Flasher Switch (Groundsmaster 4010--D) - Toro Groundsmaster 4000-D Service Manual

Flasher Switch (Groundsmaster 4010- -D)
On Groundsmaster 4010--D machines, the flasher
switch is used as an input for the TEC controller to pro-
vide power for the four way flashers. The switch is lo-
cated on the steering tower (Fig. 52).
Testing
1. Before disconnecting the flasher switch for testing,
the switch and its circuit wiring should be tested as a
TEC input with the InfoCenter Display (see InfoCenter
Display in this chapter). If the InfoCenter verifies that the
flasher switch and circuit wiring are functioning correct-
ly, no further switch testing is necessary. If, however, the
InfoCenter determines that the flasher switch and circuit
wiring are not functioning correctly, proceed with test.
2. Make sure ignition switch is OFF. Remove key from
ignition switch.
3. Remove front steering tower cover (see Steering
Tower in the Service and Repairs section of Chapter 7
-- Chassis).
4. Locate flasher switch and unplug wire harness con-
nector from switch.
5. The switch terminals are marked as shown in Figure
53. The circuit logic of the flasher switch is shown in the
chart below. With the use of a multimeter (ohms setting),
the switch functions may be tested to determine whether
continuity exists between the various terminals for each
position. Verify continuity between switch terminals. Re-
place flasher switch if testing identifies a faulty switch.
SWITCH CLOSED
POSITION CIRCUITS
ON (LIGHT
END DE-
PRESSED)
OFF
6. Connect the harness connector to the switch after
testing.
7. If switch tests correctly and circuit problem still ex-
ists, check wire harness (see Electrical Schematics and
Wire Harness Drawings in Chapter 10 -- Foldout Draw-
ings).
8. Install front steering tower cover (see Steering Tower
in the Service and Repairs section of Chapter 7 -- Chas-
sis).
Electrical System
OPEN
CIRCUITS
2 + 3 2 + 1
5 + 6 5 + 4
2 + 1 2 + 3
5 + 4 5 + 6
1. Steering column
Page 5 - - 44
2
1
Figure 52
2. Flasher switch
BACK OF SWITCH
Figure 53
Groundsmaster 4000--D/4010--D