLECTOR
NOTCH
Figure 30
4. Align a locking post of the bulb base with the notch
in the socket, then push the bulb inward and turn
clockwise to lock
5. With the terminals pointing upward, align the tab of
6. Connect the wire harness leads to the appropriate
FUSES
Always use the same capacity fuse for replacement.
Refer to SPECIFICATIONS. If the electrical system
does not function, check the fuses.
To replace a fuse, pull the old fuse from the fuse holder
and install the new fuse.
GENERAL BATTERY INFORMATION
TERMINAL
SOCKET
ALWAYS SHIELD EYES AND PROTECT SKIN AND
CLOTHING WHEN WORKING NEAR BATTERIES.
REFLECTOR
HOUSING
30
the socket with the notch of the reflector. Push the
socket inward and turn as follows to lock:
• Left headlight — appoximately 1/4 turn clock-
wise.
• Right headlight — approximately 1/4 turn coun-
terclockwise.
socket terminals.
WARNING
a. Battery posts, terminals and related accesso-
ries contain lead and lead compounds. Wash
Hands after handling.
b. Should battery acid accidentally splatter into
the eyes or onto the skin, rinse the affected
area immediately with clean cold water. If
there is any further discomfort, seek prompt
medical attention.
c. If acid spills on clothing, first dilute it with clean
water, then neutralize with a solution of
ammonia/water or baking soda/water.
d. NEVER connect (or disconnect) battery
charger clips to the battery while the charger is
turned on, as it can cause sparks.
e. Keep all sources of ignition (cigarettes,
matches, lighters) away from the battery. The
hydrogen gas generated during charging can
be combustible.
f.
As a further precaution, only charge the
battery in a well ventilated area.
DANGER
Batteries contain sulfuric acid and may emit
explosive gases. use extreme caution when
handling batteries. Keep batteries out of the
reach of children.
Hide quick links:
Advertisement
Table of Contents
