Sealey AK451DX Quick Start Manual

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear protective
instruction gloves
manual
1. SAFETY
GENERAL SAFETY
1.1.
WARNING! Ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when
‰
using this equipment.
WARNING! DO NOT pollute the environment by allowing uncontrolled discharge of waste oil.
‰
WARNING! Disconnect the drainer from the air supply before changing accessories, servicing or performing any
‰
maintenance.
WARNING! Ensure correct air pressure is maintained and not exceeded.
‰
▲ DANGER! DO NOT release drain pan clamp lever when there is pressure in the reservoir as pipe and drain pan will be propelled upward
with force. This could result in damage and/or serious injury.
Dispose of waste oil in accordance with local authority regulations.
9
Familiarise yourself with the application and limitations of the oil drainer, as well as the potential hazards.
9
Maintain the drainer in good condition (use an authorised service agent).
9
Replace or repair damaged parts. Use genuine parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
9
Keep the work area clean, uncluttered and ensure there is adequate lighting.
9
Keep the drainer clean for best and safest performance.
9
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.
9
Keep children and unauthorised persons away from the working area.
9
When not in use disconnect from the air supply, vent reservoir and store in a safe, dry, childproof area.
9
Keep air hose away from heat, oil and sharp edges.
9
Check air hose for wear before each use, and ensure that all connections are secure.
9
DO NOT use the drainer for any purpose other than that for which it is designed.
8
DO NOT operate the drainer if any parts are damaged or missing as this may cause failure and/or personal injury.
8
DO NOT stand on the drainer.
8
DO NOT adjust or tamper with the safety valve.
8
DO NOT move the drainer by the hose, or yank the hose from the air supply.
8
DO NOT place attachments close to your face (especially eyes, ears, etc.) and DO NOT point hose at other persons or animals.
8
DO NOT allow untrained persons to operate the drainer.
8
DO NOT operate the drainer when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT leave the drainer operating unattended.
8
DO NOT direct air from the air hose at yourself or others.
8
2. INTRODUCTION
i
Steel fabricated 65ltr reservoir and telescopic steel drain pan fitted with grid filter. Air discharge drain with hose. Fitted with reservoir oil
level indicator tube.
3. SPECIFICATION
i
Capacity: ......................................................................... 65ltr
Min. Height to Pan: .................................................. 1070mm
Max. Height to Pan: ................................................. 1590mm
Gravity Feed: ................................................................... Yes
Air Discharge: ..................................................................Yes
Weight ....................................................................... 22.48kg
4. ASSEMBLY
Assembly - Refer to Parts List
4.1.
4.1.1. Close all valves on the drainer.
4.1.2. Screw drain pan (13) into ball valve (12) using securing bolt (16).
4.1.3. Loosen the handle retaining bolts (16) at the back of the reservoir, insert the handle (14) and tighten the bolts (16).
© Jack Sealey Limited
WASTE OIL DRAINER 65LTR AIR
DISCHARGE
MODEL NO:
Wear eye Wear protective
protection clothing
Original Language Version
AK451DX
AK451DX Issue 3 (H, F) 25/04/18