18.5 hp electric start 42" mower 6 speed transaxle lawn tractor (240 pages)
Summary of Contents for Craftsman 917.270682
Page 1
For answers to your questions about this product, Call: Read and follow all Safety 1-800-659-5917 Rules and Instructions before Sears Craftsmen Help Line operating this equipment. 5 am - 5 pm, Mon- Seam, Roebuck and Co,, Hoffman Estates, II 60179 Visit our Craftsman website:www.sears.com/craftsman...
Page 2
Sears will replace the battery at no charge. War- ranty service is available free of charge by taking your Craftsman riding equipment your nearest Sears Service Center.
IMPORTANT: This cutting machine is All slopes require extra caution. If you capable of amputating hands and feet cannot back up the slope or if you feel uneasy on it, do not mow it. and throwing objects. Failure to observe the following safety instructions could...
Page 4
• Before and when backing, look behind • Keep nuts and bolts, especially blade and down for small children. attachment bolts, tight and keep • Never carry children. They may fall off equipment in good condition. and be seriously injured or interfere •...
,d_Look for this symbol to point out _,CAUTION: Tow only the attachments important safety precautions. It means that are recommended by and comply CAUTION!!! BECOMEAWARE!!! YOUR with specifications of the manufacturer _FETYIS INVOLVED. your tractor. Use common sense when CAUTION: In order to prevent towing.
Page 6
Steering Wheel Steering Wheel Insert (1) Large Flat Washer !i!i!iLili ililili!l!l!l (1) Hex Bolt (1) Hex Bolt (1) Lock washer 5/16-18 x 1-1/4 3/8-16 x 1 (1) Locknut 5/16-18 Stterinig n Steering Boot Shaft Steering Wheel Adapter Seat (£Washer 17/32 x 1-3/16 x 12 _) Shoulder olt 5/16-18 Gauge...
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness.
Page 8
TO ROLL TRACTOR OFF SKID (See Operation section for location Label function of controls) Seat • Press lift lever p_unger and raise Terminal attachment lift lever to its highest Battery position. Door • Release parking brake by depressing clutch/brake pedal. •...
Page 9
• Hook front latch into hole on front of */CHECKLIST mower deck. Before you operate and enjoy your new • Hook rear latch into hole on back of tractor, we wish to assure that you receive mower deck. the best performance and satisfaction ACAUTION: Do not remove deflector from this quality product.
Page 10
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION REVERSE FORWARD FAST SLOW WARNING ENGINEON ENG,NEOFF O,LFRESSURE 'IGHTSON OV_TEMFI FUEL CHOKE MOWER HEIGHT PARKING BRAKE UNLOCKED MOWER LIFT LOCKED R N H L ATTACHMENT...
Page 11
"._'un I n_blv_I vn I%II_VV READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Save this manual for future reference. Light Switch Ignition Switch Attachment Clutch...
Page 12
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your tractor or performing adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses.
• The average lawn should be cut to • To restart movement, slowly release parking brake and clutch/brake pedal. approximately 2-1/2 inches during the cool season and to over 3 inches • Slowly move motion control lever to slowest setting. during hot months.
BEFORE STARTING THE ENGINE _eCAUTION: Fill to bottom of gas tank CHECK ENGINE OIL LEVEL r neck. Do not overfill. Wipe off any spilled oil or fuel. Do not store, spill or use • The engine in your tractor has been gasoline near an open flame.
Page 15
15e sure the tractor Js on level ground. • • Move motion control lever to neutral • Place the motion control lever in (N) position. Shut- off engine and set neutral. Release the parking brake parking brake. and let the clutch/brake slowly return •...
MOWING TIPS MULCHING MOWING TIPS • Mower should be properly leveled for IMPORTANT: For best performance, best mowing performance. See "TO keep mower housing free of built-up grass LEVEL MOWER HOUSING" in the and trash. Clean after each use. Service and Adjustments section of •...
.,..T' N,NCESC.EOO'.E F,LL ,N DATES AS YOU COMPLETE REGU R SERVICE ..Check Check Tire Pressure Brake Operation Check Operator Presence and Intedock Systems Check for Loose Fasteners V" _lt_7 Lubdca.tJon Chart cA Sharpen/Replace Mower Blades Check Battery Level Clean Battery and Terminals Check Transaxle Cooling Adjust Blade Belt(s) Tension...
Page 18
TRACTOR IMPORTANT: To ensure proper assembly, center hole in blade must align with star Always observe safety rules when on mandrel assembly. performing any maintenance. • Reassemble hex bolt, lock washer and BRAKE OPERATION flat washer in exact order as shown. If tractor requires more than six (6) feet •...
Page 19
BA'n'ERY TRANSAXLE PUMP FLUID Your tractor has a battery charging system The transaxle was sealed at the factory which is sufficient for normal use. How- and fluid maintenance is not required for ever, periodic charging of the battery with the life of the transaxle. Should the an automotive charger will extend its life.
• Use gauge on oil fill cap/dipstick • If very dirty or dam&ged, replace pre- checking level. Be sure dipstick cap is cleaner. tightened securely for accurate reading. • Reinstall pre-cleaner over cartridge. Keep oil at "FULL" line on dipstick. •...
Page 21
• Protect painted surfaces with automo- tive type wax. ClamP_clamp We do not recommend using a garden Fuel Filter hose to clean your tractor unless the electrical system, muffler, air filter and CLEANING carburetor are covered to keep water out. •...
Page 22
TO LEVEL MOWER HOUSING • If links are not equal in length, adjust Adjust the mower while tractor is parked one link to same length as other link. on level ground or driveway. Make sure • To lower front of mower loosen nut "E" tires are properly inflated (See "PROD-...
Page 23
TO REPLACE MOWER BLADE DRIVE With Parking Brake BELT "Engaged" The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake• Jam Nut BELT REMOVAL - •Nut "A" • Remove mower from tractor (See "TO REMOVE MOWER"...
Page 24
TRANSAXLE MOTION CONTROL FRONT WHEEL TOE-IN/CAMBER LEVER NEUTRAL ADJUSTMENT The front wheel toe-in and camber are not adjustable on your tractor. If damage has The motion control lever has been preset occurred to affect the front wheel toe-in or at the factory and adjustment should not camber, contact your nearest authorized be necessary.
TO ATTACH JUMPER CABLES - • Connect each end of the RED cable to Seat the POSITIVE (+) terminal of each battery, taking care not to short against chassis. • Connect one end of the BLACK cable to "y the NEGATIVE (-) terminal of fully charged battery.
Page 26
TO ADJUST CARBURETOR ENGINE NOTE: The carburetor on this engine is Maintenance, repair, or replacement of low emission. It is equipped with an idle the emission control devices and systems, fuel adjusting needle with a limiter cap, which are being done at the customers which allows some adjustment within the expense,...
PRELIMINARY SETTING - Idle Speed S, rew • Air cleaner assembly must be as- _--_ /Throttle sembled to the carburetor when making Lever carburetor adjustments. • Be sure the throttle control cable is adjusted properly (see above). FINAL SETTING - •...
Page 28
ethanol or methanol) can attract moisture Immediately prepare your tractor for storage at the end of the season or if the which leads to separation and formation tractor will not be used for 30 days or of acids during storage. Acidic gas can more.
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Will not start • Outof fuel. • Fill fueltank. • See"TO START ENGINE" • Engine not"CHOKED" properly. in Operation section. • Wait several minutes before • Engine flooded. attempting to start. • Bad spark plug. •...
Page 30
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION • Cutting too much grass/too Loss of power • Set in "Higher Cut" position/ fast. reduce speed. • Throttle in "CHOKE" • Adjust throttle control. position. Clean underside of mower • Build-up of grass, leaves and trash under mower.
Page 31
IMUUI:(_[..=_I'IUU I ll)(iJl _,.,n.•.(Lr't CAUSE CORRECTION PROBLEM • Obstruction in clutch • Remove obstruction. Mower blades will mechanism not rotate • Worn/damaged mower • Replace mower drive belt. drive belt. • Replace idler pulley. • Frozen idler pulley. • Frozen blade mandrel. •...
Page 51
TRACTOR - - MODEL NUMBER 917.270682 HYDRO TRANSAXLE - - MODEL NUMBER 319-0500 PART PART DESCRIPTION DESCRIPTION 170351 Main Housing, Assembly 142883 Brake Puck Puck Plate 170352 Side Housing, Assembly 142882 170353 Center Section, Assembly 170409 Brake Actuating Pin 170354 Swashplate, Trunion Machined 170410 HFHCS 1/4-20X2 W/Patch, Special...
Page 52
TRACTOR - - MODEL NUMBER 917.270682 BRIGGS & STRATTON ENGINE-MODEL NUMBER 310707, TYPE NUMBER 0136-E1 REQUIRES SPECIAL TOOLS TO INSTALL. SEE REPAIR 654 _ y INSTRUCTION MANUAL. 914_ 1022 _ 1023 383_ 1026A 1110_ L 1019 LABEL KIT L 1058 OWNER'S MANUAL 1033 VALVE OVERHAUL KIT 1022 888_...
Page 53
TRACTOR -- MODEL NUMBER 917.270682 BRIGGS & STRATTON ENGINE-MODEL NUMBER 310707, TYPE NUMBER 0136-E1 467_ 423 _ 8751 711_ 404 @ 614 P LSTO INSTALL 967 _ " • 484 @ SEE REPAIRINSTRUCTIONMANUAL, 2316354_'_ I ii05 692 I..137_ 634A_ ,.7, [ "'_'_ •o-- 117...
Page 54
TRACTOR - - MODEL NUMBER 917.270682 BRIGGS & STRATTON ENGINE-MODEL NUMBER 310707, TYPE NUMBER 0136-E1 287 _'_ L_----'_ 726_ ..1051 ,:-:, 783A 165 ,.:, 524 _ 1036 LABEL-EMISSIONS...
Page 55
TRACTOR -- MODEL NUMBER 917.270682 BRIGGS & STRATTON ENGINE-MODEL NUMBER 310707, TYPE NUMBER 0136-E1 PART PART DESCRIPTION DESCRIPTION • Valve-Float Needle 690156 Cylinder Assembly 231855 • Seat-Inlet 399265 Bushing/Seal 690577 291675 _ Seal-Oil 690464 Valve-Choke (Manual Choke) 494238 Sump-Engine 108A692344 Valve-Choke (Choke A Matic) 690188 Head-Cylinder...
Page 56
TRACTOR - - MODEL NUMBER 917.270682 BRIGGS & STRATTON ENGINE-MODEL NUMBER 310707, TYPE NUMBER 0136-E1 PART PART DESCRIPTION DESCRIPTION 690323 Screw (Starter Motor) 691239 Pin-Counterweight 497608 Brush Set 691096 Screw (Counterweight) 692127 Screw (Mounting Bracket) 693713 Gear-Pinion (For Steel Ring 495859 Armature-Magneto Gear Only)
Page 59
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHTING "_. .. CUT GUIDE THe- S ¢O greater than 15°), never across the face. Make turns gradu- Operate your Tractor up and down the face of slopes (not ally to prevent tipping or loss of control.
Page 60
Get it fixed, at your home or ours! For repair of major brand appliances in your own home... no matter who made it, no matter who sold it! 1-800-4-MY-HOME Anytime, dayor night (1-800-469-4663) www.sears.com To bring in products such as vacuums, lawn equipment and electronics for repair, call for...