Table of Contents
Advertisement
Quick Links
Phoenix
Model (8612)
Woodstove
OWNER'S MANUAL
INSTALLATION
AND
OPERATING INSTRUCTIONS
PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE YOU INSTALL, AND USE,
YOUR NEW PHOENIX WOOD STOVE. To reduce the risk of fire, follow the installation
instructions. Failure to follow these instructions may result in property damage,
bodily injury, or even death.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE!
CONTACT LOCAL AUTHORITIES HAVING JURISDICTION (BUILDING
DEPARTMENT or FIRE OFFICIALS) ABOUT PERMITS REQUIRED,
RESTRICTIONS AND INSTALLATION INSPECTION IN YOUR AREA.
Phoenix Model 8612
Manual # 6400-40413A
Revised: 9/23/2008
Advertisement
Table of Contents
Troubleshooting
Related Manuals for HearthStone Phoenix 8612
Summary of Contents for HearthStone Phoenix 8612
- Page 1 Phoenix Model (8612) Woodstove OWNER'S MANUAL INSTALLATION OPERATING INSTRUCTIONS PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL, AND USE, YOUR NEW PHOENIX WOOD STOVE. To reduce the risk of fire, follow the installation instructions. Failure to follow these instructions may result in property damage, bodily injury, or even death.
-
Page 2: Table Of Contents
Glass........................... 22 Stone .......................... 23 Cast Iron ........................23 ......................24 ROUBLESHOOTING Troubleshooting Guide....................25 & O ..............26 EPLACEMENT ARTS PTIONAL CCESSORIES ........................27 AFETY ABEL HEARTHSTONE WOODSTOVE LIMITED WARRANTIES ..........28 Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 3: Introducing Your Phoenix Wood Stove
2.4 grams per hour particulates rooms. We recommend that you do not locate your emission, you can be proud to join the Hearthstone stove in an uninsulated basement. The amount of family with our Phoenix Cast & Stone Wood radiant energy required to heat concrete basement Burning Stove. -
Page 4: Codes
“dog house”, or lower primary air Be sure the removable ash lip is in place while inlet. using the stove. If the ash lip is not installed properly, the hearth surface may exceed safe temperatures. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 5: Emergency Procedures
The stove should not be fired again until the stove, stovepipe, and chimney are all thoroughly inspected for any sign of damage. You must correct any damage before using your stove again. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 6: Specifications
Polished gray soapstone is a natural product and will vary from stone to stone. Various amounts of gray, charcoal, blue and green are usually evident, and vary according to the natural composition of the stone. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 7: Setting Up Your Phoenix Wood Stove
Read this chapter to obtain a sound understanding of how to properly install your stove. Hearthstone packages your Phoenix stove with the greatest care, so that it ships safely. Under certain If you use a close clearance connector pipe, it must circumstances, however, damage can occur during be listed, and tested to UL standards. -
Page 8: Outside Air Supply
(flex pipe, (76 mm) diameter duct (supplied by others) which outside termination, mesh, and hood supplied by leads to the outside of the house. When others. Contact your dealer availability). Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 9: Clearances T O Combustibles
B: Back wall to stove: 13” (33 cm) C: Back wall to pipe: 9” (23 cm) Corner Installation: A: Wall to stove corner: 12” (31 cm) B: Wall to pipe: 18” (46 cm) Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... - Page 10 Residential and Mobile Home Installations for USA/Canada – Rear Exit Maintain 18” min. clearance between horizontal chimney connector and ceiling. Parallel Installation: A: Side walls to stove: 20” (51 cm) B: Back wall to stove: 25” (64 cm) Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com...
- Page 11 C: Back wall to pipe: 5” (13 cm) D: Top of stove to ceiling: 36” (91 cm) The minimum alcove size: Height: 64” (163 cm) Width: 40” (102 cm) Max. Depth: 48” (122 cm) Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com...
- Page 12 5” (127 mm). For flooring, the floor protector’s minimum area must be under the chimney connector and 2” (50 mm) beyond each side. 1. 24 gauge, single wall pipe to wall = 18” (457 mm). 2. Close clearance pipe to wall = 5” (127 mm). Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com...
-
Page 13: Venting Components And Configuration
9. The single wall clearances are generic; WARNING: the Double wall clearances are for Simpson DO NOT CONNECT THIS APPLIANCE TO ANY Dura Vent DVL. AIR DISTRIBUTION SYSTEM OR DUCT. • Check Specifications From Manufacturer Of Your Connector. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 14: Installing A Venting System
An exterior chimney’s draft is not as strong and may experience increased creosote accumulation. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... - Page 15 C h im n e y is s u p p o r te d b y T e e S u p p o r t B ra c k e t. C h im n e y is s u p p o r te d b y C e ilin g . Figure 1 – Typical Venting Options Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com...
-
Page 16: Connection To A Masonry Chimney
This stove requires a minimum chimney height of 13 feet (4 m). The maximum allowable chimney height is 30 feet (9m). Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 17: Installation I N A Mobile Home
SLEEPING. ▌ CAUTION: MAINTAIN THE STRUCTURAL INTEGRITY OF MOBILE HOME WALLS, FLOOR, Typical Mobile Home Installation. CEILING, AND ROOF WHILE YOUR STOVE IS INSTALLED, AND IN USE. Chimney is supported by Ceiling. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 18: Operating Your Phoenix Wood Stove
To properly could overheat and damage the stove. season green wood: split it, stack it, and allow it to air dry for a period of one year. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 19: Buildinga Fire
You can in the closed position and the ash door is alleviate these odors by opening a few windows or tightly closed. otherwise creating additional ventilation around your Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 20: Normal Operation
Inspect the venting the control handle to the left. system frequently if low burn rates are maintained consistently. 3) Light the paper under the kindling. Leave the door slightly ajar momentarily until the Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 21: Over -Fire Caution
The ash pan is easy to remove and has a handle for convenient Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 22: Creosote Formation And Need For Removal
Contact your dealer for the name of a service. remaining in the door (take care to save hinge pins and any washers for reuse). Lay the door face down Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 23: Stone
5. Peel the paper backing from the tape gasket. Apply the new gasket to the new glass as illustrated above. 6. Place the gasketed glass onto the door. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 24: Troubleshooting
Slightly opening a window in the same room as the This phenomenon of air starvation within the building stove during startup can help too. can be exacerbated if exhaust fans, such as clothes Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 25: Troubleshooting Guide
Do not over-fire the stove. Monitor stove temperatures. Use ENAMEL seasoned cordwood only. CASTING Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 26: Replacement Parts & Optional Accessories
WOOD HANDLES (2) 5012-052 AIR INLET/ASH PAN BOX PRIMARY AIR CONTROL SLIDER 5012-056 PRIMARY AIR CONTROL SLIDER 5012-057 HANDLE 5012-066 PRIMARY SHUTTER BUSHING 5012-304 FRONT BAFFLE SUPPORT 5400-2202A ASH DOOR SHAFT 5400-2205 DOOR LATCH/SHAFT Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 27: Safety Label
Phoenix Model 8612 AFETY ABEL Hearthstone Quality Home Heating Products, Inc ® www.hearthstonestoves.com... -
Page 28: Hearthstone Woodstove Limited Warranties
Purchaser (the “Woodstove”) against any of the occurrences listed in this document that result from defects in material or workmanship. All obligations of Hearthstone under this document commence on the date the Original Purchaser purchases the Woodstove (the “Purchase Date”). - Page 29 12. A defect in any part of the Woodstove if the Original Purchaser fails to comply with Hearthstone’s or a Dealer’s request to ship the part or the Woodstove to Hearthstone or a Dealer, as the case may be.
- Page 30 Hearthstone or a Dealer, as the case may be. Notwithstanding any other provision of this document, in no event will Hearthstone pay for any Dealer fees or other fees for pick up or delivery of the Woodstove returned for repair; the Original Purchaser shall be responsible for any such fees.
Need help?
Do you have a question about the Phoenix 8612 and is the answer not in the manual?
Questions and answers