Checking The Vehicle After Bleeding The Hydraulic Clutch System; Magnet Base B; Magnetic Base Stand; Yu-A8438 - Yamaha 2006 FJR1300AS Service Manual

d. Install a suitable bracket "4", the magnet base
B "5", and the dial gauge & stand set "6".

Magnet base B

90890-06844

Magnetic base stand

YU-A8438

Dial gauge & stand set
90890-01252
6
4
b
c
a
a
a. 100 mm (3.94 in)
b. 20 mm (0.79 in)
c. 1.5 mm (0.06 in)
d. 64 mm (2.52 in)
e. M6 × 40 mm bolt
f. 5 mm (0.20 in)
g. 60 mm (2.36 in)
e. Disengage the clutch by turning the manual
clutch operation bolt.
f. Measure the clutch pressure plate stroke.
Clutch pressure plate stroke
2.8 mm (0.11 in) or more
3
5
d
e
f
g
g. If the pressure plate stroke is out of specifica-
tion, repeat steps (j) to (l) in the procedure for
step "2. Bleed" until clutch pressure plate
stroke is within specification.
L LLL L LLL L L LLL
4. Install:
• Swingarm
Refer to "SWINGARM" in chapter 4. (Manual
No.: 3P6-28197-E0)
• Rear wheel
Refer to "REAR WHEEL" in chapter 4. (Man-
ual No.: 3P6-28197-E0)
• Air filter case
Refer to "GENERAL CHASSIS" on page 37.
ET2D21036
CHECKING THE VEHICLE AFTER
BLEEDING THE HYDRAULIC CLUTCH
SYSTEM
1. Check:
• Rear wheel drag torque
Rear wheel does not rotate/drag torque does
not progressively increase in the following or-
der: neutral, 1st gear, and when rear wheel
starts to rotate in 1st gear → Check the pres-
sure plate stroke.
Refer to "BLEEDING THE HYDRAULIC
CLUTCH SYSTEM" on page 31.
M MMM M MMM M M MMM
a. Place the vehicle on the centerstand.
b. Turn the main switch to "ON".
c. Shift the transmission into neutral, and then
rotate the rear wheel by hand.
d. Shift the transmission into 1st gear, and then
rotate the rear wheel by hand.
L LLL L LLL L L LLL
2. Check:
• Shift operation
Engine stalls → Check the pressure plate
stroke.
Refer to "BLEEDING THE HYDRAULIC
CLUTCH SYSTEM" on page 31.
M MMM M MMM M M MMM
a. Place the vehicle on the centerstand.
– 33 –
ENGINE
L L LLL L L LLL L
M M MMM M M MMM M
L L LLL L L LLL L
M M MMM M M MMM M
L LLL L LLL
M MMM M MMM
L LLL L LLL
M MMM M MMM