Sealey LS575VH.v2 Instructions For Use

thank you for purchasing a sealey product. manufactured to a high standard this product will, if used according to these instructions and
properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREfULLY. NOTE THE SAfE OPERATIONAL REQUIREmENTS, WARNINGS & CAUTIONS.
USE THE PRODUCT CORRECTLY AND WITH CARE fOR THE PURPOSE fOR WHICH IT IS INTENDED. fAILURE TO DO SO mAY CAUSE
DAmAGE AND/OR PERSONAL INJURY AND WILL INvALIDATE THE WARRANTY. PLEASE KEEP INSTRUCTIONS SAfE fOR fUTURE USE.
1. SAfETY INSTRUCTIONS
1.1. SAfETY AND mAINTENANCE.
3 Keep the log splitter clean for best and safest performance.
3 maintain the log splitter in a good condition (use an authorised service agent).
3 use a qualified person to lubricate and maintain the log splitter.
7 DO NOT top up hydraulic unit using brake fluid. use hydraulic jack oil only.
7 DO NOT operate the log splitter if damaged.
3 replace or repair damaged parts. Use genuine parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
1.2. WORKSHOP/ENvIRONmENTAL SAfETY.
3 locate the log splitter on dry, level and solid ground in a suitable work area with adequate lighting.
3 Keep the area clean and tidy and free from unrelated materials. do not leave tools, logs or other items lying around where they could become a
tripping hazard.
7 DO NOT operate the log splitter in wet or damp areas or expose it to rain.
7 DO NOT operate the log splitter in areas where fumes from paint, solvents, or flammable liquids pose a potential hazard.
1.3. OPERATOR SAfETY.
3 remove ill fitting clothing. remove ties, watches, rings and other loose jewellery, and contain long hair.
3 Wear protective, electrically non conductive gloves .
3 Always wear safety goggles. everyday spectacles are not sufficient protection.
3 maintain correct balance and footing, do not over-reach. ensure the floor is not slippery and wear non-slip, protective footwear.
7 DO NOT allow untrained persons to operate the log splitter.
7 DO NOT operate the log splitter with the guards or guides removed.
7 DO NOT operate the log splitter when you are tired or under the influence of alcohol, drugs or intoxicating medication.
3 the log splitter must always be operated by one person only.
3 Keep hands away from moving parts of the log splitter.
3 Keep hands away from splits and cracks which open in logs. they may close suddenly which could cause serious personal injury. for this
reason do not attempt to remove jammed logs by hand. A jammed log is a log which is only partially split and continues to grip the splitting
wedge.
1.4. SAfETY Of OTHERS.
7 DO NOT allow another person to help you with a jammed log.
3 Keep children and unauthorised persons away from the work area.
3 the log splitter must always be operated by one person only. other people must
keep a safe distance from the log splitter especially when it is in operation.
3 store the log splitter in a safe area away from children and other people not
qualified to use the log splitter.
1.5. GENERAL SAfETY.
7 DO NOT make any modifications to the log splitter.
7 DO NOT exceed the stated log capacity of the log splitter.
7 DO NOT use the log splitter for a task it is not designed to perform.
7 DO NOT force the log splitter to work beyond its specified capacity.
3 ensure that there are no nails, screws or other foreign objects in logs to be split.
3 the ends of logs should be cut square and also if possible logs should be cut to
a uniform length.
p WARNING! the warnings, cautions and instructions referred to in this manual
cannot cover all possible conditions and situations that may occur. It must be
understood that common sense and caution are factors which cannot be built into
this product, but must be applied by the operator.
3 When not in use, store the log splitter, with the hydraulic unit fully lowered, in a
safe, dry, childproof location.
2. INTRODUCTION & SPECIfICATION
safe and easy way to split logs, offering continuous sizing and up to
8tonne of pressure. seven tier wedge system allows workpiece to be as
near to wedge as possible so minimising splitting time. operated by foot
pump requiring a maximum of 15 strokes to capacity (without load) for
easy and fast splitting.
tier log lengths: . . . . . . . . . . . . . . . . . . . 300, 350, 400, 450, 500, 550, 600mm
maximum log diameter: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160mm
Vertical ram travel: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158mm
maximum load Pressure: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8tonne
overall size (W x d x H): . . . . . . . . . . . . . . . . . . . . . . . . . . 285 x 540 x 1040mm
Weight: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30kg
© Jack sealey limited
InstructIons for:
HYDRAULIC LOG SPLITTER 8TONNE
575mm CAPACITY vERTICAL TYPE
model:
Original Language Version
LS575vH.v2
ls575VH.V2 Issue: 1 - 07/02/13