Permanently lubricated tank mounted air compressor (48 pages)
Summary of Contents for Craftsman 919.167342
Page 1
PortabJe AIR COMPRESSOR Safety Guidelines Assembmy Operation Maintenance Service and Adjustments Repair Parts CAUTmON: Read the Safety Guidelines and All hstructions Carefully Before Operating. Sears, Roebuck and Co., Hoffman Estates, mL(}0179 U.S.A. Visit our Craftsman website: www, sears,com/craftsman A09708 Ro,,o12/27/04...
Page 3
ModeB N o. 919-167342 Running HP Sore 2.375" Stroke 1.35" Voltage-Single Phase 120V/60HZ Minimum Branch Circuit Requirement 15 amps Fuse Type Time Delay Air Tank Capacity Approx. Cut-In Approx. Cut-out SCFM @ 40 psig SCFM @ 90 psig Refer to Giossary for abbreviations. This manual contains information...
Page 4
Save these instructions Improper operation or maintenance of this product could result in serious injury and property damage. Read and understand all warnings and operation instructions before using this equipment. WARNING: Risk of explosion or fire How To Prevent it What Could Happen It is normal for emectricaR contacts...
111¸¸ 11!1 iiiiiiiii_, III! WARNING: Risk of Bursting Air Tank: The following conditions could lead to a weakening of the tank, and result in a violent tank explosion and could cause property damage or serious injury. How To Prevent It What Coumd Nal2pen Drain tank dally or after each use.
Page 6
WARNING: Risk of Electrical Shock Now To Prevent mt What Ceumd Happen Your air compressor is powered Never operate the compressor outdoors electricity. Like any other electrically when it is raining or in wet conditions. powered device, If it is not used Never operate compressor with...
Page 7
WARNING: Risk of Burns Now To Prevent It What Could Hap___en Never touch any exposed metal parts Touching exposed metal such as the on compressor during or immediately compressor head or outlet tubes, can after operation. Compressor win remain result in serious burns.
Page 8
WARNING: Risk of Serious Injury or Property Damage When Transporting Compressor (Fire, Inhalation, Damage to Vehicle Surfaces) How To Prevent What Could Happen Oil can leak or spill and could result Always pBace COMPRESSOR on a in fire or breathing hazard; serious protective mat when transporting injury or death can result,...
Page 9
Become familiar with these terms When the tank pressure drops to a certain low level the motor will restart before operating the unit. automatically. The low pressure CFM: Cubic feet per minute. at which the motor automatically SOFM: Standard cubic feet per restarts is called "cut-in"...
Contents of Carton Install the four screws, two on each side. 1 - Air Compressor Tighten securely. Handle Assemble Wheels 1 - Grip Handle It win be necessary 4 - Self Tapping Screw to brace or Wheels support one side of the unit when installing the wheems because 2 - Shoulder Bolts, 3/8-16...
Page 11
IMPORTANT: The outlet being used HOW TO SET UP YOUR UNiT must be instaIIed and grounded in accordance with all local codes and Location of the Air Compressor ordinances. Locate the air compressor in a Make sure the outlet being used ciean, dry and well ventilated area.
Extension Cords Vomtage and Circuit Protection Using extension cords is not Refer to the specification chart for the recommended. The use of extension voltage and minimum branch circuit cords wiII cause voltage to drop requirements. resulting in power Ioss to the motor Certain air compressors can be and overheating.
Page 13
Know Your Air Compressor READ THiS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR UNIT. Compare the illustrations with your unit to famiIiarize yourself with the location of various controls and adjustments. Save this manual for future reference. Description of Operation Outlet Pressure Gauge: The outlet...
Motor Overload Protector: Air Compressor Pump (not motor has an automatic reset shown): Compresses air into the air tank. Working air is not available thermal overload protector. If the until the compressor has raised motor overheats for any reason, the the air tank pressure above that overload protector will shut off the motor.
Page 15
Move the On/Auto/Off lever How to Start: to "On/Auto" position. The Turn the On/Auto/Off lever compressor wilI start, to "On/Auto" and allow tank Run the compressor for 15 pressure to build. Motor will minutes. Make sure the drain stop when tank pressure reaches valve is open and there is "cut-out"...
Page 16
Customer Responsibilities Before Daily or after Every Every each each Yearly hours qours Check Safety VaNe Drain Tank Air Filter @(1) Air compressor pump intake and exhaust valves 1- more frequent in dusty or humid conditions To Check Safety Valve Unit cycBes automatica{ly when...
Page 17
if dirty, rinse air filter with warm Water win condense in the air tank, If water and squeeze dry. not drained, water will corrode Repiace air fiIteK weaken the air tank causing a risk Replace filter cover. of air tank rupture, NOTE: if the air filter is extremely After the water has been drained, dirty it wiII need to be replaced.
Page 18
Unit cycmee automatically when power is on. When doing Maintenance, you may be exposed to voltage sources, compressed or moving parts, Personal injuries can occur. Before performing Maintenance or repair, unpBug the compressor and bmeed off aH air pressure. ALL MAINTENANCE AND REPAIR Using an adiustable wrench loosen pressure relief tube nut...
Page 19
11. Replace the pressure release Remove the outlet pressure tube. Tighten nuts. gauge, tank pressure gauge, and 12. Replace the outlet tube and quick connect (if equipped) from tighten nuts. the regulator. 13. Replace shrouds and console. Remove the regulator. 14.
Page 20
Before you store the air compressor, make sure you do the following: not drained, water will corrode Review the "Maintenance" weaken the air tank causing a risk section on the preceding of air tank rupture, pages and perform scheduled After the water has been drained, maintenance as necessary.
Performing repairs may expose voltage sources, moving parts or compressed air sources, moving parts or compressed air sources. Personal }njury may occur. Prior to attempting any repairs, unpBug the a}r compressor and Heed off aH air tank a}r pressure. PROBLEM CAUSE CORRECTION Pressure switch does...
Page 22
PROBLEM CAUSE CORRECTION Pressure reading It is normal for "some" if there is an excessive on the regulated pressure drop to occur. amount of pressure drop pressure gauge when the accessory is used, drops when an adjust the regulator following accessory is the instructions in the...
Page 23
OAUSE OORREOTION PROBLEM Regulator will Damaged regulator. Replace. notshut offair outlet. Motor will not Let motor coot off and Motor overload protection run. overload switch will switch has tripped. automaticatly reset. Tank pressure exceeds Motor will start automatica!ly when tank pressure drops pressure switch "cut-in"...
Page 24
i!!1 Air Compressor Model Number 919,167342 ]orque 12 Ft '\19 62 / A09708 24- ENG...
Page 25
Nut Sleeve Assembly 3/8" ACG-18 Saddle Mount Cup (2) 91895680 Screw 1/4-20 x 3/4 (2) ACG-408 Fastener Assembly LA-3027 Label, Drain Tank LA-3069 Label, Craftsman D23565 Label, Star Rating Z-D266!2 Pressure Switch D28999 Standpipe SSP-480 Nipple 1/4-18 NPT x 2-1/2 D21426 Regulator Z-D21923 Gauge 2"...
Page 26
Air Compressor Model Number 919,167342 Torque 7-10 Ft-Lbs "<7 79-4 Torque 51-63 ImLbs Torque 100-120 In-Lbs A09708 26-ENG...
Page 27
Air Compressor Model Number 919,167342 PART NUMBER DESCRIPTION SSF-586 Screw 1/4-20 UNC x 3/4 AC-0!08 SSF-615 Screw 1/4-20 Z-AC-0140 Eccentric Bearing Z-D26712 Motor Cylinder Sleeve >x Connecting Rod Assembly > 79-2 Compression Ring >x 79-3 ACG-29 Connecting Rod Cap >x SSF-3158=I Screw 10-24 x 3/4 T25 79=4...
Page 28
TOTAL DE UN ANO DEL OOMPRESOR DE AIRE Si este compresor de aim Craftsman fallase debido a defectos de materiales o de fabricaci6n dentro del abe de su fecha de compra, Sears, a su opci6n, Io reparara o reemplazara sin costo alguno.
Page 29
Modelo N ° 919o167342 HP de Trabajo Di_metro interior 2,375 pulg. (60,4 ram) Carrera 1,35 pulg. (34,3 ram) Tensi6n monof_sica 120V/60HZ Circuito minimo requerido Tipo de fusibleAcci6n retardada Capacidad de aire en el tanque 33 Galones (124,9 litros) Presi6n de corte de entrada Presi6n de corte de salida SCFM a 40 psig 8,6 Calibre de libras...
Page 30
GUARDE ESTA$ |NSTRUCCiONES operaci6n e! mantenimiento inadecuados este producto podrian ocasionar serias lesiones y da_os a la propiedad. Lea y comprenda todas advertencias e instrucciones de funcionamiento antes de utilizar este equipo. iiii" ADVERTENOIA: Riesgo de Explosidn o mncendio puede occurrir c6mo preveniHo...
Page 31
ADVERTENCIA: Riesgo de ExpRosi6n Tanque de aire: las siguientes condiciones podr[an, causar el debilitamiento del tanque, determinar su explosi6n violenta, danes a la propiedad o serias lesiones= puede occurrir c6rno preveniHo Drene eUtanque diariamente o despu_,s de Drenaje hradecuado agua condensada cada use, Si el tanque genera una perdida, e8 tanque,...
Page 32
ADVERTENCIA: Riesgo de Descarga El_ctrica I _.._ puede occurrir c6mo preveniHo Su compresor de aire est& accionado Jam&e oper_ el compresor a la intemperie electricidad. Come cualquier otto dispositivo cuando est& Iloviendo o en condiciones e_6ctrico irnpulsado electdcamente, si no se Io humedad.Nunca opere el cornpreeor sin sus...
Page 33
iii _ ADVERTENCIA: Riesgo de Quemaduras qu6 puede occurrir c6rno preveniHo James toque partes de metal e×puestas en el Tecar e[ metal expuesto ta_ come e[ cabezal compresor durante o inmediatamente despues de[ compresor o _os tubes de sa_ida de[ escape, de _aoperacion, el cempresor permanecer_...
Page 34
ADVERTENCIA: Riesgo de Sepias Lesiones o DaSos a la Propiedad ¢ornpresor Transportar (Fuego, hhaUaci6n, da_o a Uasuperficie de vehicuUos) puede occurrir c6mo prevenirmo EUaceite puede derramarse y ello podria Deposite el eompreeor sobre uea affombrHla resultar en serias _esiones o la muerte debido al protectora cuando Uotraesporte,...
Page 35
Presi6n minima de corte: Cuando Familiadcese con los siguientes t6rminos, el motor estA apagado, la presi6n del antes de operar la unidad: tanque de aire baja a medida que usted CFM: (Cubic feet per minute) Pies cObicos continL_a usando su accesorio. Cuando por minuto.
Page 36
Contenido de la caja Instale los cuatro tornillos, dos a cada lado. 1- Compresor de aire Ajuste firmemente. 1- Manija 1- Agarradera de manija Ensamble de las ruedas 4- Tornillo Autorroscante Ser_ neeesario 2- Ruedas sopertar un lado del equipo cuando se instalan 2- Pernos con resalto, 3/8-16...
Page 37
iiiiiiiiiii i ..iii ..C6MO PREPARAR LA UNIDAD AsegOresedequeeltomacorrienteque set9 utilizado tenga la misma configuraci6n que el enchufe de Ubicaci6n del compresor de aire conexi6n a tierra. NO UTILICE UN Ubique al compresor de aire en una zona ADAPTADOR. Vet figura.
Page 38
Cables de extensi6n el_ctrica Protecci6n del voltaic y del circuito No se recomienda la utilizaci6n de cables Acerca del voltaje y la minima cantidad de extensi6n electrica. El uso de cables circuitos requeridos, refi6rase al cuadro de de extensi6n el6ctrica originarA una especificaciones, caJda de tensi6n, Io que determinarA una Ciertos compresores...
Page 39
Oonozca su com_FesoF de aiFe LEA ESTE MANUAL DEL PROPIETARIO Y SUS NORMAS DE SEGURiDAD ANTES DE OPERAR LA UNIDAD. Compare las ilustraciones contra su unidad a fin de familiarizarse con la ubicaci6n de los distintos controles y regulaciones. Conserve este manual para referencias futuras, Descripci6n de operaciones...
Page 40
V_lvuma reguladora: Cuando el Protecci6n para sobrecarga del motor: compresor El motor tiene un protector de sobrecarga de aire se termico de reposici6n automatica. Si el encuentra motor se sobrecalienta pot alguna raz6n, funcionando, el protector de sobrecarga apagara el la valvula motor.
Page 41
Abra completamente la valvula de drenaje C6mo poner en marcha: (sentido antihorafio) a fin de permitir la Mueva la palanca On/Auto/Off a la salida del aire e impedir el aumento de la posiciSn "On/Auto" y deje que se presi6n dentro del tanque de aire durante incremente la presi6n del tanqae.
Page 42
Responsabilidades de[ c[[ente Antes Diariamente Cada Cada Anualmente de cada oluegode cada use horas horas Verifique la v_lvula de seguridad Drenaje del tanque Filtro de aire V_lvulas de entrada y escape de la bomba del compresor de aire 1- M_s frecuente en condiciones polvorientas o hOmedas.
Page 43
Una vez drenada el agua, cierre SiestA sucio enjuague el filtro de aire la v_lvula de drenaje (girando en con agua tibia y exprimalo hasta que sentido horario). Ahora el compresor seque. de aire podr_ ser guardado. Reponga el filtro de aire y su ret6n. NOqFA: Si la v_lvula de drenaje fuera del NOTA: Si el filtro de aire est_ sumamente...
Page 44
_ _ o Launidadcicla autom_ticamente en cuanto la energia el6ctrica es conectada. AI efectuar el mantenimiento, usted quedar_ expuesto a tensi6n viva, aire comprimido o partes en movimiento. Debido a tales circunstancias, podrfan ocurrirle lesiones personales. Antes de efectuar mantenimiento o reparaci6n alguna, desenchufe el compresor...
Page 45
1 1. Vuelva a instalar la tuberfa de alivio Extraiga el regulator. de presi6n. Ajuste las tuercas. Aplique sellador para carlos al niple. Vuelva a instalar la tuberfa de salida y Ensamble el regulador y ori6ntelo tal ajuste las tuercas. como se indica.
Page 46
Antes de guardar su compresor de aire, ERagua se asegOrese de hacer Io siguiente: eondensa dentro Revise la secci6n "Mantenimiento" del tanque de aire. Si no se drena, ella corroer_ debilitando la paredes de las p_ginas precedentes y ejecute tanque de aire, originando un riesgo de el mantenimiento...
Page 47
El desarrollo de reparaciones puede exporter a sitios corriente viva, partes en movimiento o fuentes de affe comprimido que podrian ocasionar lesiones personales. Antes de intentar reparaci6n alguna, desenchufe el compresor de affe y purgue toda la presi6n CORRECCION PROBLEMA CAUSA Presi6n excesiva El interrupter de presi6n no...
Page 48
PROBLEMA CAUSA CORRECCION Si hubiese una caida excesiva La lectura de la Es normal que ocurra algOn de presi6n durante el uso del presi6n sobre un descenso en la presi6n. accesorio, ajuste el regulador de man6metro acuerdo a las instrucciones de la viene equipado secci6n "Operaci6n".
Page 49
PROBLEMA CAUSA CORRECCION El motor no Deje enfriar el motor y el El interrupter de protecci6n funciona. obrecarga del motor se ha interruptor de sobrecarga se abierto. reajustarA automAticamente. El motor arrancarA automAticamente La presi6n del tanque excede cuando la presi6n del tanque caiga la presi6n de "corte mAximo"...
Page 52
Your Home For repair - in your home - of aH major brand appHiances, Hawn and garden equipment, or heating and cooHing systems, no matter who made it, no matter who sold it! For the repHacement parts, accessories owner's manuaHs that you need to do-it-yourseHfl For Sears professionaH installation of home appHiances and items Hike garage door openers and water heaters.