Figure 11. Parking Brake Lever; Figure 12. Parking Brake Adjustment - Equipter RB4000 Operator's Manual

dump position and must be secured with the support
arm in place but never have the dump box in the
lifted position.
All personnel must stay off and all body parts out
from under the dump box at all times the lift is not
in the transport position.
Every 8 hours of operation or daily the following
should be checked:
• Check Engine Oil Level - Refer to Engine
Operation Manual.
• Check and adjust parking brake. (See illus-
tration). Ensure that the Parking Brake is
working properly.

Figure 11. Parking Brake Lever.

• If parking brake does not hold trailer
and lever adjustment is at the maximum,
chock trailer tires and turn knob on top
of lever fully counter clockwise. Loosen
jam nut (A). Tighten nut (B) until there is
approximately a business card clearance
between brake pads (C) and rotor (D)
on each side. Tighten jam nut (A). Adjust
parking brake as shown in figure 11.
04/13/16
New Heights LLC
11 Township Drive
Paradise, PA 17562
Phone: 717-768-0070 • Fax: 717-768-8910
Web: www.equipter.com

Figure 12. Parking Brake Adjustment.

• Check Tire Inflation Pressure with tires cold
(not been driven for at least 3 hours). Rec-
ommended inflation pressure is on the "Tire
and Loading Information" placard located
on the hitch.
If tires are replaced, be sure they are sized for
the rim and meet or exceed the load capacity of
the original tires supplied by the factory.
• Check Hydraulic Fluid Level - With the
Equipter on level ground, the dump bed
down and retracted, the outriggers raised,
and the steering wheels down, the hydraulic
oil level should be visible in the sight gauge
in between the top and bottom of the tem-
perature gauge (normal reading should be
between 1/4 and 1/2 on the gauge). If nec-
essary to refill, use only approved SAE 5W
hydraulic oil.
New Heights, LLC recommends changing the
hydraulic oil filter every year and the hydraulic oil
every 2 years.
The following are approved oil sources:
Chevron Rando HD Prem MV Hyd Oil
Mobil
Castrol
12
Mobil DTE 12 or 12M
Aerial Lift
CAT E4000OM-0416