Page 1
SERVICE MANUAL HOME CINEMA CONTROL CENTER MB105 2003 RX-ES1SL Area suffix A ------------------------- Australia TABLE OF CONTENTS PRECAUTION............... . . 1-3 SPECIFICSERVICE INSTRUCTIONS .
Page 2
SPECIFICATION Amplifier Output Power 100 W per channel*, min. RMS, driven into 8 Ω at 1 kHz with no more At stereo operation Front channels than 0.8% total harmonic distortion. (IEC268-3) 100 W per channel*, min. RMS, driven into 8 Ω at 1 kHz with no more At surround operation Front channels than 0.8% total harmonic distortion.
Page 3
SECTION 1 PRECAUTION Safety Precautions (1) This design of this product contains special hardware and voltmeter. many circuits and components specially for safety purpos- Move the resistor connection to each exposed metal es. For continued protection, no changes should be made part, particularly any exposed metal part having a return to the original design unless authorized in writing by the path to the chassis, and measure the AC voltage across...
Page 4
SECTION 2 SPECIFIC SERVICE INSTRUCTIONS This service manual does not describe SPECIFIC SERVICE INSTRUCTIONS. 1-4 (No.MB105)
Page 5
SECTION 3 DISASSEMBLY Main body section 3.1.1 Removing the top cover Top cover (See Figs.1 and 2) (1) From the back side of the main body, remove the three screws A attaching the top cover.(See Fig.1) (2) From the both sides of the main body, remove the four screws B attaching the top cover.(See Fig.1) (3) Release the six joints a using a longer driver from the inside.(See Fig.2)
Page 6
3.1.3 Removing the rear panel (See Fig.5) • Prior to perform the following procedure, remove the top cover. Strain relief (1) From the back side of the main body, remove strain relief Rear panel from the rear panel in the direction of the arrow. (2) Remove the twenty-four screws E attaching the rear panel.
Page 7
3.1.7 Removing the AC power supply board (See Figs.8 and 9) • Prior to perform the following procedures, remove the top Rear panel cover and tuner. Strain relief (1) From the top side of the main body, cut the tie band and disconnect the wires from the connectors CN203 CN205...
Page 8
3.1.9 Removing the main board (See Fig.11) • Prior to perform the following procedures, remove the top Amp. board cover, front panel assembly, rear panel, tuner, digital input CN516 Rectifier board CN519 board, digital output board, AC power supply board and DC Wire clamp power board.
Page 9
3.1.12 Removing the fan motor (See Figs.13 and 14) • Prior to perform the following procedures, remove the top Fan assembly cover, tuner and AC power supply board. DC power board CN207 (1) From the top side of the main body, cut the tie band and disconnect the wire from the connector CN207 on the DC...
Page 10
3.1.15 Removing the FL board (See Fig.16) • Prior to perform the following procedures, remove the top Front panel assembly cover and front panel assembly. (1) From the inside of the front panel assembly, remove the six screws V attaching the FL board. (2) Disconnect the wire from the connector CN403 on the FL...
Page 11
SECTION 4 ADJUSTMENT This service manual does not describe ADJUSTMENT. (No.MB105)1-11...
Page 12
SECTION 5 TROUBLESHOOTING This service manual does not describe TROUBLESHOOTING. 1-12 (No.MB105)
Page 14
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MB105) Printed in Japan...
Page 15
SCHEMATIC DIAGRAMS HOME THEATER RECEIVER RX-ES1SL CD-ROM No.SML200311 Area suffix A ------------------------- Australia Contents Block diagram Standard schematic diagrams 2-10 to 14 Printed circuit boards No.MB105SCH COPYRIGHT 2003 VICTOR COMPANY OF JAPAN, LTD. 2003/11...
Page 16
In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety.
Page 17
Block diagram Component output board Power amp. board Power amp. drv. board Digital input board IC672 Q2501 J5501 SMUTE S.MUTE Q672 Q101 IC11 IN_L LIN+/- DVD_Y IC609 Q115 to Q118 ANT/T.TONE IN_R RIN+/- SELECT1 IC12 IC610 Power amp. Q114 COAX IN DVD_Pb SDTI1 to 3 IC611...
Page 32
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MB105SCH)
Page 33
PARTS LIST [ RX-ES1SL ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix A ------------------------- Australia - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1) 3- 5 Electrical parts list (Block No.01~05)
Page 34
Exploded view of general assmbly and parts list Block No. Digital input boar Power amp. driver board Power amp. board Amp. board Support board Rectifier board FL board SW board Volume board...
Page 35
Digital output board board 52 58 Connector board Main board AC power supply board DC power board Headphone jack board...
Page 36
Part Name Description Local QYSBSG3008E TAPPING SCREW 3mm x 8mm QUQ412-1107CJ FFC WIRE QUQ412-0508CJ FFC WIRE LV10781-007A FRONT PANEL QUQ412-1114CJ FFC WIRE LV43338-002A JVC MARK VYSH101-009 SPACER LV43622-001A FOOT (x2) LV43550-001A LABEL LV43381-002A FILTER LV34361-002A RATING LABEL LV21463-008A FRONT LENS QQR0594-001...
Page 37
Electrical parts list Front board Symbol No. Part No. Part Name Description Local Block No. [0][1][0][0] D407 SLR-342VC-T Symbol No. Part No. Part Name Description Local D408 204-10SUBC/A4UV D409 204-10SUBC/A4UV D410 MA111-X SI DIODE System control & IC401 MN101C35DMF FL driver ...
Page 38
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R234 NRSA63J-102X MG RESISTOR 1k$ 1/16W J CN711 QGD2501C1-03Z CONNECTOR (1-3) R235 NRSA63J-104X MG RESISTOR 100k$ 1/16W J DI401 QLF0116-001 FL TUBE ...
Page 39
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local IC681 MM1563DF-X Regulator Q1806 2SA1514K/RS/-X TRANSISTOR IC682 IMX9-W TRANSISTOR Driver Q1807 2SA1514K/RS/-X TRANSISTOR IC683 MM1613DN-X Regulator Q1808 2SA1514K/RS/-X TRANSISTOR Dual Operational Q1901 2SA1514K/RS/-X TRANSISTOR IC690...
Page 40
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local D1951 MA111-X SI DIODE C673 NCB31CK-103X C CAPACITOR 0.01uF 16V K C677 NCS31HJ-101X C CAPACITOR 100pF 50V J C301 QETN1HM-105Z E CAPACITOR 1uF 50V M C679 NCS31HJ-101X...
Page 41
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C827 NCB31EK-104X C CAPACITOR 0.1uF 25V K C1827 NCB21HK-104X C CAPACITOR 0.1uF 50V K C828 NCB31EK-104X C CAPACITOR 0.1uF 25V K C1828 NCB21HK-104X C CAPACITOR 0.1uF 50V K...
Page 42
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C2589 NCF31CZ-104X C CAPACITOR 0.1uF 16V Z R393 NRSA63J-684X MG RESISTOR 680k$ 1/16W J C2590 NCF31CZ-104X C CAPACITOR 0.1uF 16V Z R394 NRSA63J-684X MG RESISTOR 680k$ 1/16W J...
Page 43
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R718 NRSA63J-122X MG RESISTOR 1.2k$ 1/16W J R852 NRSA63J-472X MG RESISTOR 4.7k$ 1/16W J R719 NRSA63J-122X MG RESISTOR 1.2k$ 1/16W J R853 NRSA63J-273X MG RESISTOR 27k$ 1/16W J...
Page 44
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R1317 NRSA63J-153X MG RESISTOR 15k$ 1/16W J R1941 NRSA63J-101X MG RESISTOR 100$ 1/16W J R1318 NRSA63J-153X MG RESISTOR 15k$ 1/16W J R1943 NRSA63J-221X MG RESISTOR 220$ 1/16W J...
Page 45
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local L701 QQL28AK-221 CHOKE COIL 220uH K Q514 2SC3576-JVC-T TRANSISTOR L1301 QQL67AM-220 COIL 22uH M Q515 2SC3576-JVC-T TRANSISTOR L1302 QQL67AM-220 COIL 22uH M Q516 2SC3576-JVC-T...
Page 46
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C538 QETN1HM-106Z E CAPACITOR 10uF 50V M C4538 NCS31HJ-470X C CAPACITOR 47pF 50V J C539 QETN1HM-106Z E CAPACITOR 10uF 50V M C4539 QETN0JM-477Z E CAPACITOR 470uF 6.3V M...
Page 47
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R1506 NRSA63J-103X MG RESISTOR 10kW 1/16W J R4509 NRSA63J-473X MG RESISTOR 47kW 1/16W J R1507 NRSA63J-104X MG RESISTOR 100kW 1/16W J R4510 NRSA63J-473X MG RESISTOR 47kW 1/16W J...
Page 48
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local CN541 QGF1205C1-05 CONNECTOR FFC/FPC (1-5) R169 NRSA63J-104X MG RESISTOR 100kW 1/16W J CN551 QGF1205C1-06 CONNECTOR FFC/FPC (1-6) R170 NRSA63J-104X MG RESISTOR 100kW 1/16W J CN561 QGF1205F1-05 CONNECTOR...
Page 49
Symbol No. Part No. Part Name Description Local R107 NRSA63J-102X MG RESISTOR 1kW 1/16W J R108 NRSA63J-102X MG RESISTOR 1kW 1/16W J R109 NRSA63J-101X MG RESISTOR 100W 1/16W J R110 NRSA63J-101X MG RESISTOR 100W 1/16W J R111 NRSA63J-101X MG RESISTOR 100W 1/16W J R112 NRSA63J-101X...
Page 50
Packing materials and accessories parts list Block No. A2,A3,A4 A5,A6,A7 3-18...
Page 51
Packing and accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local RM-SQPES1U REMOCON ------------ BATTERY (x2) LVT1002-012B INST BOOK QAL0457-001 ANT.WIRE QAL0476-001 AM LOOP ANT BT-56012-1 WARRANTY CARD QAM0199-002 PIN CABLE LV34165-004A CARTON BOX LV21466-001A CUSHION(FRONT) LV21467-001A CUSHION(REAR) QPC06507015P...