Table of Contents
Advertisement
A.J. Antunes & Co.
Place this manual in the Toaster section
of your Equipment Manual.
Manufactured exclusively for
McDONALD'S ®
BY
A.J. ANTUNES & CO.
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: 1-630-784-1000
TOLL FREE: 1-877-392-7854
FAX: 1-630-784-1650
www.ajantunes.com
Owner Information .....................................................2
General ......................................................................2
Service/Technical Assistance ....................................2
Warranty Information .................................................2
Specifications .............................................................3
Electrical Specifications & Plug Configuration ..........3
Pass Through Time ...................................................3
Dimensions ................................................................3
Important Safety Information ....................................4
Installation ...................................................................5
Unpacking ..................................................................5
Location .....................................................................5
Operation .....................................................................6
Operating Instructions ...............................................6
The Antunes Food Service Equipment Division of A.J. Antunes & Co. provides the following limited warranty to the original purchaser of all McDonald's Equipment.
All components are warranted against defects in the material and workmanship for a period of two (2) years from date of original installation.
If any part becomes defective during the period of this Warranty, Antunes Food Service will pay labor costs to an Authorized Service Agent to replace the part plus
travel expenses.
WARRANTY EXCLUSIONS
• The cost of Installation.
• Equipment that has been damaged due to shipment. Purchaser should
make damage claim directly upon carrier.
• Alteration, misuse, abuse.
• Improper storage or handling.
• Improper maintenance.
• Failure to follow proper Installation instructions, including electrical
connection.
Antunes Food Service reserves the right to make changes in design or add improvements on any products. The right is always reserved to modify Equipment
because of factors beyond our control and government regulation. Changes to Equipment do not constitute a warranty charge.
This warranty is exclusive and is in lieu of all other warranties, expressed or implied, including any implied warranty of merchantability or fitness for a particular
purpose, each of which is expressly disclaimed. The remedies described above are exclusive, and in no event shall A.J. Antunes & Co. or any of its Divisions be
liable for special consequential or incidental damages for the breach or delay in the performance of this warranty.
This manual is for the exclusive use of licensees and employees of McDonald's Systems, Inc..
P/N 1011256 Rev. B 03/15
McDonald's
HORIZONTAL CONTACT TOASTER
HCT-5H
MFG. NO. 9210850
A.J. Antunes & Co.
HCT-5H & HRT-5H
Scan with mobile device or enter URL
for product and service information.
http://tiny.cc/ajaHCT-HRT
TABLE OF CONTENTS
LIMITED WARRANTY
© McDonald's Corporation All Rights Reserved
HCT-5H BUN TOASTER
Language Selection ...................................................6
Programming ..............................................................7
Control Panel .............................................................7
Settings ......................................................................7
Light/Dark Adjustment ...............................................7
Purging Product from Toaster ....................................7
Factory Reset ............................................................7
Maintenance ................................................................8
Daily Cleaning ...........................................................8
Quarterly Maintenance ..............................................9
Troubleshooting .......................................................12
Replacement Parts ...................................................16
Wiring Diagram .........................................................21
Notes..........................................................................22
• Improper or unauthorized repairs.
• Scheduled Maintenance procedures as outlined in your MRC Card.
• This Warranty does not cover Consumable items. NOTE: The Conveyor Belt
wraps are consumable items that can be easily adjusted or replaced accord-
ing to the Maintenance Section of this product's Owner's Manual.
• Water pressure problems or contamination problems such as foreign material
in water lines or inside solenoid valves due to an incoming water source.
• Freight, foreign, excise, municipal or other sales or use taxes.
• Consequential damages such as loss of profit, loss of time, the cost of repair-
ing or replacing other property which is damaged, or any other incidental
damage of any kind.
1
A.J. Antunes & Co.
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for A.J.Antunes HCT-5H
Summary of Contents for A.J.Antunes HCT-5H
-
Page 1: Table Of Contents
HORIZONTAL CONTACT TOASTER A.J. Antunes & Co. HCT-5H BUN TOASTER HCT-5H MFG. NO. 9210850 Place this manual in the Toaster section A.J. Antunes & Co. of your Equipment Manual. Manufactured exclusively for McDONALD’S ® A.J. ANTUNES & CO. 180 KEHOE BLVD. -
Page 2: Owner Information
HCT-5H BUN TOASTER OWNER INFORMATION General Fill in the information below and have it handy when calling your Authorized Service Agency for assistance. This manual provides the safety, installation, and The serial number is on the specification plate located operating procedures for this unit. Please read this on the rear of the unit. -
Page 3: Specifications
30 Amps, 250 VAC 9210850 Pass Through Time CAUTION For all HCT-5H units the pass through time is All electrical connections must be in accordance with 17 seconds (+/- 2 seconds). local electrical codes and any other applicable codes. Dimensions 17.75”... -
Page 4: Important Safety Information
HCT-5H BUN TOASTER IMPORTANT SAFETY INFORMATION In addition to the warnings and cautions in this manual, WARNING use the following guidelines for safe operation of the To avoid possible personal injury and/or dam- unit. age to the unit, all inspections, tests, and repair of electrical equipment should be performed by •... -
Page 5: Installation
1. Place the toaster in the required position desig- nated by McDonald’s. NOTE: The HCT-5H is designed to be used with the HRT-5H toaster. When installed together, the HRT- 5H should be placed on top of the HCT-5H. 2. Attach the Bun Feeder, Crumb Tray, and Bun Buffer Frame (Figure 1). -
Page 6: Operation
HCT-5H BUN TOASTER OPERATION Language Selection Operating Instructions Follow these steps to set the language option for the Follow these steps to start the toaster: toaster. 1. Plug in the power cord. Press and release the Power Button to turn on. Wait until the Control 1. -
Page 7: Programming
Button 1. When the unit is plugged in, press and hold the MENU button (Figure 4) for five seconds. The Figure 3. HCT-5H Control Panel control panel displays “Platen A” Factory Reset NOTE: The unit does not have to be turned on in order to access the settings menu. -
Page 8: Maintenance
4. Wash the Bun Feeder, Crumb Tray, and Bun Bun Buffer Frame Buffer Frame at the three-compartment sink. Allow to air dry. Figure 4. HCT-5H Components 5. Reattach the Bun Feeder, Crumb Tray, and Bun Buffer Frame. NOTE: Be sure to clean and sanitize the Belts com- 6. -
Page 9: Quarterly Maintenance
HCT-5H BUN TOASTER MAINTENANCE (continued) Quarterly Maintenance NOTE: The Belt Wraps are considered a con- sumable item that can be easily maintained and replaced according to these instructions. Quarterly Maintenance includes all daily maintenance as well as the replacement of belt wraps. - Page 10 HCT-5H BUN TOASTER MAINTENANCE (continued) REMOVING BELTS 1. Turn the toaster off. The toaster enters a cool- down mode and automatically shuts down when complete. 2. Unplug the power cord once the cool-down period is complete. 3. Put on neoprene gloves. Remove the Bun Feeder, Crumb Tray, and Bun Buffer Frame.
- Page 11 The snaps on the belts should face the Bun Buffer Frame inside of the top rollers. Figure 4. HCT-5H Components 5. Slide the first crown belt over the rear top roller and rear bottom roller. Repeat this step for the club/ heel belt and the second crown belt.
-
Page 12: Troubleshooting
HCT-5H BUN TOASTER TROUBLESHOOTING WARNING To avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equip- ment should be performed by qualified service personnel. The unit should be unplugged when servicing, except when electrical tests are required. - Page 13 HCT-5H BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause(s) Corrective Action Display Reads “Heater The Platen Heater A heater did not reach Cycle Power OFF/ON. If message persists, A Fail” set-point temperature. then Call AJA Technical Support 877-392-7854 for assistance. Display Reads “Sensor Platen Thermocouple A sensor has A Fail”...
- Page 14 HCT-5H BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause(s) Corrective Action No Display Power Cord is not plugged into the outlet Unplug the power cord then firmly plug back in No power at outlet Contact your electrician Circuit Breaker is Tripped or OFF...
- Page 15 HCT-5H BUN TOASTER TROUBLESHOOTING (continued) Problem Possible Cause(s) Corrective Action Buns are toasting too Incorrect temperature set-points Perform a factory reset as detailed in dark “Programming Section” of this owner’s manual. Call AJA Technical Support 877-392-7854 for assistance Incorrect motor speed Perform a factory reset as detailed in “Programming Section”...
-
Page 16: Replacement Parts
HCT-5H BUN TOASTER REPLACEMENT PARTS Item Part No. Description Qty. Item Part No. Description Qty. 0022045 Weldment, Hinge Bracket - Bottom 0200331 Mica, Spacer Front 0200329 Base Gasket, 33.86” Lg 0400438 Spacer, 1.25Od X .03Thk, Nomex 0200330 Base Gasket, 19.52” Lg 0504320 Spacer 0.781 X 1.125 X 0.06”... - Page 17 HCT-5H BUN TOASTER REPLACEMENT PARTS (continued) Item Part No. Description Qty. Item Part No. Description Qty. 4050240 Relay, Solid State Dual Pole 3080157 Screw, Tap 8-32 X 3/8”Lg W/Conn-Recept 0506961 Plate, Motor Mounting 4051010 Relay, Random Phase, Solid State-50A 1 21000-0046 Standoff, 1/4”...
- Page 18 HCT-5H BUN TOASTER REPLACEMENT PARTS (continued) NOTE: See Page 20 for Parts List. P/N 1011256 Rev. B 03/15 McDonald’s A.J. Antunes & Co.
- Page 19 HCT-5H BUN TOASTER REPLACEMENT PARTS (continued) NOTE: See Page 20 for Parts List. P/N 1011256 Rev. B 03/15 McDonald’s A.J. Antunes & Co.
- Page 20 HCT-5H BUN TOASTER REPLACEMENT PARTS (continued) Item Part No. Description Qty. Item Part No. Description Qty. 0013035 Adj. Platen Assembly 2150250 Bearing, Flanged 0021725 Weldment, Bearing 2150251 Sprocket, 25B14 3/8” Bore Bracket & Spring Guide - LH 2150285 Bearing, Single Groove S/S...
-
Page 21: Wiring Diagram
HCT-5H BUN TOASTER WIRING DIAGRAM P/N 1011256 Rev. B 03/15 McDonald’s A.J. Antunes & Co. -
Page 22: Notes
HCT-5H BUN TOASTER NOTES P/N 1011256 Rev. B 03/15 McDonald’s A.J. Antunes & Co. - Page 23 HCT-5H BUN TOASTER NOTES (continued) P/N 1011256 Rev. B 03/15 McDonald’s A.J. Antunes & Co.
Need help?
Do you have a question about the HCT-5H and is the answer not in the manual?
Questions and answers