Related Manuals for J. A. Roby ULTIMATE
Summary of Contents for J. A. Roby ULTIMATE
- Page 1 OWNER’S MANUAL ULTIMATE WOOD STOVE Certified and tested according to UL-1482-00 and ULC-S627-00 norms. Revised October 22, 2012 ULTIMATE 490, rue de l'Argon Québec (Québec) G2N 2C9 Phone: 418-849-8095 Fax : 418-849-0077 www.jaroby.com...
-
Page 2: Table Of Contents
ULTIMATE CONTENTS ULTIMATE CONTENTS ........................2 WARNING ...............................3 NOTICE ..............................5 Creosote ..............................5 ULTIMATE - CHARACTERISTICS ....................6 INSTALLATION .............................7 Vertical installation inside a masonry chimney ..................8 Exterior vertical installation .........................8 Vertical installation on a cathedral roof ....................9 Cross installation ..........................10 Vertical installation ..........................10 CLEARANCES ............................ -
Page 3: Warning
WARNING Before installing, please take a few minutes to read this handbook. Keep it in a sure place and easily reachable for future references. If this appliance is not properly installed, it could cause fire damages to the property, injuries and death. To reduce fire hazards, follow instructions contained in this handbook. - Page 4 If the appliance starts to glow red, over firing is happening. Do not add fuel. Immediately close the doors and the air intake of the appliance until everything becomes normal again. Do not charge the appliance beyond the firebricks height. Ashes must be evacuated frequently, remove it with a small steel shovel.
-
Page 5: Notice
- Do not use the appliance when a glass is broken or damaged. - Do not build the fire close to the glass. - Keep the door closed when using the appliance. - Do not connect the Ultimate with a chimney or a flue serving another heating appliance... -
Page 6: Ultimate - Characteristics
ULTIMATE - CHARACTERISTICS Combustible Wood 500 à 3000 ft² (46,5 à 278,70 m²) Recommended surface Evacuation pipe diameter 6 in (15,24 cm) Chimney minimal height 12 ft (3,66m) Dimensions Exterior height 33,5 in. (85,1 cm) 27,5 in. (70,0 cm) Exterior width Exterior depth 37 in. -
Page 7: Installation
INSTALLATION A good installation is extremely important for a safe and efficient use of your J.A. Roby Inc. appliance. If you doubt on the way to install the appliance correctly, seek for professional installation service. We suggest you to call masters fitters. -
Page 8: Vertical Installation Inside A Masonry Chimney
ERTICAL INSTALLATION INSIDE A MASONRY CHIMNEY The Ultimate must be installed in accordance with the applicable local laws or the CAN/CSA - B365 ULC S635, ULC S640, UL 1777 norms. For the chimney, follow the chimney manufacturer's instructions. XTERIOR VERTICAL INSTALLATION... -
Page 9: Vertical Installation On A Cathedral Roof
ERTICAL INSTALLATION ON A CATHEDRAL ROOF The Ultimate must be installed in accordance with the applicable local laws or the CAN/CSA - B365 ULC S635, ULC S640, UL 1777 norms. For the chimney, follow the chimney manufacturer's instructions. -
Page 10: Cross Installation
ROSS INSTALLATION The Ultimate must be installed in accordance with the applicable local laws or the CAN/CSA - B365 ULC S635, ULC S640, UL 1777 norms. For the chimney, follow the chimney manufacturer's instructions. ERTICAL INSTALLATION The Ultimate must be installed in accordance... -
Page 11: Clearances
Due to its reduced clearances, this appliance occupies a minimum of space in the room where it is installed. No matter where you install it, the Ultimate will complete perfectly your decoration by its originality and its heat. With the addition of A heat shield it... -
Page 12: Floor Protector
FLOOR PROTECTOR Your wood stove should be placed on a non-combustible plate under the appliance, which must exceed 18 inches to the front, 8 inches on each side and 8 inches to the back. *** Only use non-combustible materials. Ex : (ceramic, marble, granite) -
Page 13: Door Adjustment
DOOR ADJUSTMENT In order for your stove to operate properly, the door should be adjusted using the small wrench tool to provide an air tight fit: To adjust: Turn clockwise until the door is air tight. LIGHTING Now that you have completed the installation of the appliance according to the recommendations, you are ready for the lighting! 1. -
Page 14: Fans And Thermodisc
FANS AND THERMODISC The 115 volts fans must be screwed with the grids beneath the air corridor. The thermo disc box must be screwed on the back of the corridor. Connect the thermo disc into the electrical outlet. When the appliance is in function, the heat reaching a temperature of F activates the thermo disc. -
Page 15: Preventive Measures And Maintenance
Do not alter or modify the air intakes of the appliance in order to get a stronger fire. To clean the glasses, J.A. Roby Inc. recommends using products sold for this purpose or an oven cleaner. Avoid cleaning with abrasives or when the glass is hot. -
Page 16: Replacement Part L Ist
REPLACEMENT PART L IST • BRICKS • WOOL • PLATES USED TO RETAIN WOOL • PIPES • GLASS • BRICKS SUPPORTS • DOOR HANDLE • FANS CORDS • O ORDER PARTS PLEASE CONTACT YOUR AUTHORIZED RETAILER... -
Page 17: Installation Of The Firebricks
INSTALLATION OF THE FIREBRICKS Before you begin, please take note that the purpose for the screws is to secure the bricks inside the stove. First, install the bricks C (10), F (2), E (1) at the bottom of the stove and C (1) & D (1) on the inclined part near the door. -
Page 18: Figure 1 .
Figure 1 . 0... -
Page 20: Limited Life Warranty
LIMITED LIFE WARRANTY J.A. ROBY INC. warrants for life (following conditions written in the present manual) its high quality appliances against all manufacturing defectiveness. This warranty is only valid for the first buyer of the appliance with a purchase proof and the serial number of the appliance.
Need help?
Do you have a question about the ULTIMATE and is the answer not in the manual?
Questions and answers
How do i unasssemble a ultimate 2015 wood stove to replace the rock wool insulation blanket