CALIFORNIA PROPOSITION If you smell gas: 1. Combustion by-products produced when using this |. Shut off gas to the appliance. product contain chemicals known to the State of 2. Extinguish any open flame. California to cause cancer, birth defects, and other reproductive harm.
Page 3
For Your Safety ........KENMORE ELITE FULL WARRANTY Grill Information Center ......2 If this grill fails due to a defect in material or workmanship within two years from the date of purchase, call 1-800-4-MY- Product Record Information......2 HOME®to...
Page 4
Temperature The temperature gauge in the hood of your new grill First Time Use measures air temperature. The air temperature inside your grill will never be as hot as the temperature at the cooking Read your Assembly Manual and ensure the grill is put surface.
Page 5
Rotisserie Cooking Rotisserie cooking is best for 'round' meat, such as large roasts, whole poultry, and pork. It generally requires an Outdoor grilling is really quite simple. You'll succeed with accessory motor and spit rod that allows the meat to be burgers, dogs, or steaks usually on your very first try.
Page 6
Wood Chips For extra smoke flavor when grilling, try adding wood Cooking on your new grill is a hands-on experience, and it chips. Soak the chips in water for approximately minutes before adding to a smoke box or pan. Place smoke is recommended to remain outside with your grill while...
Page 7
Cookinq surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended Why Clean? clean cooking surfaces while grill is hot. We've all heard the saying, "an ounce of prevention worth a pound of cure."...
Page 8
LP Tank * The LP Tank used with your grill must meet the following requirements: * Use LP Tanks only with these required measurements: 12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) x, II capacity maximum.
Page 9
LP Tank Exchange Connecting Regulator To The LP Tank * Many retailers that sell grills offer you the option of l. LP tank must be properly secured onto grill. (Refer to replacing your empty LP tank through an exchange service. assembly section.) Use only those reputable...
Page 10
Leak Testing Valves, Hose and Regulator 1. Turn all grill control knobs to OFF. 2. Be sure regulator is tightly connected to LP tank. 3. Completely open LP tank valve by turning OPD hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately.
Page 11
Safety Tips • Before opening LP cylinder valve, check the coupling nut for tightness. • When grill is not in use, turn off all control knobs and LP For Safe Use of Your Grill and to Avoid Serious cylinder valve. Injury: •...
Page 12
Match-Lightlng Main Burner ignitor Lighting * Do not lean over grill while lighting. * Open grill lid during Lighting. * Open lld. Turn on gas at LP cylinder. * Do not lean over grill while lighting. * Light Burners one at time. 1.
Side burner Ignitor Lighting CAUTION Do not lean over grill while lighting. 1. Open side burner lld. Turn ON gas at LP cylinder. 2. Turn side burner knob to the Hi position, push and hold ELECTRONIC IGNITOR button. SPIDER ALERT! 3.
Page 14
Cleaning the Main Burner Assembly General Grill Cleaning Follow these instructionsto clean and/or replace parts of burner * Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not assembly or if you have trouble igniting grill. painted at the factory (and should never be painted).
Grill Halogen Light LIGHT OPERATION iNSTRUCTiONS 1. Make sure light switch on the control panel is in the "OFF" position. 2. Connect light plug to an extension cord, then plug the extension cord into the outlet on the wall. 3. Turn the light switch to "ON".
Page 16
Cleaning the Lens 1. Prior to cleaning, make sure the light switch is in the "OFF" position and the light plug is disconnected from the power supply. 2. Do not clean the glass lens when warm. Allow to cool before cleaning. Sudden change in temperature may cause cracking of the glass lens.
Page 17
1 LEFT SIDE S HELF G523-1100-W1 BOTTOM SHELF G523-0025-W1 1 FASCIA, LEFT SHELF G523-0051-W1 DOOR MAGNET ASSEMBLY G501-0016-W2 1 RIGHT SIDE SHELF G523-1200-W1 TANK SHELFASSY G523-4100-W1 1 FASCIA, RIGHT SHELF G523-0052-W1 LEFT SIDE PANEL G523-0800-W1 RIGHT SIDE PANEL G523-0900-W1 TOP LID G523-0100-W2 LOCKING CASTER G523-0028-W1...
Page 19
insert flange on left side shelf into side shelf brackets, shown A. Attach left side shelf rear using two 1J4-20xlJ2" screws, 7mm lock washers and 7mm fiat washers, shown B. Attach left side shelf front using three 1J4-20x1/2" screws, 7mm lock washers and 7mm fiat washers, shown C.
Page 20
insert flange on right side shelf into side shelf brackets, shown A. Attach right side shelf top using two 1/4-20x3/4" screws, 7mm fiat washers, 7mm lock washers and 1/4" nuts, shown B. Attach right side shelf rear using one 1/4-20x3/4" screw, 7mm lock washer and 7mm fiat washer, shown C.
Page 21
Install heat diffusers by sliding one end of each heat diffuser into slots at front of firebox and resting opposite end on pins at back of firebox. Make sure to install the shorter heat diffuser in A position, and install the two longer heat diffusers in B and C position. Heat diffuser Place cooking grates onto the firebox as shown.
Page 22
Place side burner grate into side burner shelf, aligning grate legs with holes in shelf. On back of grill, slide grease tray into opening in lower back panel. Failure to install grease tray wi[[ cause hot grease to drip from bottom of grill with risk of fire or property damage.
Page 23
Unscrew electronic ignition cap on cart right side panel, insert AA battery into ignitor, negative(-) first. Replace the cap. AA Battery Electronic Ignition Cap LP TANK IS SOLD SEPARATELY. Flit and leak check the tank before attaching to grill and regulator (see Use &...
Page 24
Install door organizers Back of left door: Attach bag hook by inserting wire ends in the holes on the door, shown A. Attach condiment tray by sliding it onto tabs on lower door back panel, shown A. Back of right door: Attach condiment trays by sliding them onto tabs on upper and lower door back panel, shown B.
EMERGENCIES: Jf a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Gas leaking from • Damaged hose. • Turn off gas at LP cylinder or at source on natural gas systems. cracked/cut/burned If the hose is cracked or cut but not burned,...
Page 26
Troubleshooting (continued) ELECTRONIC IGNMON: Burner(s) will not light using ignitor. No spark, no ignition noise. See Section I of Electronic Ignition System. (See Electronic Ignition Troubleshooting also) No spark, some ignition noise. See Section II of Electronic Ignition System. Sparks, but not at electrode or at full See Section III of Electronic...
Page 27
Troubleshooting - Electronic Ignltion SECTION No sparks appear • Battery not installed • Check battery orientation. • Install battery (make sure that "+" and "-" any electrodes when properly. connectors are oriented correctly, with "÷'_ end up Electronic Ignition and "-" end down.) Button is pressed;...
Page 28
PROPOSITION 65 DEL ESTADO DE CALIFORNIA Si slente olor a gas: 1. En el estado de California se sabe que los subproductos de 1. Cierre el paso de gas al aparato. la combusti6n, que se producen al usar este producto, 2.
Page 29
Garanffa Por su propia seguridad ........complefa _:Hfe de Kenmore Centro de servicio para parrillas ......Siesta parrilla falla debido a defectos de material o de mano de obra dentro del plazo de dos a_os desde la fecha de compra, Informaci6n de inscripci6n de la garantia...
Page 30
Temperatura El medidor de temperatura ubicado en la tapa de la parrilla mide la temperatura del aire. La temperatura Cuanda la use pot primera vez interior de la parrilla no ser6 nunca tan alta como la de la Lea el Manual de armado de la unidad y verifique parrilla...
Page 31
Para cocinar en asador La mejor manera de cocinar carnes en piezas 'redondas _, como asados grandes, aves enteras y cerdo, es usando el Verdaderamente, el asar al aire libre es bastante simple. asadoro Por Io general se necesita un motor auxiliary Podr6 preparar deliciosas salchichas,...
Page 32
Asti[[as de madera Para Iograr un mayor sabor a ahumado al cocinar a la parrilla, pruebe usar astillas de madera. Empape en agua las astillas La experiencia en cocinar a la parrilla se adquiere con la pr6ctica y durante unos 30 minutos antes de colocarlas en el ahumador o el es aconsejable que se quede junto a la parrilla mientras cocine.
Page 33
Superficies para cocinar: Si utiliza un cepillo de cerdas para iimpiar ias superficies para cocinar, antes de usar ia parriiia verifique que no queden cerdas sueltas sobre 6stas. Se f.Por qu_ limpiarla? recomienda no iimpiar ias superficies para cocinar cuando ia Todos conocemos el antiguo dicho, 'm6s vale prevenir que parriiia est6 aOn caliente.
Page 34
Tanque de gas - El tanque de gas que se use con su parrilla debe cumplir siguientes requisites: • Use 6nicamente tanques de gas que tengan las siguientes medidas obligatorias: 12" (30.5 cm) (di6metro) x 18" (45.7 cm) (altura), con una capacidad m6xima de 20 lb.
Page 35
Reposlci6n del tanque de gas C6mo conectar el regulador al tanque de gas propano • Muchos comerciantes minoristas que venden parrillas, 1. El tanque de gas debe estar bien conectado a la parrilla. (Lea ofrecen la opci6n de reponer su tanque de gas vac[o mediante la secci6n de armada.)
Page 36
Prueba para detectar fugas de las v61vulas, las mangueras V el regulador Gire todas las perillas de control de la parriHa a la poslci6n de APAGADO. Cerci6rese de que el regulador est6 bien conectado al tanque de gas. Abra por completo la v61vula del tanque de gas, girando dispositivo...
Page 37
Consejos de segurldad " Verifique que la tuerca de uni6n est6 bien apretada antes de abrir la v61vula del tanque de gas. " Cuando no use la parrilla, cierre todas las perillas de control y la parriHa v61vula deJ tanque de gas. Para usar en forma...
Page 38
Encendldo deJquemador prlnclpaJ con eJ encendedor Encendldo con f6sforos • No se incJlne sobre Ja parrHJa cuando Ja est_ encendlendo. • Abra la tapa de la parriHa durante el encendldo. • Abra Ja tapa. Abra el paso de gas desde eJ tanque. •...
Page 39
Encendldo con el encendedor del quemador lateral No se incline sabre la parrilla cuando la est_ encendlendo. 1. Abra la tapa de[ quemadar lateral. Abra el paso de gas desde el tanque. 2. Gire la perilla del quemador lateral a la graduaci6n de llama ALTA, oprima y mantenga oprimido...
Page 40
C6mo H_plar Ja unldad deJque_ador Limpleza generaJ de Ja parrlJJa Siga estas instrucciones para Jimpiar o cambiar piezas de Ja unidad • No confunda Ja acumuJaci6n de grasa y de humo, de color marr6n deJ quemador, o si tiene probJemas para encender Ja parriJJa.
L6mpara hal6gena de la parrilla INSTRUCCIONES DE FUNCIONAMIENTO DE LA LAMPARA I. Veriflque que ei interruptor de luz en el tablero de control est_ en la posici6n de apogodo (OFF). 2. Conecte el enchufe adaptador a un cable de prolongaci6n, luego enchufe el cable del adaptador...
Page 42
Limpieza del cristal 1. Antes de limpiarlo, verifique que el interruptor de luz est_ en la posici6n de apagado (OFF) y que el adaptador de C.A. est_ desconectado de1 tomacorriente. 2. No limpie el cristal cuando est_ caliente. Deje que se enfrie antes de limpiarlo. Un cambio repentino de la temperatura...
Page 43
1 REPISA, LADO IZQUIERDO G523-1100-W1 PORTAFOSFOROS Y CADENA G508-0039-W1 1 M,_,SCARA, REPISA DEL LADO IZQUIERDO G523-0051-W1 REPISA INFERIOR G523-0025-W1 1 REPISA, LADO DERECHO G523-1200-W1 UNIDAD DE IM,_,N DE LA PUERTA G501-0016-W2 1 M,_,SCARA, REPISA DEL LADO DERECHO G523-0052-W1 UNIDAD DE LA REPISA PARA EL TANQUE G523-4100-W1 TAPA SUPERIOR G523-0100-W2...
Page 45
Introduzca el reborde de la repisa del lado izquierdo en los soportes para la repisa, como se ilustra en A. Fije la parte posterior de la repisa del lado izquierdo con 2 tornillos de 1/4-20 x 1/2", arandelas de presi6n de 7 mm y arandelas planas de 7 mm, como se ilustra en B.
Page 46
Introduzca el reborde de ia repisa del lado derecho en los soportes para la repisa, como se ilustra en A. Fije la repisa del lado derecho con dos tornillos de 1/4-20 x 3/4", arandelas planas de 7 mm, arandelas presi6n 7 mm y tuercas de 1/4", como se ilustra en B. Fije la parte posterior de la repisa del lado derecho con un tornillo...
Page 47
Instale Jos termodisipadores desJizando un extremo de cada uno de estos en Jas ranuras ubicadas en Ja parte delantera de la c_mara de combusti6n y apoyando el extremo opuesto en Jas chavetas de Ja parte posterior de la misma. Recuerde debe instalar eJ termodisipador...
Page 48
Coloque la rejilla del quemador lateral en la repisa del mismo, alinee las patas de la rejilta con los orificios ubicados en la repisa. En la parte posterior de la parrilla, introduzca la bandeja para la grasa en la abertura del panel inferior trasero.
Page 49
Desenrosque la tapa de! encendedor electr6nico, ubicado en el panel de! lado derecho del carrito. Colo que una pila AA en el encendedor, con el polo negativo (--) por delante. Vuelva a colocar la tapa. Pila AA Tapa del encendedor electr6nico EL TANQUE DE GAS SE VENDE...
Page 50
[nsfa[e los organlzadores para [as puer_as Porte posterior de [a puerto de[ [ado izquierdo: Para instalar el gancho para bolsas, introduzca los extremos del alambre en los orificios de los puertas, ¢omo se ilustra en A. Para instalar la bandeja para ¢ondimentos, ins_rtela...
Page 51
CASO$ DE EMERGENCmA: Si no se puede detener una fuga de gas, o siocurre un incendio debido a una fuga de gas, Ha_e a los bo_beroso Fugas de gas de • Manguera da_ada. • Cierre el gas en el cilindro o en la fuente de los sistemas de gas natural.
Page 52
Resoluci6n de problemas (conflnuac_6n) ENCENDIDO ELECTRON|CO: El quemador o los * Lea la secci6n I de Sistema de encendido electr6nico. * No hay chispa, no hay sonido de encendido. quemadores no se enciende(n) ai usar el encendedor. * Lea la secci6n ii de Sistema de encendido electr6nico.
Page 53
Resomud6n de probmemas ° Encend_do emectr6nico SECCION I " La piia no est6 instalada " Instaie ia piia (verifique que los conectores "+" y _'" est4_n " Revise Ja orientaci6n de Ja piJa. No aparecen en cuaiquier adecuadamente. orientados correctamente, con el extremo "+"...
Page 56
Your Home For troubleshooting, product manuals and expert advice: managemylife www.managemylife.com For repair - in your home - of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter made it, no matter sold For the replacement parts, accessories and owner's manuals...