Table of Contents
Advertisement
Quick Links
D
S
ean
toves
Dean Forge Fabrication Ltd. Dean Prior, Buckfastleigh, Devon TQ11 0LS
T e l: 0 1 3 6 4 6 4 3 5 7 4
w w w.d e a n–f o r g e.c o.u k
e m a i l: s t o v e s @ d e a n-f o r g e.c o.u k
Operating Instructions for the Dean Stoves
Sherford Slimline 5 and Sherford Slimline 5 SE
th
SHS5SE (issue 1) 20
July 2016
All stoves meet the essential type test requirement BS
EN13240:2001 + and 2:2004, CE marked
The Clean Air Act 1993 and Smoke Control Areas
Under the Clean Air Act local authorities may declare the whole or part of the district of the
authority to be a smoke control area. It is an offence to emit smoke from a chimney of a
building, from a furnace or from any fixed boiler if located in a designated smoke control area.
It is also an offence to acquire an "unauthorised fuel" for use within a smoke control area
unless it is used in an "exempt" appliance ("exempted" from the controls which generally apply
in the smoke control area).
The Secretary of State for Environment, Food and Rural Affairs has powers under the Act to
authorise smokeless fuels or exempt appliances for use in smoke control areas in England. In
Scotland and Wales this power rests with Ministers in the devolved administrations for those
countries. Separate legislation, the Clean Air (Northern Ireland) Order 1981, applies in
Northern Ireland. Therefore it is a requirement that fuels burnt or obtained for use in smoke
control areas have been "authorised" in Regulations and that appliances used to burn solid
fuel in those areas (other than "authorised" fuels) have been exempted by an Order made and
signed by the Secretary of State or Minister in the devolved administrations.
The Dean Stoves, Sherford Slimline 5 SE has been recommended as suitable for use in
smoke control areas when burning wood logs.
To use the Sherford Slimline 5 SE in smoke controlled areas the smoke control kit must be
fitted to the stove.
Further information on the requirements of the Clean Air Act can be found here :
http://smokecontrol.defra.gov.uk/
Your local authority is responsible for implementing the Clean Air Act 1993 including
designation and supervision of smoke control areas and you can contact them for details of
Clean Air Act requirements
.
1
Advertisement
Table of Contents
Related Manuals for Dean Sherford Slimline 5
Summary of Contents for Dean Sherford Slimline 5
- Page 1 The Dean Stoves, Sherford Slimline 5 SE has been recommended as suitable for use in smoke control areas when burning wood logs. To use the Sherford Slimline 5 SE in smoke controlled areas the smoke control kit must be fitted to the stove.
-
Page 2: Door Operation
Unpacking Stove Remove all packaging and stickers, Check the protective brick lining and the baffle plate has not moved in transit. Remove the glove pack from the inside of the stove. Safety Note Warning- The external parts of the appliance will get very hot to the touch and due care will be needed when operating. -
Page 3: Controlling The Stove
Controlling the stove Diagram A: Primary and secondary air controls situated below the door Primary = One ring on the control knob Secondary = Two rings on the control knob The primary air control is indicated with a single ring machined into the control knob. This control is used for lighting the fire or boosting the fire. - Page 4 When the fire has fully established and the logs are burning well shut the primary air comtrol and control the fire with the secondary air wash lever (if you are unable to sustain the fire with secondary control it is very likely that your logs have a high moisture content). Refuelling When refuelling the fire, to ensure clean burning, the primary air control should be opened for a couple of minutes so that flames are established on the newly fuelled logs.
-
Page 5: Pre-Season Check
Pre-Season Check: The chimney needs to be swept at least once a year. The chimney must be checked at this stage for blockages before lighting i.e.: bird’s nests This is probably the time to have the chimney swept before the beginning of the seasons. Before lighting at the beginning of the season or after prolonged shutdown periods, check the door seals are in good condition;... -
Page 6: Health And Safety Precautions
As with all stoves fireguards must be installed when young children are present. Chimney All Dean Stoves must have a minimum chimney height of 4m measuring from the stove outlet, the chimney must not be less than 150mm (6”) internal diameter. - Page 7 Due to the weight of the Sherford Slimline 5 door you must secure the stove to the hearth to prevent the possibility of the stove toppling forward when opening the door. This can be done by using the two rear brackets supplied.
-
Page 8: Register Plates
The Sherford Slimline 5 SE model requires a 125mm (5”) first length of flue then stepping up into a minimum of 150mm (6”) liner. When the Sherford Slimline 5 SE has a smoke except air slider fitted the flue liner can be reduced to 125mm (5”). We strongly advise a 150mm (6”) - Page 9 DEFRA screw and close combustion manifold. The Sherford Slimline 5 SE is supplied with a DEFRA screw fitted and must be left in place when using the stove in smoke controlled areas. This screw can be removed when installed in a non-smoke controlled area.
-
Page 10: Data Plate
October 2010 a compliant Carbon Monoxide Alarm must be fitted Table of mean flue temperatures with closed doors Stove Type Flue gas temp downstream of spigot, closed doors. Wood logs Sherford Slimline 5 SE 218°C Flue Gas Mass Flow Stove Type Flue gas mass flow (g/s) -
Page 11: Ec Declaration Of Conformity
EC Declaration Of Conformity The Undersigned, representing the following: Manufacturer Dean Forge Ltd Dean Prior, Buckfastleigh, Devon, TQ11 0LS Herewith declare that the products: Description Product Code Sherford 5 STDFSH5 Sherford Slimline 5 STDFSHS5 Sherford 8 STDFSH8 Description of product: Sherford heating stove product range. - Page 12 Provisions to which the product conforms: Product: Room heater fired by solid fuel as covered under the scope of the standards listed. Intended use: Space heating in residential building. Characteristic Performance Report Fire Safety Satisfies Sherford 5- STDFSH5 Co @ 13% 0² Wood 0.31% 5.3Kw @ 83% Wood 6931-2 Emission of combustible...
- Page 13 THE DEAN FORGE FABRICATION LTD STOVES GUARANTEE Dean Forge Fabrication Ltd offers a five year guarantee which covers the main body of the stove for manufacturing defects. In the event of any failure we will replace any defective part free of charge, labour cost excluded.
-
Page 16: Product Registration
..........................................................Phone Number: ..........Suppliers Details: Name ......................Address ...............................................................................Phone Number: ..........Installers Details: Name ......................Address ...............................................................................Phone Number: ..........HETAS Registration Number……………………………………………………. Dean Forge Fabrication Ltd Dean Prior Buckfastleigh Devon TQ11 0LS...
Need help?
Do you have a question about the Sherford Slimline 5 and is the answer not in the manual?
Questions and answers