Harman TLC 2000 Installation & Operating Manual
  1. Manuals
  2. Brands
  3. Harman Manuals
  4. Stove
  5. TLC 2000
  6. Installation & operating manual

Harman TLC 2000 Installation & Operating Manual

Coal/wood stove
Hide thumbs Also See for TLC 2000:
Table of Contents

Advertisement

Quick Links

Installation & Operating manual
The harman TlC 2000 Coal/wood Stove
R9
"Ce manuel est disponible en Français sur demande"

SAFETY NOTICE

PlEASE rEAd ThIS ENTIrE mANuAl bEFOrE YOu INSTAll ANd uSE YOur NEw rOOm hEATEr. FAIlurE
TO FOllOw INSTruCTIONS mAY rESulT IN PrOPErTY dAmAgE, bOdIlY INjurY, Or EvEN dEATh.
FOr uSE IN ThE u.S. ANd CANAdA. NOT SuITAblE FOr INSTAllATION IN mObIlE hOmES
IF ThIS STOvE IS NOT PrOPErlY INSTAllEd, A hOuSE FIrE mAY rESulT. FOr YOur SAFETY, FOllOw
INSTAllATION dIrECTIONS.
CONTACT lOCAl buIldINg Or FIrE OFFICIAlS AbOuT rESTrICTIONS ANd INSTAllATION INSPECTION
rEQuIrEmENTS IN YOur ArEA.
CONTACT YOur lOCAl AuThOrITY (SuCh AS muNICIPAl buIldINg dEPArTmENT, FIrE dEPArTmENT, FIrE
PrEvENTION burEAu, ETC.) TO dETErmINE ThE NEEd FOr A PErmIT.
CETTE guIdE d'uTIlISATION EST dISPONIblE EN FrANCAIS. ChEz vOTrE CONCESSIONNAIrE dE
hArmAN.
manual # 3-90-08691
SAvE ThESE INSTruCTIONS.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the TLC 2000 and is the answer not in the manual?

Questions and answers

Related Manuals for Harman TLC 2000

Summary of Contents for Harman TLC 2000

  • Page 1: Safety Notice

    Installation & Operating manual The harman TlC 2000 Coal/wood Stove “Ce manuel est disponible en Français sur demande” SAFETY NOTICE PlEASE rEAd ThIS ENTIrE mANuAl bEFOrE YOu INSTAll ANd uSE YOur NEw rOOm hEATEr. FAIlurE TO FOllOw INSTruCTIONS mAY rESulT IN PrOPErTY dAmAgE, bOdIlY INjurY, Or EvEN dEATh.

  • Page 2: Table Of Contents

    TLC 2000 Coal Stove INDEX Specifications Operation Building a Fire Maintenance Installation Chimney System Parts List Parts Diagram Warranty Please read this entire manual before you install and use your new room heater. Failure to follow instructions may result in property damage, bodily injury, or even death.
  • Page 3 TLC 2000 Coal Stove WARNINGS Carbon Monoxide (CO) Awareness Carbon monoxide, referred to as CO, is a color- CO detectors are very sensitive and may less, odorless gas that is produced during combustion sound an alarm for fumes other than CO or CO of coal and other fuels.

  • Page 4: Specifications

    TLC 2000 Coal Stove Specifications - Harman TLC 2000 Weight 375 lbs Flue Size 6 inch Fuel Pea, Nut, or Stove coal Cordwood with optionalspark screen Log Length Recommended 16" with 18" Max Heating Capacity 1,900 sq. ft. Blower Size (optional)
  • Page 5 TLC 2000 Coal Stove Clean-out Cover Top Load Door Top Load Opening Top Load Door Arm Glass Door Wood Air Control Grates Side Shield Coal Air Control Removable Shaker Handle Front Load Door Latch Ash Door Ash Door Latch...

  • Page 6: Operation

    This causes the ashes to fall through the grates into the ash pan. It is the special design of the Harman Grates that allows longer intervals between refueling and shaking Harman TLC 2000 Grate System the grates.

  • Page 7: Building A Fire

    TLC 2000 Coal Stove Air Controls Coal The primary air control for coal burning is a knob located on the bottom door. Sliding the knob to the left pro- vides less air for a smaller fire. Sliding the knob to the right provides more air for a larger fire.When burning wood, this...
  • Page 8 TLC 2000 Coal Stove Reloading. Remove Once you have prepared and maintained a thick charcoal Cleanout Plate bed, you should be able to reload the stove, allow some burn- To Burn As A ing at the maximum air setting, and reset the air control in a Fireplace Stove few minutes.
  • Page 9 TLC 2000 Coal Stove Building and Maintaining a Coal Fire Build a wood fire as described but instead of adding larger wood, limit the size to about " in diameter. Add enough " wood that the firebox floor is covered with burning wood.
  • Page 10 This causes the heat and smoke to circle around the food. As with any cooking, the amount of heat and length of time it is cooked must be experimented with for best results. TLC 2000 with cooking grill in action...

  • Page 11: Maintenance

    TLC 2000 Coal Stove Maintenance The Fire Chamber Like all fine equipment, your TLC 2000 requires The inside of the fire chamber should be examined some routine maintenance and inspection. Follow the for damage to the firebrick lining material, and grates. guidelines in this section to guarantee safe, efficient If any bricks have been damaged, replace them with operation.
  • Page 12 The gaskets are made of fiberglass very little maintenance. You should, however, keep the air of different sizes (obtainable from Harman Dealer) and are inlet and the motor free of dust and dirt. fixed in place with a high temperature stove gasket cement.

  • Page 13: Installation

    TLC 2000 Coal Stove Installation DO NOT INSTALL IN A SLEEPING ROOM Assembly Blower ( Optional ) Bolt the blower to the bottom rear of the stove with four Blower Variable 1/4-0 bolts. Tighten the bolts, but do not overtighten. Speed knob The power cord for the blower must be connected to a grounded outlet, and may not be routed above, under, over or around the stove itself.
  • Page 14 TLC 2000 Coal Stove Parallel versus Corner Installations Floor Protection In all installations, the area under and around the A parallel installation is one in which the back and stove must be protected from falling ash and live sides of the stove are parallel to the walls behind and coals.

  • Page 15: Chimney System

    To inspect this system, let the The Harman TLC 000 may be installed with (150 mm) 4 stove cool. Using a flashlight and mirror, check the interior of gauge chimney connector pipe.

  • Page 16: The Chimney

    The 3-foot, -foot, 10 foot rule Heating Appliances, UL 103, or () a code-approved masonry chimney with a flue liner. In Canada, the TLC 2000 is listed for use with prefabricated chimneys tested and listed to the Codes require that solid-fuel chimneys extend 3 ft (0.9 m)
  • Page 17 TLC 2000 Coal Stove Do not connect this unit to a chimney flue servicing another appliance. NOTE: The restriction of not venting more than one ap- pliance to the same flue applies to the U.S. specifically. While it is not recommended that you use the same chimney for more than one appliance, in Canada certain exceptions may be made.
  • Page 18 U.S. or Canadian high-temperature standards, UL 103 or ULC-69. Warning: Do not install in sleeping room. The Harman TLC 000 was tested with the fuel door open and closed. If you operate with the door open, open the by-pass and put a screen over the opening.

  • Page 19: Parts List

    TLC 2000 Coal Stove TLC 2000 Parts List -00-85109L TLC Rear Top -00-8519 TLC Rear Hinge ( per unit) 1-10-0870A TLC Front Top 1-00-08710 TLC-000 Top Air Grill Assembly (Option) 3-44-10050 1 1/" Tadpole gasket (39") -00-85149L TLC Gasket Plate -00-85153 TLC Cleanout...

  • Page 20: Parts Diagram

    TLC 2000 Coal Stove...
  • Page 23 Notes...
  • Page 24 TLC 000 Owner's Manual #3-90-08691, Rev.9...

Table of Contents