Related Manuals for X-TREME XG-575DS
Summary of Contents for X-TREME XG-575DS
- Page 1 X-Treme™ Gas Scooters XG-575DS Owner’s Manual PLEASE BE SAFE WHEN RIDING ALWAYS WEAR A HELMET AND OBEY ALL LAWS!
-
Page 2: Table Of Contents
TABLE OF CONTENTS Table of Contents……………………………………………………………………………………… 2 Important Information……………………………………………………………………………… 3 Safety Information……………………………………………………………………………………. 4 Getting To Know Your XG-575DS……………………………………………………………… 5 Package Contents…………………………………………………………………………………….. 6 Getting Started…………………………………………………………………………………………. 6 Folding and Storage………………………………………………………………………………….. 8 Operating Procedures………………………………………………………………………………. 8 Maintenance……………………………………………………………………………………………. 10-16 Recommended Tools……………………………………………………………………. 10 Carburetor Adjustments……………………………………………………………….. 10 Braking System………………………………………………………………………………... -
Page 3: Important Information
PLEASE READ THIS FIRST BEFORE OPERATING THIS PRODUCT WHERE TO USE YOUR XG-575DS: This product does not conform to Federal Motor Vehicle Standards and is not intended for operation on public streets, roads or highways. Serious injury can result from the unsafe operations of this vehicle. -
Page 4: Safety Information
Use only parts and accessories that are recommended by the manufacturer. If a situation arises that is not covered in this manual, Proceed with caution and use good judgment. Contact your dealer or X-Treme (www.x-tremescooters/support) if you need further assistance. -
Page 5: Getting To Know Your Xg-575Ds
Getting To Know Your A-Blaze Signature Series XG-575DS 1. Gas/Throttle Lever 13. Choke 2. Front Brake Lever 14. Belt Cover and Mud Guard 3. Rear Brake Lever 15. Handlebar Down Tube 4. Gearshift 16. Pull Starter 5. Front Disc Brake 17. -
Page 6: Package Contents
Unfolding 1.) Carefully remove the XG-575DS from the box. 2.) To unfold the XG-575DS, begin by pressing down on the FOLDING HANDLE with one hand, (Fig. 1) while gently pulling up on the handlebar post with the other (Fig. 2). - Page 7 19.) Make sure the engine is running. 20.) Put one foot on the deck of the XG-575DS. While pushing off with the other foot, press the GAS LEVER on the right side of the handlebars. The XG-575DS will begin to move on its own.
-
Page 8: Folding And Storage
BRAKE LEVERS (Fig. 8). FOLDING AND STORAGE When you are done riding the A-Blaze Signature Series XG-575DS Gas Scooter you can fold it down for compact storage, carrying and transportation. To fold down the XG-575DS, use one hand to push down the front folding handle mechanism while gently pushing down on the handlebars. - Page 9 cycle oil. Mix (shake) the fuel container. Add the remaining amount of fuel. Mix (shake) the fuel oil thoroughly before filling the tank. Fueling WARNING! 1.) Always shut the engine off before refueling. 2.) Slowly open the fuel tank, so that possible over-pressure disappears. 3.) Before fueling, clean the tank cap area carefully, to insure that no dirt falls into the tank.
-
Page 10: Maintenance
MAINTENANCE RECOMMENDED TOOLS To adjust and service the A-Blaze Signature Series XG-575DS Gas Scooter you will need the following tools: Allen Keys: 3/4/5/6mm Wrenches: 10/13/17mm – Open and Ring Combination Short Reach Spark Plug Socket Water Pump Pliers ... -
Page 11: Braking System
BRAKING SYSTEM The XG-575DS Gas Scooter uses both a floating front wheel disc/caliper system activated by a hand lever on the handlebar. Familiarize yourself with the braking system before use. The front brake is activated by squeezing the BRAKE LEVER with your left hand. Make sure to release the GAS LEVER when engaging the brakes. -
Page 12: Tires And Wheels
With continued use, the squeak should go away. TIRES AND WHEELS The XG-575DS Gas Scooter uses an identical rim and tire assembly for the front and rear wheel, which means the tires can be rotated. The wheels are actually two wheel halves (split rim) bolted together to make is easier to remove and replace the tire and tube. -
Page 13: Adjusting The Belt And Chain
**DO NOT OVER TIGHTEN OR IT WILL DAMAGE THE BEARINGS!! **DO NOT CONTINUE TO USE PRODUCT IF THERE IS TOO MUCH FREE PLAY AS THIS WILL DAMAGE THE BEARINGS!! ADJUSTING THE BELTS The belts will come adjusted from the factory. However, it may be necessary to adjust the pulleys from time to time. -
Page 14: Adjusting The Second Gear Clutch Freeplay
**FAILURE TO DO THE ABOVE WILL RESULT IN BEARING FAILURE!! ADJUSTING THE SECOND GEAR CLUTCH FREEPLAY During normal operation of your A-Blaze Signature Series XG-575DS Gas scooter, you may experience the second gear slipping. An easy way to determine if your scooter’s second gear selector is adjusted correctly is while standing with the engine turned off, select second gear and try to move the scooter backwards. -
Page 15: Maintenance Schedule
MAINTENANCE SCHEDULE Proper care of your A-Blaze Signature Series XG-575DS will ensure optimal performance and longer life span. The following are a few maintenance suggestions that will keep your scooter running in top condition. -
Page 16: Warranty/Technical Support
X-Treme to service this product. If you need technical support, contact a technician at www.x-tremescooters.com/support. If you are in need of replacement parts for your XG-575DS, please visit our site at http://www.x-tremescooters.com/owning/parts. - Page 17 DO NOT RETURN TO STORE! IF YOU NEED HELP, CALL (253) 777-0690 OR GO ONLINE TO www.x-tremescooters.com/support Revised 04/16/13...
Need help?
Do you have a question about the XG-575DS and is the answer not in the manual?
Questions and answers