Page 2
SAMSUNG SV-A20 IK General Information Wiring Diagram Also Covers SV-A30 IK SV-A40 IK SV-A80 IK SV-200 B SV-203 B SV-205 B SV-405 B Matrix Item See Model Book Connecting X-5 Jig ................SV-A130 IK Alignment & Adjustments ..............SV-A130 IK Deck Exploded View .................
Page 3
SAMSUNG SV-A20 IK Audio Video Diagram (SV-A20, SV-A30, SV-A40, SV-200, SV-203, SV-205)
Page 4
SAMSUNG SV-A20 IK Audio Video Diagram (SV-A80, SV-405)
Page 12
2) If tape control signal is not connected to the jig, the VCR must be operated in SP mode. 2-1-2 Servicing Jig Jig Item Part No. Connects the deck ass’y to the main PCB connecting cable. X-5 Chassis Jig 68140-500-013 Samsung Electronics...
Page 13
6. Apply power to the function PCB. touching the start and end sensor LEDs. If the tape still does not load, reset the function PCB by 7. Insert a test tape into the housing assÕy. pressing SW715. Samsung Electronics...
Page 14
CONNECTS TO THE ASS'Y MAIN CN601. CONNECTS TO THE CAPSTAN MOTOR CONNECTOR OF ASS'Y FULL DECK. CONNECTS TO THE LOADING MOTOR CONNECTOR OF ASS'Y FULL DECK. ASS'Y FULL DECK ASS'Y MAIN CN604 CN605 CN603 CN601 1 SCREW (1-3X10) 2 SCREWS (2-3X10) Samsung Electronics...
Page 15
Reference Information MEMO Samsung Electronics...
Page 16
42 dB min (IHF A filter) Frequency response 100Hz-8KHz Power requirement 230V (AC 50/60 Hz) Power consumption Approx. 18 watts Operation temperature 41°F-104°F (5°C-40°C) Operation humidity 10%-75% Weight 4.4 Kg (net) Dimensions (W x H x D) 380 x 90.5 x 310 mm Samsung Electronics...
Page 17
FUNCTION AUDIO JUST FRONT TAPE SHOW REAR SHUTTLE SLOW REMARK DUBBING JACK SPEED VIEW MODEL SV-A20GK/SEH (SV-200G) 1 SCART SV-A20GK/POL (SV-200G) 1 SCART SV-A40GK/SEH (SV-205G) 1 SCART SV-A40GK/POL (SV-205G) 1 SCART SV-A60GK/SEH (SV-400G) 1 SCART SP/LP SV-A60GK/POL (SV-400G) 1 SCART SP/LP SV-A80GK/SEH (SV-405G) 1 SCART...
Page 18
4-1 Cabinet Assembly Note : Disassemble in the order shown. Reassemble in reverse order. 4-1-1 Cabinet Top removal 1. Remove 5 screws and slide the top cabinet to the rear to remove. REMOVE 5 SCREWS Fig. 4-1 Cabinet Top removal Samsung Electronics...
Page 19
(BH;1-3X12 YELLOW) "A" Lift up the bottom cover in the direction of arrow "A". SV-A40GK/SV-A80GK SV-205G/SV-405G REMOVE 2 SCREWS (BH;1-3X12 YELLOW) "A" Lift up the bottom cover in the direction of arrow "A". Fig. 4-2 Bottom Cover removal Samsung Electronics...
Page 20
2. Release 4 hooks on the top side and 3 hooks on the bottom side and then, pull the assÕy front panel to remove. RELEASE 4 HOOKS REMOVE KNOB-SHUTTLE (Top view) RELEASE 3 HOOKS (Bottom view) Fig. 4-3 Ass’y Front Panel removal Samsung Electronics...
Page 21
1. Release 5 hooks and remove the assÕy function-timder. Note : Take extreme care not to damage the PCB when removing it. SV-A20GK/SV-A60GK SV-200G/SV-400G FRONT A/V OPTION RELEASE 5 HOOKS SV-A40GK/SV-A80GK SV-205G/SV-405G RELEASE 5 HOOKS Fig. 4-4 Ass’y Function-Timer removal Samsung Electronics...
Page 25
Disassembly and Reassembly MEMO Samsung Electronics...
Page 26
PLAY PLAY STOP STOP MENU MENU Q-PRO Q-PRO SOFTEN SHARPEN TV/VCR SOFTEN SHARPEN TV/VCR SLOW A.DUB SLOW A.DUB PICTURE PICTURE AUDIO ADD BUTTON(AUDIO) TEST BUTTON IS HIDDEN BEHIND OF INLAY. Fig. 5-2 Remote Control Ass’y for X-7/X-8 Chassis Samsung Electronics...
Page 27
5-2-1 The number and position of test point Test point : TP02 (CTL Pulse) TP03 (H’D S/W -Trigger) TP04 (V. Envelope) TP05 (Audio out) AUDIO OUT H’D S/W -TRIGGER CTL PULSE V. ENVELOPE Fig. 5-3 The position of test point (Main PCB-Component side) Samsung Electronics...
Page 28
2) Set the tracking preset using the ÒFINE (Tracking, Fig. 5-4 Tracking preset adjustment TRK) button of remote control. REMOTE 3) After adjustment is completed, press the CONTROL PULSE REMOVE BUTTONS ÒPOWERÓ button to release. PUSH TRACKING TRACKING PUSH Fig. 5-5 Tracking preset adjustment Samsung Electronics...
Page 29
1) Simultaneously press the ÒTESTÓ button and Ò5Ó button in PB mode. This will adjust the tracking center automatically. 2) Set the tracking preset using the ÒFINE (Tracking, TRK) button of remote control. 3) After adjustment is completed, press the ÒPOWERÓ button to release. Samsung Electronics...
Page 30
1) Insert an SP tape into the housing assÕy. 2) Press the ÒPLAYÓ button. 3) Press the ÒINPUTÓ button and Ò3Ó button simultaneously. 4) This will adjust the head S/W point adjustment automatically. 5) After the adjustment is completed, press ÒPOWERÓ button to release. Samsung Electronics...
Page 31
5. Apply the output of attenuator to the ANT IN ANT IN terminal of VCR. DC Voltmeter TP07 6. Set the channel of VCR to CH 2. 7. Connect DC voltmeter to TP07. 8. Adjust VR401 for DC 3.7 ± 0.1V. VR401 Main PCB (Component side) Samsung Electronics...
Page 32
Eject Cassette IN Cassette IN Unload Unload R. PS R. PS, Z-R. PS R. Slow Pinch Roller off Position Still Still, Slow, F-ADV Play PB, T-Stop, REC, Pause, F. PS, Z-FPS Stop Stop, Power off FF/REW FF, REW Samsung Electronics...
Page 33
Alignment and Adjustment MEMO Samsung Electronics...
Page 36
SME LOCAL SC301 AC98-12023J ASSY-SH/CASE TOP;SV-A140F,IS-PAL ASSY S/C TOP SME LOCAL SP601 AC61-22321A HOLDER-TR;POM,-,-,-,-,- SME LOCAL SP602 AC61-22321A HOLDER-TR;POM,-,-,-,-,- SME LOCAL Note : The part numbers of location numbers 2, 3 and 21 will be informed separately later. Samsung Electronics...
Page 43
Exploded View and Parts List MEMO 6-10 Samsung Electronics...
Page 44
IC;KA7809,-,- SME LOCAL C604 2203-002188 C-CERAMIC,CHIP;10NF,+80-20%,16V,Y5V,TP,2012,- SME LOCAL IC1S2 B4161-0030 PHOTO-COUPLER;PS2561-1 ST DIP C605 2203-001577 C-CERAMIC,CHIP MELF;150PF,10%,50V,Y5E,TP SME LOCAL IC1S3 AC14-12006D IC;KA431Z,TO-92,TAPING SME LOCAL C606 2202-000797 C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5P,TP,3.5X19,- SME LOCAL L1S01 AC29-30050A FILTER-LINE NOISE;-,400UH,-,250V,- C607 2203-002188 C-CERAMIC,CHIP;10NF,+80-20%,16V,Y5V,TP,2012,- SME LOCAL Samsung Electronics...
Page 45
Q6102 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250MW,TO-92,TP SME LOCAL C651 2401-001511 C-AL;47UF,20%,16V,GP,-,6X7,5 SME LOCAL Q6106 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250MW,TO-92,TP SME LOCAL C652 2203-001557 C-CERAMIC,CHIP;100NF,+80-20%,25V,Y5V,TP,2012, SME LOCAL Q6108 0501-000303 TR-SMALL SIGNAL;KSA733-Y,PNP,250MW,TO-92,-,120 SME LOCAL C653 2203-001557 C-CERAMIC,CHIP;100NF,+80-20%,25V,Y5V,TP,2012, SME LOCAL R601 2001-000832 R-CARBON;510OHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL Samsung Electronics...
Page 46
SME LOCAL W144 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL R636 2001-000281 R-CARBON;100OHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL XT601 2801-003293 CRYSTAL-UNIT;10MHZ,50PPM,28-AAA,16PF,50OHM, R637 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL XT602 64539-021-009 CRYSTAL;32.768KHZ SME LOCAL R638 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL XT6102 2801-003311 CRYSTAL-UNIT;17.734475MHZ,50PPM,28-AAA,16PF R640 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL Samsung Electronics...
Page 47
C362 2401-001912 C-AL;1UF,20%,50V,GP,BK,5X11MM,2MM SME LOCAL IC303 1209-001023 IC-DELAY LINE;SS23377M,SOP,14P,225MIL,PLASTI C363 2203-001608 C-CERAMIC,CHIP;22NF,+80-20%,50V,Y5V,TP,2012,- L301 AC27-92001B COIL-PEAKING AXIAL;BAL04ST101K,-,-,-,- SME LOCAL C364 2401-001912 C-AL;1UF,20%,50V,GP,BK,5X11MM,2MM SME LOCAL L303 2701-000206 INDUCTOR-AXIAL;56UH,5%,2.4X3.4MM SME LOCAL C366 2202-000797 C-CERAMIC,MLC-AXIAL;10NF,30%,16V,Y5P,TP,3.5X19,- SME LOCAL L304 2701-000206 INDUCTOR-AXIAL;56UH,5%,2.4X3.4MM SME LOCAL Samsung Electronics...
Page 48
SME LOCAL R337 2001-000472 R-CARBON;2.7KOHM,5%,1/8W,AA,TP,1.8X3.2M C426 2203-001557 C-CERAMIC,CHIP;100NF,+80-20%,25V,Y5V,TP,2012, SME LOCAL R338 2001-000734 R-CARBON;4.7KOHM,5%,1/8W,AA,TP,1.8X3.2M SME LOCAL C427 2401-001975 C-AL;47UF,20%,16V,GP,TP,5X11MM,5 SME LOCAL R339 2001-000429 R-CARBON;1KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL C428 2203-002188 C-CERAMIC,CHIP;10NF,+80-20%,16V,Y5V,TP,2012,- SME LOCAL R340 2001-000449 R-CARBON;2.2KOHM,5%,1/8W,AA,TP,1.8X3.2M SME LOCAL C429 2201-000796 C-CERAMIC,DISC;10NF,10%,50V,Y5P,TP,6.5X3,5 Samsung Electronics...
Page 49
SME LOCAL Q802 0501-000303 TR-SMALL SIGNAL;KSA733-Y,PNP,250MW,TO-92,-,120 SME LOCAL R4A6 2007-001555 R-CHIP,MELF;27KOHM,5%,1/8W,DB,BK,2012 SME LOCAL Q803 0501-000398 TR-SMALL SIGNAL;KSC945,NPN,250MW,TO-92,TP SME LOCAL R4A7 2007-001555 R-CHIP,MELF;27KOHM,5%,1/8W,DB,BK,2012 SME LOCAL Q812 0504-000203 TR-DIGITAL;KSR1004,NPN,300MW,47K-47K,TO-9 SME LOCAL R4A8 2001-000595 R-CARBON;3.3MOHM,5%,1/8W,AA,TP,1.8X3.2M SME LOCAL Q813 0504-000142 TR-DIGITAL;KSR2001,PNP,300MW,4.7K-4.7K,TO SME LOCAL Samsung Electronics...
Page 50
(SHUTTLO OPT.) 2007-000483 R-CHIP;1OHM,5%,1/10W,DA,TP,2012 SME LOCAL L701 AC27-92001B COIL-PEAKING AXIAL;BAL04ST101K,-,-,-,- SME LOCAL XT01 64539-102-311 CERAMIC RESONATOR;CSB455EBL/KBR455BKTL L703 2701-000181 INDUCTOR-AXIAL;33UH,5%,2.4X3.4MM SME LOCAL LD701 0601-000497 LED;ROUND,GRN,3MM,565NM Q701 0504-000203 TR-DIGITAL;KSR1004,NPN,300MW,47K-47K,TO-9 SME LOCAL R701 2004-000292 R-METAL;12OHM,5%,1/4W,AA,TP,2.4X6.4MM SME LOCAL R702 2001-000290 R-CARBON;10KOHM,5%,1/8W,AA,TP,1.8X3.2MM SME LOCAL Samsung Electronics...
Page 51
Electrical Parts List MEMO Samsung Electronics...
Important safety notices : Components identified with the mark ! have the special characteristics for safety. When replacing any of these components. Use only the same type. 3 Block Identification of Main PCB (Component Side) (Conductor Side) 11-2 Samsung Electronics...
Schematic Diagrams PB Y PROCESS REC LINEAR AUDIO REC Y PROCESS 11-3 Audio/Video (SV-A20GK/A40GK/SV-200G/205G) REC C PROCESS PB C PROCESS PB LINEAR AUDIO 11-6 Samsung Electronics...
Page 64
Schematic Diagrams PB Y PROCESS REC LINEAR AUDIO REC Y PROCESS 11-4 Audio/Video (SV-A60G/A80G/SV-400G/405G) REC C PROCESS PB C PROCESS PB LINEAR AUDIO 11-8 Samsung Electronics...