Related Manuals for Brave VH1322GX
Summary of Contents for Brave VH1322GX
- Page 1 MVH1322C.4 VH1322GX, VH1322GC, VH1322GCI, VH1326GX, VH1322GXI, VH1326GXI, VH1326VN Brave 22 and 26 Ton Vertical / Horizontal Log Splitters Model VH1322 Model VH1326 Photos show Model VH1326 Owner / Operator and Safety Manual...
- Page 2 ❏ Make sure the trailer hitch of the towing vehicle is equipped with a 2 inch ball. NOTE: Brave reserves the right to make technical changes for product improvement. This manual may contain illustrations and photographs, for demonstration purposes, which slightly deviate from the actual product design.
-
Page 3: Table Of Contents
Warranty Card............43 800-350-8739 Brave... -
Page 4: Introduction
Brave’s rigid, quality-control and component testing help ensure years of productive, reliable service. Since 1982, the name Brave has stood for quality and reliability when it comes to log splitters and wood processing products. -
Page 5: Safety
If any doubt or question arises about the correct or safe method of performing anything found in this or other Brave’ manuals, contact your Brave dealer or call the Sales and Service representatives at our main headquarters. -
Page 6: Personal Protection
Safety DO NOT proceed if any doubt arises about the correct or safe method of performing anything found in this or other Brave manuals. Seek out expert assistance from a qualified person before continuing. CALIFORNIA PROPOSITION 65 Engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. -
Page 7: Operating Safety
Only use your hand to operate the control lever. NEVER use your foot, knee, a rope, or any other extension device. Log Splitting Safety Always keep your fingers away from any cracks that open in the log during the ✔ splitting operation. 800-350-8739 Brave... -
Page 8: Maintenance And Repair
ALWAYS be careful when backing up. You could jackknife your log splitter if ✔ care is not taken. ALWAYS disconnect your log splitter from your towing vehicle before ✔ attempting to use it. Brave 800-350-8739... -
Page 9: Refueling
(if any). If a spark arrester is used, it should be maintained in effective working order by the owner and/or operator. 800-350-8739 Brave... -
Page 10: Assembly Instructions
Cotter Pin Fender Assembly Bolt (1/2-13 x 4-1/2 inch) (Model VH1326 only) Locknut (1/2-13) Fenders Hitch Pin Fender Bracket, Left-Hand Clip, Hair Pin Fender Bracket, Right-Hand Bolts (5/16-18 x 3/4 inch) Locknuts (5/16-18) On the pallet. In cardboard box. Brave 800-350-8739... -
Page 11: Unpacking The Crate
“Shipping List” section provides a complete list of all the parts shipped with your log splitter. If any parts are missing, call Brave at (800) 350-8739. NOTE: The contents of the cardboard box includes the hitch assembly, valve handle, two safety chains, and one bag of hardware, as shown. -
Page 12: Assembly Procedure
3. Place the front leg in the 45 degree down position and install the hitch pin through the lower front hole of the base unit and front leg. 4. Install the hair pin clip through the hitch pin. Brave 800-350-8739... - Page 13 Install and tighten a 1/2-13 locknut. NOTE: To prevent the rail from binding, do not over tighten the locknut. This connection serves as the pivot point for the log splitter from the vertical to horizontal position. 800-350-8739 Brave...
- Page 14 1/2 x 3 inch bolt (A). Install and tighten the locknut. Insert the end of quick link into front tube of the rail assembly and insert a 1/2 x 3 inch bolt (B) through link and hitch. Install and tighten the locknut. Brave 800-350-8739...
- Page 15 16. Attach the control lever to the valve spool using a 1/4” x 1” long clevis pin. Secure the clevis pin with a cotter pin (bend the ends of the cotter pin to hold it in place). 800-350-8739 Brave...
- Page 16 The fenders are interchangeable (left or right). Position the fender with the bolts in the middle and front holes. This should place the fender over the tire with equal spacing in the front and back. Brave 800-350-8739...
- Page 17 Assembly Instructions 21. The log splitter is now completely assembled. Follow the “Start-Up Procedure”, in the following section, which adds oil to the engine and hydraulic tank before trying to start the engine. Model VH1322 Model VH1326 800-350-8739 Brave...
-
Page 18: Start-Up Procedure
Be careful not to spill fuel when filling the engine. If fuel should spill, quickly wipe off and allow the excess fuel to evaporate before continuing. Fuel and fuel vapors are highly flammable and can cause personal injury or even death when ignited. Brave 800-350-8739... - Page 19 Cycle the log splitter several times. 10. Again, check the fluid level in the hydraulic tank and add oil as needed. Replace and tighten the fill cap. 11. Your log splitter is now ready to use. 800-350-8739 Brave...
-
Page 20: Towing
Failure to securely attach the log splitter can cause loss of control of the vehicle or the log splitter being separated from the towing vehicle, resulting in serious injury or death. Brave 800-350-8739... -
Page 21: Operation
If any doubt or question arises about the correct or safe method of performing anything found in this or other Brave manuals, contact your Brave dealer or call the Sales and Service representatives at our main headquarters. Proper care is your responsibility. - Page 22 WARNING Do not place your hands on the ends of the log when loading the log splitter. This is a very UNSAFE method and could result in injury to your hands. Brave 800-350-8739...
- Page 23 Keep hands away from pinch point areas WARNING Do not operate the log splitter by reaching across the rail. This is a very UNSAFE method, which could cause personal injury or even death. 800-350-8739 Brave...
- Page 24 (stop the wedge from retracting) and carefully remove the log from the wedge. Allowing the log to remain attached to the wedge when it is fully retracted could lead to possible injury and/or damage to the log splitter. Brave 800-350-8739...
- Page 25 Move the log under the splitting wedge keeping your hands on the sides of the log near the middle of the block. Center the log making sure that the sawed end is sitting on the large plate (base plate). 800-350-8739 Brave...
- Page 26 If you must, hold the log in the middle of the block. Remove your hand immediately when the wedge engages the log. Never use your hip or any extension device to operate the valve control handle. Brave 800-350-8739...
- Page 27 DO NOT reach forward to grab the split wood. 3. Once the wedge reaches its full forward downward travel, push UP on the control lever to retract the cylinder. 800-350-8739 Brave...
- Page 28 Keep hands away from pinch point areas. ✔ Helps eject any log that sticks to the splitting wedge. ✔ Protects control valve and other hydraulic components from damage. ✔ Rugged construction to last the life of your log splitter. Brave 800-350-8739...
-
Page 29: Inspection And Maintenance
Always replace frayed, kinked, or cracked hoses and/or other damaged hydraulic components with Brave authorized parts and components specified in the “Parts” section of this manual. Replacement parts from secondary suppliers (not original Brave replacement parts) can lead to product damage and/or personal injury, and will void the warranty. -
Page 30: Hydraulic Oil Change
Inspection and Maintenance Hydraulic Oil Change Brave recommends an oil and filter change every 100 hours of operation. Refer to the “Specifications” section in this manual for the type and quantity of oil. Important Notice Never run the log splitter unless the hydraulic oil tank is full. - Page 31 Start the engine and cycle the cylinder several times. c. Retract the cylinder and shut off the engine. d. Recheck the hydraulic tank to make sure oil is filled within one inch from the top of the tank. 800-350-8739 Brave...
-
Page 32: Specifications
DO NOT mix different types of hydraulic oils and transmission fluids (e.g., synthetic with non-synthetic). Hydraulic oil is NOT compatible with transmission fluid, and different TYPES of hydraulic oils and transmission fluids MAY NOT BE compatible with each other. Brave 800-350-8739... -
Page 33: Troubleshooting
The following section details procedures for checking your log splitter, should you encounter a malfunction. Brave recommends that you do not attempt to make repairs to the log splitter. In the long run, it is better to take your log splitter to a servicing lawn and garden dealer for repairs. -
Page 34: Decals
Decals Make sure all decals are attached to the log splitter and/or engine and are legible at all times. If you are missing a decal or one is not legible, call Brave at 800-350-8739 for a replacement. Decals 800-350-8739 Brave... - Page 35 Decals 800-350-8739 Brave...
- Page 36 Decals (10) (11) (12) (13) (14) (15) Item Part No. Description Qty. Model VH1322GX BR002622 22 Ton Logo (VH1322) VH1322GC VH1322GCI VH1322GXI VH1326GX BR002624 26 Ton Logo (VH1326) VH1326GXI VH1326VN BR002559 Decal, Proper Machine Loading BR002308 Kit, Warning and Operation...
-
Page 37: Warranty
Warranty For one year from the date of purchase, Brave will replace for the original purchaser, or repair free of charge, all parts of the Brave’ Hydraulic Log Split- ter, returned to our factory PREPAID and found upon inspection by us to be faulty, due to defects in materials or workmanship. -
Page 38: Parts
Ref# Part# Description Model Ref# Part# Description Model 82494 Bolt, 5/16-18 x 1 3/4” 82037 Locknut, 1/2” -13 long 82021 Washer, 5/16” BR021263 Weldment, Tank Hydraulic 82371 Bolt, 1/2-13 x 4-1/2” long 82100 Lockwasher, 5/16” Hairpin Clip, 3/32” Nut, 5/16-18 BR001764 82508 (manual bag) - Page 39 Parts- VH1322- Rev C 800-350-8739 Brave...
- Page 40 Nut, 1/2-13 82027 3/8” Lock Nut Bolt, Carriage, 82450 3/8” Bolt 82499 1/2-13 x 2-1/2” BR001761 Hairpin 3/32 x 1-5/8 BR001765 Slide Pin, 1/2 x 3” VH1322GX VH1322GC BR004057 VH1322GCI Cylinder VH1322GXI VH1326GX BR004056 VH1326GXI VH1326VN BR008531A Pin, Grooved, 1” dia.
- Page 41 Parts- VH1322- Rev C 800-350-8739 Brave...
- Page 42 Parts- VH1322- Rev C Ref# Part# Description Model Ref# Part# Description Model VH1322GC BR002001M VH1322GX GNEGC160LAQH Engine, Honda GC160 Hydraulic Pump (11 GPM) VH1322GCI VH1322GC VH1326GX VH1322GX BR002002B GNEGX160 Engine, Honda GX160 Hydraulic Pump (16 GPM) VH1326GXI VH1322GXI VH1326VN VH1326GX...
- Page 43 Parts- VH1322- Rev C 800-350-8739 Brave...
-
Page 44: Optional Attachment
Optional Attachment This attachment is designed to fit both Brave 22 and 26 ton log splitters. Log Cradle (Part No. BR021181) ✔ Catches split logs - no more stooping to pick up the split pieces. ✔ Each shelf is infinitely adjustable up to 45 degrees to accommodate various sizes of logs. -
Page 45: Warranty Card
Important Warranty Information To activate your Brave log splitter warranty, please Brave fill out the information in the form below and mail 20195 S. Diamond Lk. Rd., STE 100 in an envelope to the address listed on the right or Rogers, MN 55374 go online to www.braveproducts.com... - Page 46 Notes 800-350-8739 Brave...
- Page 47 Notes 800-350-8739 Brave...
- Page 48 Brave 20195 S. Diamond Lk Rd, STE 100 Rogers, MN 55374 Phone: 800-350-8739 (Toll Free) Fax: 866-779-9963 E-mail: sales@braveproducts.com Website: www.braveproducts.com VH1322/VH1326 10/13...
Need help?
Do you have a question about the VH1322GX and is the answer not in the manual?
Questions and answers