Related Manuals for Camplux CA318
Summary of Contents for Camplux CA318
- Page 1 CAMPLUX 12L Residential Indoor Tankless Gas Water Heater USE & CARE MANUAL (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 2 40 inches, top at 40 inches. Turn gas off at cylinder valve after use. Disconnect and remove cylinder before storing this appliance indoors. * Please retain the instruction manual for future reference. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 3 You're All Set! Thanks for purchasing your new Camplux 12L residential tankless water heater. This convenient, safe and high efficiency product will open the doors to enjoying endless hot water. We highly suggest you take the time to read through all of the safety and installation procedures in this manual, before attempting to install your new residential water heater.
- Page 4 Be sure to inspect the flue terminal for proper installation at initial start-up and at least annually thereafter. Refer to the Care and Cleaning section of this manual for more information regarding flue terminal inspection. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 5 Read and follow water heater warnings and Instructions. If owners manual is missing, contact the retailer or manufacturer. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 6 Be sure to inspect the flue terminal for proper installation at initial start-up, and at least annually thereafter. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 7 ● Water heaters utilizing propane gas are different from natural gas models. A natural gas water heater will not function safely on propane gas and vice versa. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 8 ● Should overheating occur or the gas supply fail to shut off, turn off the manual gas control valve to the water heater. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 9 D. Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the appliance and to replace any part of the control system and any gas control which has been under water. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 10 Electrical safety DANGER Shock hazard-make sure the electrical power to the water heater is off to avoid electric shock that will result in death or serious personal injury. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 11 Turn off the manual shut off valve if the water heater has been subjected to overheating, fire, flood, physical damage or if he gas supply fails to shut off. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 12 ● The vent pipe should be installed with a flame retardant wall thimble. Owner must refer to vent manufacturer’s instructions and specifications. ● The power socket connecting the water heater should be grounded properly with a GFCI circuit protector. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 13 ● If the clearances stated on the instruction/warning label, located on the front panel of the heater fifer, install he water heater according to the clearances stated on the manual. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 14 If the water heater is installed in a confined space, provisions for combustion and ventilation air must be made. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 15 Plumbing should be carried out by a qualified plumber in accordance with local codes. Use approved plumbing materials and tools only. Install a check valve between the water heater and the water shut off valve. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 16 IMPORTANT: Do not apply heat to the HOT or COLD water connections. Any heat applied to the water supply fittings will permanently damage the internal components of the water heater. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 17 ● DO NOT use lead or non-approved plastic pipe. ● To conserve energy and minimize heat loss, insulation of hot water piping is recommended. Air Relief Valve Hot Water Tap Water Outlet Drain Valve (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 18 NOTICE: Manual operation of relief valves should be performed at least once a (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 19 The National Fuel Gas Code (NFGC) mandates a manual gas shut off valve, see (NFGC) for complete instructions. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 20 ● Use a commercial leak detector or soapy water solution to test for leaks at all connections and fittings. Bubbles indicate a gas leak that must be corrected. All connections should also be leak tested after the water heater is placed in operation. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 21 Pressure Testing The Gas Supply System WARNING: Install a gas pressure regulator, in the gas supply line, which does not exceed the maximum supply pressure. DO NOT use an industrial type gas regulator. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 22 CAUTION: Reinforcement of the wall is required in case the wall is not strong enough to hold the appliance. 3.94″ Φ Installation Holes For Flue 4.64″ 3.54″ Installation Holes 4-Φ 0.4″deep 2″ 3.54″ (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 23 The installation hole in the wall needs to be sealed by fire-retardant materials or wall thimble, making sure the water heater is tight and will not come off. 3.54″ 3.54″ 3.54″ 3.54″ (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 24 Vent pipe runs must be adequately supported along both horizontal and vertical runs. The maximum recommended unsupported span should be no more than 5 feet. Support isolation hanging bands should be used. DO NOT use wire (See diagram below). (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 25 Insulation 1/4″ Per Feet Insulation Material Downward Slope Material Inspection Ceiling Hole#2 Board Inspection Hole#1 (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 26 NOTICE: Make sure that the seam of the vent pipe in horizontal runs is toward the top of the installation (see illustration below). (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 27 NOT following proper condensate procedures will void warranty. Vent Termination Clearances Drawing For non-direct vent installations in the US and Canada (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 28 For clearances not specified in ANSI Z223.1/NFPA 54 or CSA-B149.1, one of the following shall be indicated: A) A minimum clearance value determined by testing in accordance with Clause 5.20 or, (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 29 1/4″ Per Feet Downward Slope 6″ Clearance Vent 12“ Minimun Adapter Support Hanger To Drain,Dispose Of Condensate In Accrdance To Local Codes 9.8“ 9.8“ Typical Horizontal Termination W1/4″ Per Feet Downward Slope (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 30 ● Connect the live wire to black leg wire and the neutral wire to the white neutral wire. CAUTION Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify correct operation after servicing. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 31 ● Keep any excess of the power supply cord on the outside of the water heater. ● If local codes require hardwiring, see instructions for “Hardwiring the electrical connections”. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 32 ● DO NOT remove the front cover unless absolutely necessary. This should only be done after being examined by a qualified service technician. ● DO NOT install this product where standing water may occur. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 33 ● Discharge line protected from freezing. E. Electrical Wiring ● Voltage matches rating plate. ● Water heater is properly grounded. ● Wiring meets all local codes. ● GFCI protection where required. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 34 Should you have any problems reading or following the instructions in this manual. STOP! Get help from help from Camplux at www.camplux.com ,live chat and toll free at (844)538-7475.
- Page 35 Before manually operating the relief valve, make certain no one will be exposed to the danger of the hot water released by the valve. The water may be hot (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 36 ● If the water heater has been subjected to fire,flood or physical damage,turn off the manual gas shut off valve(s), and do not operate the water heater again until it has been checked by qualified personnel. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 37 Check for any abnormal sounds during normal operation of the water heater. All piping should be checked for gas and/or water leaks. Refer to page 14 of this manual for instructions on leak testing. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 38 6. Return the filter to the water heater and crew in the filter. 7. Turn the electrical power supply and cold water supply ON to the water heater. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 39 This damage is not covered under your manufacturer’s warranty. If these conditions are anticipated, please drain the water heater as follows to help but not guarantee from freezing: (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 40 2. Close the water shut off valve. 3. Turn the on/off switch to the OFF position and disconnect breaker at least 10 seconds after step #1. 4. Open drain valve. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 41 This function is no purge un-burned Normal operation. There is no need hot water faucet is closed gas 10-15 seconds to call for service. Check for error codes (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 42 1. Turn off the hot water faucet and turn off the switch on the remote control. 2. Take care of the error code displayed and contact customer service at (844)538-7475 or email to support@camplux.com for any assistance. Error Code Error Description...
- Page 43 This water heater requires a special venting system. Refer to the installation instructions for parts This water heater requires a special venting system. Refer to the installation instructions for parts list and method of installation. list and method of installation. (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 44 1 43 In The Box Item Description Identification Quantity Residential tankless 1 piece water heater Vent pipe Φ 1 set 2.0”x20”) Fixing kits 1 set Manual 1 piece (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 45 Camplux, Enjoy Outdoor Life! Limited Warranty Information Camplux hereby warrants this product to be free of material defects in materials and workmanship when installed and operated according to Camplux’s installation and operating instructions. This Limited Warranty extends to the original purchaser and subsequent owners, but only while the product remains as the site of the original installation.
- Page 46 AK, HI, Canada, and any location outside of the continental US, will be responsible for all shipping costs,regardless of reason or circumstance. All shipments of any type of product coming to Camplux for any reason must have an RGA for any repairs to be made. Please contact Camplux to obtain an RGA number prior to shipping anything to Camplux.
- Page 47 Temperature Control Manual 80 -160°F Manual 90 -140°F Manual 90 -140°F Warranty 1 Year 1 Year 1 Year Product Dimensions 12.8*20.28*5.91 Inch 14*22.2*5.9 Inch 15*6.5*22.24 Inch RESIDENTIAL SERIES (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...
- Page 48 (844) 538-7475 support@camplux.com 3330-A Marathon Ct Charleston, SC 29418 Visit Us: Camplux.com...