Related Manuals for Clarke SHHH AIR 100/24
Summary of Contents for Clarke SHHH AIR 100/24
- Page 1 Shhhair 100-24, 100-50, 150,100.book Page 1 Wednesday, July 30, 2008 5:23 PM SILENT AIR COMPRESSOR MODEL NO: SHHHAIR 100/24, 100/50, 150/100 PART NO: 2320880, 2320885, 2320890, OPERATION & MAINTENANCE INSTRUCTIONS 0708...
-
Page 2: Parts And Servicing
Shhhair 100-24, 100-50, 150,100.book Page 2 Wednesday, July 30, 2008 5:23 PM INTRODUCTION Thank you for purchasing this CLARKE Silent Air Compressor. Before attempting to use this product, please read this manual thoroughly and follow the instructions carefully. In doing so you will ensure the safety of yourself and that of others around you, and you can look forward to your purchase giving you long and satisfactory service. -
Page 3: Safety Precautions
2. DO NOT operate your compressor with any guards removed. 3. Electrical or mechanical repairs should only be carried out by a qualified engineer. If problems occur, contact your Clarke dealer. 4. Before carrying out any maintenance, ensure the pressure is expelled from the air receiver, and the machine is disconnected from the mains supply. -
Page 4: Electrical Connections
Shhhair 100-24, 100-50, 150,100.book Page 4 Wednesday, July 30, 2008 5:23 PM ELECTRICAL CONNECTIONS Connect the mains lead to a standard, 230 Volt (50Hz) electrical supply through an approved 13 amp BS 1363 plug, or a suitably fused isolator switch. WARNING: THIS APPLIANCE MUST BE EARTHED IMPORTANT: The wires in the mains lead are coloured in accordance with the following code:... -
Page 5: Preparing For Use
1. Make sure that the oil level is half way up the oil sight glass. 2. If not, remove the oil cap and top up the reservoir. • Only use Clarke synthetic compressor oil, available from your Clarke dealer (Part No. 3050795). -
Page 6: Switching The Air Compressor On
Shhhair 100-24, 100-50, 150,100.book Page 6 Wednesday, July 30, 2008 5:23 PM SWITCHING THE AIR COMPRESSOR ON The compressor will make a continuous loud noise when the tank is charging - this is normal. 1. To start the compressor, turn the ON/OFF switch to the ‘I’... -
Page 7: Shutting Down The Compressor
NOTE: If the machine pumps continuously without cutting out then the compressor is too small for the application/tool being used, and damage may result. Consult your Clarke dealer. NOTE: DO NOT exceed the duty cycle for the machine (see Specifications). -
Page 8: Draining The Tank
Shhhair 100-24, 100-50, 150,100.book Page 8 Wednesday, July 30, 2008 5:23 PM DRAINING THE TANK 1. Pressurise the reservoir slightly and then turn the compressor off. 2. Attach the small hose supplied to the vent valve as shown. 3. Place a tray beneath the vent valve to collect any condensate. -
Page 9: Troubleshooting
Shhhair 100-24, 100-50, 150,100.book Page 9 Wednesday, July 30, 2008 5:23 PM TROUBLESHOOTING PROBLEM PROBABLE CAUSE REMEDY The compressor will not start, Bad connections Check the electrical or stops and will not start connections again Blown fuse Replace fuse Overload cutout switch has Wait 25-20 mins before tripped attempting to restart... -
Page 10: Maintenance
Shhhair 100-24, 100-50, 150,100.book Page 10 Wednesday, July 30, 2008 5:23 PM MAINTENANCE Before Once Once each a Year Month Check the oil level, See “Adding Oil” on page 5. Drain the water collected in the air outlet filter. See “Draining the Tank”... -
Page 11: Replacing The Air Outlet Filter
Shhhair 100-24, 100-50, 150,100.book Page 11 Wednesday, July 30, 2008 5:23 PM CHECK THE NON RETURN VALVES If the tank pressure decreases for no apparent reason, it is possible that the non-return valve is leaking. To check, ensure the tank is under pressure and the machine switched OFF, 1. -
Page 12: Specifications
500mL Synthetic Oil Oil Part No. 3050795 3050795 3050795 Please note that the details and specifications contained herein, are correct at the time of going to print. CLARKE International reserve the right to change specifications at any time without prior notice. - Page 13 Shhhair 100-24, 100-50, 150,100.book Page 13 Wednesday, July 30, 2008 5:23 PM EXPLODED DIAGRAM & PARTS LIST...
- Page 14 Shhhair 100-24, 100-50, 150,100.book Page 14 Wednesday, July 30, 2008 5:23 PM EXPLODED DIAGRAM & PARTS LIST...
- Page 15 Shhhair 100-24, 100-50, 150,100.book Page 15 Wednesday, July 30, 2008 5:23 PM EXPLODED DIAGRAM & PARTS LIST...
- Page 16 Shhhair 100-24, 100-50, 150,100.book Page 16 Wednesday, July 30, 2008 5:23 PM EXPLODED DIAGRAM & PARTS LIST...
-
Page 17: Exploded Diagram And Parts List
Shhhair 100-24, 100-50, 150,100.book Page 17 Wednesday, July 30, 2008 5:23 PM EXPLODED DIAGRAM & PARTS LIST DESCRIPTION DESCRIPTION C0037 Screw TCEI 6X20 C0247 Air Hose C0106 Spacer T21 C0292 Air Pipe MM 260 1/8FX1/8F Rotable C0109 Capacitor Bracket C0293 Air Pipe MM 300 1/8FX1/8F Rotable C0111 Overload Protector T2134A (230V) - Page 18 The CE mark was first applied in: 2003 Product Description: Silent Air Compressor Model number(s): SHHHAIR 100/24 Serial / batch Number: Current Manufacture Date of Issue: 01/05/2008 Signed A.C. AIKEN Senior Manager Clarke International. SHHHAIR-100-24-RV1.doc Page 1 of 1...
- Page 19 The CE mark was first applied in: 2003 Product Description: SILENT AIR COMPRESSOR Model number(s): SHHHAIR 100/50 Serial / batch Number: CURRENT MANUFACTURE Date of Issue: 01/01/1901 Signed A.C. AIKEN Senior Manager Clarke International. - 1 -...
- Page 20 The CE mark was first applied in: 2003 Product Description: SILENT AIR COMPRESSOR Model number(s): SHHHAIR 150/100 Serial / batch Number: CURRENT MANUFACTURE Date of Issue: 01/05/2008 Signed A.C. AIKEN Senior Manager Clarke International. - 1 -...
- Page 21 Shhhair 100-24, 100-50, 150,100.book Page 20 Wednesday, July 30, 2008 5:23 PM...
Need help?
Do you have a question about the SHHH AIR 100/24 and is the answer not in the manual?
Questions and answers