Haier HWD1000 User Manual
Front load washer
& dryer combo
Hide thumbs
Also See for HWD1000:
- User manual (76 pages) ,
- Service manual (30 pages) ,
- Operation manual (21 pages)
Advertisement
Advertisement
Table of Contents
Related Manuals for Haier HWD1000
Summary of Contents for Haier HWD1000
- Page 1 HWD1000 HWD1500 HWD1600 RONT ASHER & D RYER OMBO...
- Page 2 • Installation Guidelines • Maintenance Guidelines • Common Operation Issues • Component Test Information • HWD1000 Error Code List • HWD 15/1600 Error code list • HWD 15/1600 Self Check Mode • Poor Drying Performance Troubleshooting • HWD1000 Common Parts List •...
- Page 3 Installation Guidelines Part 1 • Do not remove the shipping bolts until the unit is at the installation space – Remove the shipping bolts just before the unit is to be moved into the final location • Make sure the unit is level –...
- Page 4 Installation Guidelines Part 2 • Make sure the Hot and cold supply lines are connected properly, unobstructed and fully open – Do not reuse old water supply hoses • Make sure the drain hose is installed into the standpipe properly and secured –...
- Page 5 Maintenance Guidelines • Use High Efficiency (HE) detergent only – The wrong type of soap can lead to poor wash performance and possibly damage the washer • Clean the Drain Filter every two weeks • Inspect the door boot gasket for tears or foreign matter with each new cycle •...
-
Page 6: Common Operation Issues
Common Operation Issues • Clothes do not dry within 120 Minutes • The washer will wash ~ 12 pounds of clothes at once but the unit only designed to dry 6.6 lbs. of clothes within 2 hours • 6.6 Lbs. is approximately 2 full outfits •... - Page 7 Common Operation Issues • Cannot open the door – This unit uses a safety interlock that locks the door for three minutes after the cycle ends or the stop button is pressed • This is done to protect the user from flood damage and excessive heat •...
- Page 8 Common Operation Issues • Unit does not seem to fill properly – Front load washers are designed to use less water than older style washers, – it is normal to see only 1/3 of the drum filled with water • The unit fills and pumps even during the dry cycle –...
- Page 9 Common Operation Issues • Musty Smell – Inspect the door boot assembly for mold etc. – Be sure to use HE soap only • Does not Drain – Inspect the drain pump filter for obstructions or debris...
- Page 10 Common Operation Issues • Water remains in the detergent cup after the cycle – On occasion, soap may clump or cake blocking the drain hole in the detergent cup, if the water in the cup is clear no service is required. –...
- Page 11 Common Operation Issues • Does not Fill – Verify both supply lines are connected properly and the taps are turned on (do not assume red is hot and blue is cold, verify) • Excessive Suds – Use HE Soap only and in the correct quantity...
- Page 12 Common Operation Issues • Does not Spin – Inspect the drain pump filter for obstructions or debris • Excessive Vibration – Verify the unit is level and all four legs are supporting weight – Be sure to Lock the leveling legs •...
- Page 13 Common Operation Issues • Leaks around the door 1. Inspect the door boot for debris or foreign matter, items as small as hair can prevent the door from sealing properly 2. Inspect the door boot for misalignment 3. Verify the door is closing and latching properly 4.
-
Page 14: Component Test Information
Component Test Information Component Nominal DC resistance Possible Related Error code or Symptom Hot water Valve 1.05 K ohms Err5 Heater Assembly 11 Ohms Err9, Err13 Pre wash valve 1.05K ohms Err5 Main Wash Valve 1.06 K ohms Err5 Dryer Fan Motor 9 ohms Err9 , Err13 Dryer Heating element... - Page 15 HWD1000 Error Code Chart Part 1 Note This chart assumes all operation issues have already been attempted Error Repair Scenario Parts Recommendation Number Err1 Verify the door latch data is being fed back to the Main PCB Door latch assembly Access test mode and verify the drain pump drive signal is working.
- Page 16 HWD1000 Error Code Chart Part 2 Note This chart assumes all operation issues have already been attempted Error Repair Scenario Parts Recommendation Number Inspect the pressure tube from the tub to the pressure sensor looking Err 13 Pressure sensor for kinks or leaks. Inspect the electrical connections from pressure...
- Page 17 HWD15/1600 Error Code Chart Part 1 Note This chart assumes all operation issues have already been attempted Error Number Possible solution Parts Recommendation Inspect the door latch and the wiring connecting the door latch to the Err1 Door Latch Man PCB Inspect the wiring from the Main PCB to the drain pump, Inspect the Drain Pump Err2...
- Page 18 HWD15/1600 Error Code Chart Part 2 Note This chart assumes all operation issues have already been attempted Error Number Possible solution Parts Recommendation Inspect the water line from the drum to the pressure sensor look for Err8 restrictions or loose connections, Inspect the electrical connections from Pressure Sensor the pressure sensor to the Main PCB Verify the continuity of the dryer heater, dryer fuse and thermal cutout.
-
Page 19: Hwd15/1600 Self Check Mode
HWD15/1600 Self Check Mode Press the and hold the extra rinse button and then spin the mode selector knob . Keep pressing the extra rinse button the screen will display "tEst. Use the Start/Pause Button to advance through the test functions, If an error is encountered the unit will NOT advance to the next test. -
Page 20: Poor Drying Performance Troubleshooting
Poor Drying Performance troubleshooting • Drying more than 6.6 Lbs. of clothing will greatly extend drying time • Defeat the door latch switch and verify there is air movement into the door boot gasket during drying operation • Open the dryer housing plenum and inspect the squirrel cage motor as well as the heating element... -
Page 21: Hwd1000 Service Parts List
HWD1000 Service Parts List Part Number Description Truck Stock WD-4550-05 Fan Drive Motor WD-5470-14 Drain Pump WD-7800-11 Hot water Valve WD-7800-96K Main Water Valve WD-0140-01 Door Latch Assembly WD-7350-08 Thermostat ( this includes the fusible link) WD-3500-01 Pressure Switch WD-3100-72... -
Page 22: Hwd1500 Service Parts List
HWD1500 Service Parts List Part Number Description Truck Stock WD-4550-88 Fan Drive Motor WD-5470-22 Drain Pump WD-7800-11 Hot water Valve WD-7800-96 Main Water Valve WD-6955-01 Door Latch Assembly WD-7350-08 Thermostat ( this includes the fusible link) WD-1650-33 Pressure Switch WD-5210-11 Motor Control PCB WD-3100-100 Door Boot... -
Page 23: Hwd1600 Service Parts List
HWD1600 Service Parts List Part Number Description Truck Stock WD-4550-88 Fan Drive Motor WD-5470-22 Drain Pump WD-7800-11 Hot water Valve WD-7800-96 Main Water Valve WD-6955-01 Door Latch Assembly WD-7350-08 Thermostat ( this includes the fusible link) WD-1650-33 Pressure Switch WD-5210-11 Motor Control PCB WD-3100-100 Door Boot...