Nilfisk-ALTO NEPTUNE 1 Operating Instructions Manual
Hide thumbs
Also See for NEPTUNE 1:
- Operating instructions manual (512 pages) ,
- Service manual (110 pages) ,
- Quick start manual (9 pages)
Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Nilfisk-ALTO NEPTUNE 1
Summary of Contents for Nilfisk-ALTO NEPTUNE 1
-
Page 1: Operating Instructions
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Operating Instructions 107145403 C... - Page 2 NEPTUNE 1 NEPTUNE 2 12 13 14 15 16 17 °F °C CUT OUT 60 140 70 160...
-
Page 3: Table Of Contents
6 After using the cleaner lines ..................11 Rolling up the electrical lead and storing accessories..11 NEPTUNE 1 Storing the cleaner (below 0°C) ....11 NEPTUNE 2 Storing the cleaner (below 0°C) ....12 Transporting the cleaner ............12 Maintenance plan ..............13 7 Maintenance Maintenance work ..............13... -
Page 4: Neptune 1, Neptune
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Safety instructions This indicates Symbols used to mark in these operating tips and instruc- instructions instructions which tions to simplify must be observed work and to en- to prevent risks sure safe operation. -
Page 5: Neptune 2 Special
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special If the mains power lead is dam- Do not clean delicate parts Disconnect the power cord by aged, to avoid hazards, this made of rubber, fabric, etc. with pulling the plug only (do not pull must be replaced either by the the 0°... -
Page 6: Purpose
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special the safety of the cleaner. Use are available from the Carl Hey- Electrical equipment manns Verlag KG, Luxemburger only high-pressure parts ap- Strasse 449, 50939 Cologne or proved by the manufacturer! from the appropriate associa- The mains power lead must not tion of employers’... -
Page 7: Operating Elements
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 1. High pressure hose reel 11. Control panel Operating elements 2. Top cover release 12. Power ON 3. Cannister for detergent 13. Fuel low 4. Cable hook 14. Nilfisk-ALTO AntiStone low 5. Spray lance 15. -
Page 8: Antiscale
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special The Nilfisk Alto Antiscale dosing Use the schematic to find the Antiscale system is set by the factory. right dosage of No Scale/anti To adjust the water hardness we stone and water, and add the recommend that the inlet water mixture to the antiscale tank. -
Page 9: Electrical Connection
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special devices of the machine can be Electrical connection destroyed. 400V 400V CAUTION! When using cable reels: 1. Due to the risk of overheat- ing and fire, always unwind the power supply cord fully. -
Page 10: Pressure Regulation (Ergo Vario Press Gun)
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 1. Move main switch into the 4.2.2 Hot water operation (up position 'Hot Water' (B) and to 100°C) select the required tempera- ture on the temperature con- IMPORTANT! trol In the case of appliances with a 2. -
Page 11: Techniques
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 5 Applications and methods Effi cient high pressure cleaning is achieved by following a few Techniques guidelines, combined with your own personal experience of specifi c cleaning tasks. Accessories and detergents, when correctly chosen, can increase the effi... - Page 12 NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 5.2.2 Vehicle Task Accessories Method Vehicle bodywork Standard lance 1. Apply detergent to vehicle or equipment surfaces in Detergent injection order to soften up dirt and grime. Apply from bottom Curved lances and un- to top.
-
Page 13: Lines
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 6 After using the cleaner 1. Close water tap. Switching off 2. Activate spray gun without the cleaner and lance in order to empty all re- disconnecting supply sidual water in the system. -
Page 14: Neptune 2 Storing The Cleaner (Below 0°C)
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Store the cleaner in a dry room 8. The machine is protected NEPTUNE 2 without danger of frost or protect against frost when antifreeze Storing the cleaner as below: solution emerges from the (below 0°C) -
Page 15: Maintenance Plan
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 7 Maintenance Maintenance plan Maintain water filters and fuel fil- ters as required. A water fi lter is fi tted on the water Maintenance work inlet to prevent large particles of 7.2.1 Water filters dirt from entering into the pump. -
Page 16: Indications On Display
- Flame sensor (B7) is chapter 7.2.4) sooted > Contact Nilfi sk-ALTO Service - Ignition or fuel system > Cold water operation is pos- failure sible Options / model variants Original instruction For NEPTUNE 1 only. For NEPTUNE 2 overheating warning see next page. -
Page 17: Other Faults
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Indication lights Cause Remedy > Flashing light Turn main switch to position - Motor is overheated “OFF“ - let the machine cool down Remove/disconnect extension cable Possible phase failure on 3 phase variants... -
Page 18: Recycling The Cleaner
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special 9 Further information If the cleaner is discarded, make The cleaner contains valuable Recycling the cleaner it unusable immediately materials that should be recy- cled. Therefore, make use of 1. Unplug the cleaner and cut your local waste disposal site. -
Page 19: Technical Data
NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Technical data Description General 1-22 EU 1-22 GB 2-20 US 2-25 GB 2-25X GB 230/50/16 230/50/13A 115/1/60/20 230/1/50/13 230/1/50/13 Data Tol. (±) + Tol/- Tol + Tol/- Tol + Tol/- Tol + Tol/- Tol... - Page 20 NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Description General 2-30X EU Special 2-30 US 220- 2-33 EU 400/3/50 2-33X EU 2-33 NO 230- 400/3~/50 240/1/60/20 400/3/50 400/3/50 Data Tol. (±) + Tol/- Tol + Tol/- Tol + Tol/- Tol + Tol/- Tol...
- Page 21 NEPTUNE 1, NEPTUNE 2 NEPTUNE 2 Special Description General 2-16 Gerni 2-26 Gerni 2-25 KR 2-40 EXPT 2-40X EXPT 240/1/50/10 240/1/50/15 220/1/60/15 220,440/3/60 220,440/3/60 Data Tol. (±) + Tol/- Tol + Tol/- Tol + Tol/- Tol + Tol/- Tol + Tol/- Tol...
- Page 22 Nilfisk-ALTO www.nilfisk-alto.com...
Need help?
Do you have a question about the NEPTUNE 1 and is the answer not in the manual?
Questions and answers