Napoleon BIB10 Owner's Manual
Hide thumbs
Also See for BIB10:
- Owner's manual (104 pages) ,
- Assembly manual (48 pages) ,
- Owner's manual (21 pages)
Table of Contents
Related Manuals for Napoleon BIB10
Summary of Contents for Napoleon BIB10
- Page 1 BUILT-IN SERIES Owner's Manual BIB10 BI 32 BIG32, BIG38 & BIG44 Grills illustrated in this manual may differ from model purchased. We Want Your Feedback! Visit Napoleon.com to write a review and register your grill. Apply Serial Number...
- Page 2 CONGRATULATIONS ON YOUR NAPOLEON GRILL! You’ve Just Upgraded Your Grilling Game. WE WANT YOUR GRILLING EXPERIENCE TO BE MEMORABLE AND SAFE. Please read and follow this Owner’s Manual before using your grill to avoid property damage, personal injury, or death.
-
Page 3: Table Of Contents
Do not use this grill for purposes other than intended. Do not operate this grill with a damaged cord, plug, or after the grill Infrared Grilling Guide malfunctions or has been damaged in any manner. Contact Napoleon for repair. WARNING! Installation & Assembly Cleaning Instructions Assemble this grill exactly as instructed in the Assembly Guide. -
Page 4: Full System Features
Integrated storage for rotisserie kits Easy access to drip pan with for more stainless steel roller bearings convenience for efficient maintenance The grills illustrated in this Owner’s Manual may differ from the model you purchased. Napoleon.com | BUILT-IN Series | Features... -
Page 5: Getting Started
CAUTION! The hook-up and installation of the gas and hose connection must be performed by a licensed gas fitter, and leak tested before operating the grill. CAUTION! Ensure the hoses do not contact any high temperature surfaces of the grill. WARNING! Accessible parts may be very hot. Keep young children away. Napoleon.com | BUILT-IN Series Getting Started |... -
Page 6: Locating Your Outdoor Gas Grill
25% of total wall 25% of total wall area area In the case of balconies, at least 20% of the total of the side, back and front wall areas shall be and remain open and unrestricted. Napoleon.com | BUILT-IN Series | Getting Started... -
Page 7: Cut-Out Dimensions
C = 5.7" (14.5 CM) MIN. (10.8 CM) MAX. For use with the installation of a Napoleon BI door. WARNING! The cabinet frame and the cabinet MUST be made from a non-combustible material when the appliance is not installed with the Zero Clearance Liner corresponding to your unit. Refer to the parts list in your Assembly Guide for specific information. -
Page 8: Gas Connections
Use a gas pressure regulator and hose supplied by Napoleon; if not included, use a regulator and hose that meet national and regional codes. - Page 9 WARNING! Follow all specifications and instructions exactly to prevent fire, explosion, property damage, personal injury, or death. WARNING! Disconnect the grill and its individual shutoff valve from the gas supply piping system during any pressure testing in excess of ½ psi (3.5 kPa). Napoleon.com | BUILT-IN Series Getting Started |...
- Page 10 ½ Psi (3.5 kPa). WARNING! Check the hose for evidence of excessive abrasion, melting, cuts or cracks. If the hose is damaged, it must be replaced with an assembly specifically recommended by Napoleon. Napoleon.com | BUILT-IN Series...
-
Page 11: Leak Test
WARNING! Never use an open flame to check for gas leaks. Sparks or flames will cause a fire, explosion, damage to property, serious physical injury, or death. WARNING! Only use the pressure regulator and hose assembly supplied with the grill, or one in conformity with local codes. STOP Napoleon.com | BUILT-IN Series Getting Started |... -
Page 12: Operation
WARNING! Follow the lighting instructions carefully. WARNING! Make sure the lid of the grill is OPEN while igniting. off poSition WARNING! Do not adjust the cooking grids while the grill is hot, or operating. Napoleon.com | BUILT-IN Series | Operation... -
Page 13: Grilling Instructions
WARNING! Do not deep fry food on the side burner. Cooking with oil can be dangerous. WARNING! Regularly clean grease out of the entire unit, including the grease tray and the sear plates, to avoid build-up and grease fires. Napoleon.com | BUILT-IN Series Operation |... - Page 14 GRILLING PRO TIP! Add a Napoleon smoker accessory to your grill to flavor your meat. WARNING! Do not leave food unattended on any lit burners. WARNING! Keep the lid open if main infrared burner is set on high to prevent accidentally burning food.
-
Page 15: How To Use The Rear Burner & Rotisserie
• Follow instructions 3-4 from 'Using the Rear Burner and Rotisserie Kit' to load both spit rods. • Place a metal dish under the meat to collect the drippings. Napoleon.com | BUILT-IN Series Operation |... - Page 16 WARNING! Disassemble rotisserie components when finished cooking, wash with warm soapy water, and store indoors. WARNING! Use heat resistant grilling gloves when handling the hot rotisserie components. WARNING! Disconnect rotisserie plug from the outlet when the grill is not in use. Napoleon.com | BUILT-IN Series | Operation...
-
Page 17: The Grilling Experience Checklist
• Soybean Oil • Extra Virgin Olive Oil • Canola Oil If not available, select an oil or fat that has a high smoke point. Do not use salted fats like butter or margarine. Napoleon.com | BUILT-IN Series Operation |... -
Page 18: Infrared Grilling Guide
5 minutes then Medium 15 minutes each side tender meat. Trim off excess until finished Lamb Chops Select larger wieners and slit MEDIUM to LOW 4 – 6 minutes lengthwise before grilling Hot dogs Napoleon.com | BUILT-IN Series | Grilling Guide... -
Page 19: Cleaning Instructions
WARNING! Always wear protective gloves and safety glasses when cleaning your grill. WARNING! Accumulated grease is a fire hazard. WARNING! Cleaning should only be done when the grill is cool to avoid the possibility of burns. Napoleon.com | BUILT-IN Series Cleaning |... - Page 20 (if applicable). • Only use Napoleon approved liners on the drip pan. Never use aluminum foil, sand or any other unapproved material. This can prevent grease from flowing properly.
- Page 21 Insect Screen and Burner Ports Spiders and insects are attracted to small enclosed spaces. Napoleon has equipped the burner with an insect screen on the air shutter. This reduces the likelihood of insects building nests inside the burner, but doesn’t eliminate the problem.
-
Page 22: Maintenance Instructions
Propane 1.25mm 13.1 20.5 1/2" Full BIG44RB Natural gas 1.65mm 2.05mm 13.1 20.5 3/8" Full Propane 13.1 1/2" BI32 Natural gas 1.65mm 13.1 3/8" Propane 10.6 BIB10RT / BIB10IR Natural gas 10.6 Fig. 1 Napoleon.com | BUILT-IN Series | Maintenance... -
Page 23: Stainless In Harsh Environments
WARNING! Maintenance should only be done when the grill is cool to avoid the possibility of burns. WARNING! A leak test must be performed annually and when any component of the gas train is replaced, or when the smell of gas is present. Napoleon.com | BUILT-IN Series Maintenance |... -
Page 24: Troubleshooting
Clean sear plates and drip pan regularly. Do not line pan with pan. aluminum foil. Refer to "Cleaning Instructions". WE WANT TO HELP! Napoleon is here to ensure your grilling experience is memorable. Contact us if you require additional help. - Page 25 Pipe must be sized according to installation code. Allow burner to cool and inspect very closely for cracks. Contact Leaking gasket surrounding the ceramic tile, or a weld your authorized Napoleon dealer to order replacement burner failure in the burner housing. assembly if any cracks are found.
- Page 26 2 minutes. Reignite. Allow burner to cool and inspect very closely for cracks. Contact Leaking gasket surrounding the ceramic tile, or a weld your authorized Napoleon dealer to order replacement burner failure in the burner housing. assembly if any cracks are found.
-
Page 27: Diagram For Electrical Connections
SWITCH - LIGHTS - 12VDC, 0.3~0.8W, 22~66mA - 12VDC, 0.3~0.8W, 22~66mA BIB10 KNOB LIGHT BLACK BIB10 x1 BLACK - 12VDC, 0.3~8W, 34~95mA RED / ROUGE / ROJO SWITCH - LIGHTS - 12VDC, 0.3~0.8W, 22~66mA Napoleon.com | BUILT-IN Series Troubleshooting |... - Page 28 This Limited Warranty creates a warranty period as specifi ed in the aforementioned table, for products purchased through an authorized Napoleon dealer, and entitles the original purchaser (or gift recipient in the case where a new product is given as a gift) to the specifi ed coverage in respect of any component replaced within the warranty period, either by Napoleon or an authorized Napoleon dealer, to replace a component of such product that has failed in normal private use as a result of a manufacturing defect.
- Page 29 Napoleon in case we ever need to contact you. When making warranty claims, Napoleon representatives may request from you the bill of sale or copy, together with a serial number and a model number. Napoleon reserves the right to have its representative inspect any product or part prior to honoring any warranty claim.
- Page 30 Napoleon.com | BUILT-IN Series...
- Page 31 Napoleon.com | BUILT-IN Series...
- Page 32 U.S. and Canadian and/or foreign patents or patents pending. De Riemsdijk 22, 4004 LC, Tiel, The Netherlands 10-12 Home Farm, Meriden Road, Berkswell, CV7 7SL, United Kingdom 24 Napoleon Road, Barrie, Ontario, L4M 0G8, Canada PHONE: +31 345 588655 www.napoleon.com eu.info@napoleon.com N415-0601AU Last Revision | - | July 27, 2022 Napoleon.com | BUILT-IN Series...