Sharp WH-T36E Service Manual

SHARP SERVICE MANUAL

NAME OF PARTS AND SPECIFICATIONS ......................................................................

EXTERNAL DIMENSION ...................................................................................................

CAUTION FOR USE .........................................................................................................

HOW TO USE ...................................................................................................................

CIRCUIT DIAGRAM ...........................................................................................................

INSTALLATION ADVICE ...................................................................................................

POWER SUPPLY INSTALLATION ....................................................................................

SHOWER SET ..................................................................................................................

REPLACING METHOD FOR MAIN PARTS .......................................................................

TROUBLESHOOTING .......................................................................................................

CIRCUIT DIAGRAM (PCB-A) ............................................................................................

SERVICE PARTS LIST ......................................................................................................

ELECTRIC WATER HEATER

In the interests of user-safety (Required by safety

regulations in some countries) the set should be restore

to its original condition and only parts identical to

those specified should be used.

SHARP CORPORATION

MODEL

WH-T36E

WH-T39EP

WH-T46E

Page

5-8

8-9

10-15

18-24

Table of Contents

Summary of Contents for Sharp WH-T36E

Page 1: Table Of Contents
SHARP SERVICE MANUAL ELECTRIC WATER HEATER MODEL WH-T36E WH-T39EP WH-T46E In the interests of user-safety (Required by safety regulations in some countries) the set should be restore to its original condition and only parts identical to those specified should be used.
Page 2: Name Of Parts And Specifications
ELB Checker Button Breaker Angle Support Shower Hose Main Water Valve Water Volume Knob SPECIFICATION WH-T39EP WH-T46E Model WH-T36E Voltage (V) Rated frequency (Hz) 3,500 4,500 Power consumption (W) Water supply One Point system Water supply temperature control Electronic control water temperature 50 C (approximate) Min.
Page 3: External Dimension
EXTERNAL DIMENSION Front Back Side (Unit in mm.) Fig. 1 CAUTION FOR USE Never install water valve or faucet at hot water outlet. Water valve Water inlet Water outlet Fig. 2 Never spray water to the electric water heater, do not put wet towels on it. Fig.
Page 4: How To Use
HOW TO USE BEFORE USE The electric home shower unit must earthed. Special skill is required. Never try to repair the unit by yourself. 1. Turn on the MAIN WATER VALVE. 2. Switch on the MAIN BREAKER. 3. Push up the breaker angle support, if it is down. 4.
Page 5: Circuit Diagram
CIRCUIT DIAGRAM INSTALLATION ADVICE 1. BEFORE INSTALLATION Be sure of sufficient water pressure. Minimum water pressure : 0.02 MPa (0.21 Bar). Maximum water pressure : 0.34 MPa (3.39 Bar). Water pressure measurement. Please see illustration; water must flow out of the pipe beyond 2.3 meters above the faucet.
Page 6 The shower installation must be over 1.50 meters from the ground. Over 1.50 meters Fig. 7 2. Removing the body unit cover. Remove the screw at the bottom of the unit. Remove the front plate first at the bottom. Screw Fig.
Page 7 4. The unit cover assembly. Remove the TEMP. CONTROL KNOB and PUSH ON-OFF BUTTON as illustration. Push unit cover on to body unit until they are locked. Drive screw cover unit and body unit. Insert the TEMP. CONTROL KNOB and PUSH ON-OFF BUTTON.
Page 8: Power Supply Installation
1. Be sure to cut off the main power supply switch every time before starting any electrical work. Use insulated double wire gage size at least 4 square millimeters. (Model WH-T36E, WH-T39EP) and size 6 square millimeters (Model WH-T46E) for power supply line.
Page 9 2. Connecting supply line can be done in 2 ways (see illustration below) which are punching on the lateral rubber grommet at the side or the back of cover unit. Punching at the side of cover unit. Punching at the back of cover unit. Fig.
Page 10: Shower Set
SHOWER SET By turning shower cover, water flow can be adjusted in 5 types. SPRAY FRESHEN FOAMY RIGHT LEFT COMFORT Mark shows the patterns of water flow at the chose position Fig. 19 REPLACING METHOD FOR MAIN PARTS REMOVE OF SHOWER HOSE 1.
Page 11 REMOVE OF BODY 1. Remove the screw holding the body with the back cover. 2. Lift the body first at the bottom. Body 3. Now the body is free. Screw Back cover Fig. 21 REMOVE OF PUSH SWITCH ASS’Y 1. Remove the body in accordance with “REMOVE OF BODY”. 2.
Page 12 REMOVE OF REED SWITCH 1. Remove the body in accordance with “REMOVE OF BODY”. 2. Disconnect Reed SW. lead wires from the PCB-A 3. Remove 2 screws holding the Reed SW. from the body valve. 4. Now the Reed SW. is free. Screw Reed SW.
Page 13 REMOVE OF HEATER TANK ASS’Y 1. Remove the triac in accordance with “REMOVE OF TRIAC”. 2. Remove the body valve ass’y and the water outlet in accordance with “REMOVE OF BODY VALVE ASS’Y and WATER OUTLET”. 3. Remove the screw to L-Wire Earth from heater tank ass’y. 4.
Page 14 REMOVE OF VOLUME SW. ASS’Y 1. Remove the body in accordance with “REMOVE OF BODY”. 2. Detach the lead wire for PCB-A CN2 from the PCB-B 3. Pry the claws of volume SW. support-E and remove the PCB-B 4. Remove the nut holding the volume SW. angle with the volume SW. support-E. 5.
Page 15 REMOVE OF BREAKER 1. Remove the body in accordance with “REMOVE OF BODY”. 2. Remove split pin holding the breaker angle support with the breaker. 3. Remove 2 screws holding 2 breaker lead wires with the breaker. 4. Remove 2 screws holding the breaker with the back cover. 5.
Page 16: Troubleshooting
TROUBLESHOOTING Problem Problem Possible cause Possible cause Corrective action Corrective action Water is not hot. Check or replace mechanical parts in Push SW. ON-OFF is defected. - ELB lamp is not light up. Push SW. ON-OFF. - Power lamp is not light up. Check Electrical leakage point from ELB breaker is cut off or defected.
Page 17: Circuit Diagram (Pcb-A)
CIRCUIT DIAGRAM (WH-T36E, T39EP, T46E)
Page 18: Service Parts List
Model : WH-T36E SERVICE PARTS LIST PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) PRINTING & PACKAGING MATERIAL 7R0094 INSTRUCTION BOOK 7R0016 SET PACKING CASE 7R0026 CARTON BOX 7R0034 NAME PLATE 7R7102 WIRING DIAGRAM STICKER 7N0042 LOWER PAD 7N0051 UPPER PAD...
Page 19 SERVICE PARTS LIST PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) MECHANICAL PARTS 2-24 7A901ASY SHOWER HOSE ASS'Y 2-25 7A910 SHOWER STAND 2-26 7G801ASY WATER INLET BODY ASS'Y 2-27 7A912 O-RING FIXER ELECTRIC PARTS 7A605 BREAKER 220V. 30A. 7R5021 PCB-B 7R512 LEAD WIRE FOR PCB-A CN2 7R4041ASY...
Page 20 Model : WH-T39EP SERVICE PARTS LIST PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) PRINTING & PACKAGING MATERIAL 7R0094 INSTRUCTION BOOK 7R0017 SET PACKING CASE 7R0027 CARTON BOX 7R0035 NAME PLATE 7R7102 WIRING DIAGRAM STICKER 7N0042 LOWER PAD 7N0051 UPPER PAD MECHANICAL PARTS 7R7014SET BODY SET...
Page 21 SERVICE PARTS LIST PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) MECHANICAL PARTS 2-24 7A9012ASY SHOWER HOSE ASS'Y 2-25 7A910 SHOWER STAND 2-26 7G801ASY WATER INLET BODY ASS'Y 2-27 7A912 O-RING FIXER ELECTRIC PARTS 7A605 BREAKER 220V. 30A. 7R5021 PCB-B 7R512 LEAD WIRE FOR PCB-A CN2 7R4041ASY...
Page 22 SERVICE PARTS LIST Model : WH-T46E PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) PRINTING & PACKAGING MATERIAL 7R0094 INSTRUCTION BOOK 71A100 SET PACKING CASE 71A101 CARTON BOX 71A102 NAME PLATE 7R7102 WIRING DIAGRAM STICKER 7N0042 LOWER PAD 7N0051 UPPER PAD MECHANICAL PARTS 71A200SET BODY SET...
Page 23 SERVICE PARTS LIST PARTS CODE REF. NO DESCRIPTION Q'TY PRICE (FEC) MECHANICAL PARTS 2-24 7A901ASY SHOWER HOSE ASS'Y 2-25 7A910 SHOWER STAND 2-26 7G801ASY WATER INLET BODY ASS'Y 2-27 7A912 O-RING FIXER ELECTRIC PARTS 7A605 BREAKER 220V. 30A. 7R5021 PCB-B 7R512 LEAD WIRE FOR PCB-A CN2 7R4041ASY...

This manual is also suitable for:

Wh-t39ep Wh-t46e

Sharp WH-T36E Service Manual

Table of Contents

TABLE OF CONTENTS

Related Manuals for Sharp WH-T36E

Summary of Contents for Sharp WH-T36E

This manual is also suitable for:

Table of Contents