All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips 3141 785 31652 Version 1.2...
For the best performance of your DVD Portable. Formats: Check www.philips.com/support for latest software upgrades available. A) By CD-ROM Download the “PHILIPS.BIN” file from the Philips support site Unzip the file and then burn it into a CD-ROM to make a disc for upgrade...
Page 3
PHILIPS LOGO on the screen. Remove the card from the set Note: If you want to use the same card for audio / video playback on the set, please delete the “PHILIPS.BIN” first. Otherwise, it will be recognized as for software upgrade again.
Page 4
2.0 SAFTETY INSTRUCTIONS WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
2.1 ESD PROTECTION When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received. PREPARATION OF SERVICING Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened.
Page 6
SAFTY NOTICE SAFTY PRECAUTIONS LEAKAGE CURRENT CHECK Plug the AC line cord directly into a 120V AC outlet (do Measure the AC voltage across the 1500 resistor. not use an isolation transformer for this check). Use an The test must be conducted with the AC switch on and AC voltmeter, having 5000 per volt or more sensitivity.
4.0 MECHANICAL INSTRUCTION Disassembly Procedure Remove 6pcs of screws on front side of bottom cabinet. (Please note the left hand side screw is shorter than others, make sure do not put long screw during re-assembly, otherwise it will damage the middle cabinet!) Remove 2pcs of screw on top side of bottom cabinet.
Page 9
4.0 MECHANICAL INSTRUCTION Unplug another wire connector of Ipod board from main board. (right top side) To remove main board from cabinet, unplug / disconnect the wires on top side first. And then remove all screws on main board connected with bottom cabinet. To remove battery board and battery from cabinet, remove the screws on battery board connected with bottom cabinet first,...
Page 10
4.0 MECHANICAL INSTRUCTION Be careful not to broken the wire connection between battery and battery board. Otherwise you can re-soldering them as shown in picture. To remove DVD loader, unplug the wires connected with main board. And then remove the flex cable on the bottom side.
Page 11
4.0 MECHANICAL INSTRUCTION To remove the key board, remove the screws as shown in picture. To remove the Ipod board, remove the screws on slider cover and then remove some tapes attached on middle cabinet and wires. To remove front cabinet, remove the screw on display frame first.
Page 12
4.0 MECHANICAL INSTRUCTION Unplug the flex cable connected with TFT board at the backside also. To remove the TFT board ass’y, de- soldering the wires between speaker and TFT board. (Black wire is connected to “- ve” port and red wire is connected to “+ve” port)
5.0 TROUBLESHOOTING SYMPTOM: BATTERY NO POWER BATTERY CAN'T Power ON Start Check charging Check adaptor Check Battery capacity ? SET OK? function OK? power-ON OK? Check the Power-ON No Defect , return button and cable OK? set to Customer Replace Button or Replace Main Board Cable...
Page 14
5.0 TROUBLESHOOTING SYMPTOM: NO IMAGE / NO SOUND SYMPTOM: NO IMAGE OUTPUT ( THE PANEL SHOW BLUE PICTURE ) Start Check DVD Drive work ? Replace DVD Drive Check the external AV NOTE: AV Cable TYPE from outside to note Cable TYPE Exchange AV cable Inside L-Audio, R-Audio, Video, Ground...
Page 15
5.0 TROUBLESHOOTING SYMPTOM: THE DVD DRIVE DOES NOT WORK SYMPTOM: THE DVD DRIVE DOESN 'T WORK Start Check DVD-Loader Cable Reinsertion connection OK? Check the DVD-Loader Replace DVD- Loader Replace main board...
Page 16
5.0 TROUBLESHOOTING SYMPTOM: ADAPTOR CANNOT POWER ON Adaptor can not Power ON Start Check Adaptor OK? Change adaptor SET OK? Check the Power-ON Return set to Replace Main Board button and cable OK? Customer Replace Button or Cable...
Page 17
5.0 TROUBLESHOOTING SYMPTOM: REMOTE CONTROL CANNOT WORK SYMPTOM: THE REMOTE CONTROL CAN NOT WORK Start Check CABLE form bottom board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace IR receiver Replace top board Replace main board Return to custormer...
Page 18
5.0 TROUBLESHOOTING SYMPTOM: NO SOUND FROM HEADPHONE...
Page 19
5.0 TROUBLESHOOTING SYMPTOM: LED DISPLAY FAILURE SYMPTOM: LED Display Fail Start Check CABLE form Main board to top board Cable Reinsertion connection OK? Check TOP-board OK? Replace LED Replace top board Replace main board Return to custormer...
Page 20
5.0 TROUBLESHOOTING SYMPTOM: KEY & BOTTON FAILURE SYMPTOM: Key & Botton Fail Start Check CABLE form board to Cable Reinsertion board connection OK? Check KEY board OK ? Replace KEY board Replace main board Return to custormer...
6.0 OVERALL BLOCK DIAGRAM TFT DRIVER BOARD SPEAKER INVERT TFT:7" OR 8.5" SPEAKER DC9V D3031 + 8D02 LI-ON Battery 2000MAH /7" 2400MAH /7" TFT POWER TFT Video signal (Y/C/CVBS) DC JACK DC9V IN bright POWER CONTROL POWER DECTETION POWER DVD-SVIDEO VIDEO SW P74LV4066 VIDEO CVBS OUT...
5V USB POWER DATA TPA+ USB DATA L- DATA TPB- USB DATA L+ DATA TPB+ INPUT GND INPUT GND IPOD-CVBS IPOD/PI_O_R IPOD/PI_O_L AUI_O_R AUI_O_L PHILIPS SEMICONDUCTORS Title DCP750-DOCKING Size Document Number VER : 060613 Date: Monday, January 15, 2007 Sheet...
Page 33
Pos. 12NC 996510001972 MAIN PCBA DCP850/12 996510001511 IPOD PCBA DCP750 996510001513 KEY PCBA DCP750 TFT DRIVER PCBA DCP850 (WITH HINGE & HINGE HOUSING, SOLDERING IS 996510001978 REQUIRED TO CONNECT WIRE WITH SPEAKERS ON DISPLAY FRAME, REFER TO SECTION 4 ABOVE) BATTERY &...
Page 34
Pos. 12NC Description 8.5” PANEL FINAL 996510001973 ASS’Y 996510001515 DVD LOADER FFC 24P LINK DVD 996510001519 LOADER FRONT CABINET 996510001974 DCP850 BOTTOM CABINET 996510001975 DCP850 DISPLAY FRAME 996510001977 WITH SPEAK MIDDLE CABINET ASS’Y (WITH OPEN BUTTON, MEUN 996510001976 BUTTON, DVD...
Page 35
8.0 SERVICE PART LIST Mechanical Part List: Service Service Description Photo Pos. 12NC 996510001518 POWER BUTTON 996510001596 NAVIGATION BUTTON 996510001597 SLIDER COVER...
Page 36
8.0 SERVICE PART LIST Accessories Part List: Service Service Description Photo Pos. No. 12NC 996510001509 AC ADAPTOR/12 ACADAPTOR 996510004261 AC ADAPTOR/05 996510000788 AV CORD AVCABLE 996510001510 CAR ADAPTER CARADAPTOR 996510000790 30GB IPOD HOLDER HOLDER 996510000789 REMOTE CONTROL...