Service Manual ViewSonic N3250w-1L Model No. VS11335-1L 32” LCD TV (N3250w-1L_SM Rev.1b_Aug.2008) ® ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583...
Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
The LCD module should be supplied by power complied with requirements of Limited Power Source (IEC60950 or UL1950), or be applied exemption. (14) The LCD module is designed so that the CFL in it is supplied by Limited Current ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 5
Do not touch and that may cause “Mura” the surface of the polarizer. Take out the monitor with cushions Taking out the monitor by grasping the LCD panel. That may cause “Mura” ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 6
Place the monitor on a clean and soft foam pad. Placing the monitor on foreign objects. That could scratch the surface of the panel or cause “Mura” ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Typical. 0.35 V Audio Characteristics: AF Output Level Measured via LP 20 kHz Typical. 0.35Vrms Filter, RMS Decoder, 75us De-emphasis 10% (max.) 44 dB (min.) Compatible system TUNER NTSC/PAL Compatible system AV NTSC M/PAL ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 8
100-240VAC +/- 10% Wide Range Input Frequency Range 47-63 Hz Input Current 3.0A @ 115VAC // 1.5A @ 230VAC Max in < 150A (with fully loaded power supply) at Power Supply Inrush 230Vac ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 9
The product firmware of VS11257-1M / VS11335-1M shall have a firmware version of V:P01. Any changes/revisions afterward shall also be pre-approved by ViewSonic in written. For VS11257-1M / VS11335-1M, its firmware shall have a built-in frequency table for NTSC/ATSC off-air TV/CATV, Closed-Caption, and with MTS implementation.
Page 10
Painting Color - PANTONE 427C (Black for front bezel & back cover) Power Key - PANTONE 032C (RED) Key Pads – PANTONE 11C & PANTONE 5C(Cool Gray) Color Texts Printed on Front Cover and Key Pads - PANTONE 427C, PANTONE 433C(Black) ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 11
Molded Plastic Workmanship shall be inspected according to ViewSonic Molded Plastic Parts Specification, VSCMPPSPEC001V1.2. Screen Printed Parts, Bird Logo Artwork shall be provided and confirmed by ViewSonic. Recess Rear Label A label identifying the product name, model/serial number and FCC ID/Logo shall be placed into the rear label recess located on the rear panel of the chassis.
VOL+ and MENU buttons again to unlock it. 2. Press VOL- and VOL+ buttons at the same time to lock OSD menu, and press VOL- and VOL+ buttons again to unlock it. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
HDMI Input Terminal Connect this port to the HDMI output of A/V device. Headphone Jack Connect this port to your headphone. Power (AC input) Using power cord provided, connect to a power source. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Remote Control ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 15
Toggle to enable/disable Picture in Picture/Picture Out of Picture function 24 P.INPUT POP/PIP input source select 25 SWAP Switch between main screen and sub-screen Note: PIP means Picture In Picture. POP means Picture Out Of Picture. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Audio Out: To control sound output ON/OFF from the RCA audio out connectors. Note: To adjust the Audio settings, Smart Sound must be set to the User mode. (Select through the Sound button on the remote control) ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 17
Setup Menu — To set up OSD window Setup Menu is active in all input sources. • Language: To select a OSD language from English, Portuguese or Spanish. • Parental: To set up parental control. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 18
Aspect Ratio: To select image size between Normal, Full, Wide1, Wide2, Wide3, 4:3, 16:9, and No scale. • OSD Timeout: To setup the display time of OSD. (5, 15, 45, and 60 seconds) • Memory Recall: To restore the factory default settings. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 19
TV / YPbPr / AV / S-Video / VGA YPbPr TV / HDMI / AV / S-Video HDMI / YPbPr / VGA S-Video HDMI / YPbPr / VGA TV / HDMI / AV / S-Video ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 20
If you forget your initial password,you can press"8866"to resume. "MENU" Lock & Un-lock: Pressing "Vol+" and "Vol-" from Front Panel Keys. "POWER" Lock & Un-lock: Pressing "Vol+" and "MENU" from Front Panel Keys. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
MT8202 supports alpha blending for Video and two OSD planes. It also supports 10bit gamma correction and advanced dithering processing for LCD display with 6/8/10 bit output. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 22
CSDL,CSDA HDMI MT8202 Digital audio interface MT8293 Conn HDMI_PLUG_POWER LCD Controller IC PWR5V ector DSDL,DSDA KSDL,KSDA 0~23,DE,Hsync, Vsync,clk HDMI_HPD 12C interface 12C interface EEPROM for EEPROM for HDCP Key EDID CP10 interface ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 23
Digital audio, such as HDMI , have decoded by MT5351 and MT8293, is converted to I2S digital audio already. The I2S digital audio data is decoded and processed by MT8202, and then be delivered to AD8256 for audio amplifying. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
1.Fig. 1: under the picture 16 grey scale of VGA source, select WHITE BALANCE and press ENTER, The color warm will auto adjust. The act of EHITE BALANCEL is completed when the picture is steady. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 25
SPEAKER output is right. Meets earphone with the EARPHONE, Determined whether the action of EARPHONE output is normal. 1.4.10 All Modes Reset After final QC step, we must to erase all saved changes again and restore the factory defaults. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 28
TV set and check whether the TV set receives the signal of CH13. (3). After all of FUNCTION TEST completed, we must erase all saved changes again and restore the factory defaults. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 29
13.328ms 16.667ms 16.666ms V TOTAL 15.880ms 12.795ms 16.000ms 15.880ms V DISPLAY 0.600ms 0.466ms 0.444ms 0.600ms V B-Porch 0.124ms 0.050ms 0.111ms 0.124ms Vs Width 0.000ms 0.000ms 0.000ms 0.000ms V Border H/V Sync Interlace ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 30
H B-Porch 1.310us 1.037us H Width 0.000us 0.000us H Border 16.662ms 16.661ms V TOTAL 16.097ms 16.005ms V DISPLAY 0.377ms 0.594ms V B-Porch 0.126ms 0.047ms Vs Width 0.00ms 0.00ms V Border H/V Sync Interlace ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 31
DDC Card RS-232 cable Barcode Reader VGA Cable N3250W-L LCD TV DDC Card RS-232 Cable VGA Cable Barcode Reader 2.2 Setup Procedure 2.2.1 Connect VGA Card and DDC Card with RS-232 cable. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 32
2.2.3 Connect DDC Card and N3250W-L LCD TV with VGA Cable. (when key in DVI DDC information, use VGA transform to DVI port ) 2.2.4 Connect Power Cord to N3250W-L LCD TV. 2.3 DDC Key In Procedure 2.3.1 Run DDC.exe ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 33
2.3.2 Choose model number then 2.3.3 Press “ENTER” key. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 34
2.3.4 Press “F4” key. 2.3.5 Input barcode ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 35
2.3.6 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED 2.3.7 Exit program. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 36
3.1 Equipment Needed N3250W-L LCD TV RS-232 cable Barcode Reader HDMI Cable N3250W-L LCD TV RS-232 Cable HDMI Cable Barcode Reader 3.2 Setup Procedure 3.2.1Connect HDMI Card and DDC Card with RS-232 cable. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 37
3.2.2 Barcode Reader connects with keyboard and PC keyboard port. 3.2.3 Connect DDC Card and N3250W-L LCD TV with HDMI Cable. 3.2.4 Connect Power Cord to N3250W-L LCD TV. 3.3 DDC Key In Procedure 3.3.1 Run DDC.exe ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 38
3.3.2 Choose model number then 3.3.3 Press “ENTER” key. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 39
3.3.4 Input barcode 3.3.5 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED OK! 3.3.6 Exit program. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 40
4.4 Execute the Mtktool to start download the file. The Mtktool program will be upgraded if necessary. "MtkTool Auto BaudRate.exe" 4.5 The Mtktool Operat 4.5.1 Select Platform : MT8105 , MT1389 or MT8205 ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 41
4.5.2 Select COM port. Depends on the COM port assigned in System Device Manager (Refer below right). 4.5.3 Select Baud Rate. 115200x 8 (Suggestion) ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 42
4.5.4 Enable the USB Bridge. 4.5.5 Browsing the File to download. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 43
2. You can slow down the baud rate if some Flash memory can not works properly in high-speed download. 3. Please call the MediaTek contact window if any problem found like unsupported Flash Type or fail to download. ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 44
At last, close the carton and seal it with tape. (Figure 4) 1.Power Cord 2.VGA Cable 3.RF Cable 4.RCA Cable 5.User’s Guide 6.Remote contrl 7.Guarant Card 8.Battery Figure 3 Figure 4 ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 45
PACKING PART LIST ( N3250w-1L ) ViewSonic Model Number: VS11335-1L Rev: 1a Item ViewSonic P/N DESCRIPTION STATUS Ref. P/N Location Q'ty N3250W(L) monitor P-00005968 Polyethy Bag Active 2013054007P POLYETHY BAG P-00004461 Foam-EPE (Right) Active 2012184600P POLYFOAM (R) P-00004462 Foam-EPE (Left)
Page 46
Disassembly Procedure Disassembly of Stand and Dust Cover from LCD TV. 1.1 Unscrew 4 screws that secure Stand Unit and detach Dust Cover from the LCD TV. Stand Dust Cover Dust Cover ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 47
2. Disassembly of Rear Cover. 2.1 Unscrew 16 screws to remove Rear Cover. Rear Cover 3. Disassembly of Main Board,Power Board,IR Board,Speaker,Front Cover and Panel Unit. 3.1 Unscrew 14 screws to remove Shield Plate. Shield Plate ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 48
3.2. Unscrew 9 screws to remove Dust Cover and METAL FITTG. METAL FITTG-I/O-Down DUST COVER METAL FITTG-I/O-Side ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 49
3.3. Unscrew 5 screws and disconnect the wires to remove Main Board. Main Board 3.4. Unscrew 4 screws and disconnect the wires to remove Power Board. Power Board ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 50
3.5. Unscrew 3 screws and disconnect the wires to remove KeyPad Board. 3.6. Unscrew 8 screws to remove Speaker. Speaker ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 51
3.7. Unscrew 8 screws to remove Bracket.Fix. BRACKET,FIX 3.8. Unscrew 4 screws to remove IR Board. IR Board ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 52
3.9. Unscrew 4 screws to remove Front Cover. Front Cover 3.10. Lay Panel Unit facedown and unscrew 8 screws on its right,left,up and down sides, to remove Panel Bracket. Panel Bracket ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 53
3.11.Unscrew 8 screws to remove Bracket.and Panel Unit. Panel Unit ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Replace I106 Replace I135 signal output to I145? defective? Check I136 is Replace I136 defective? Check Pin37 of I145 is Check Earphone high? circuit Check I145 is Replace I145 defective? Check Speaker Wire ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 55
OK? Check 3.3V is on C113? Replace I101 1.9V is on I102 Pin2? Replace I102 Check IR Board Replace IR Board Check X100 is OK? Replace x100 Replace I106 & I107 ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 56
6.3. NO DISPLAY NTSC YPb Pr S-VIDEO Check Check Video wave form is Replace L221,R172 Check L224,R197,C340 is Replace L224,R197 or Replace I112 L221,R172,R173,C332,C33 on I112 Pin12 ? R173,C332,or C334 C340 4 is OK? Check Replace L215,R501,R170,C331 is L215.R501,R170 or C331 Check L226,R203,C335 is Replace L226,R203, or...
Page 57
Replace I106 Pin19~22 of P114 ? Check the LVDS wire from Replace LVDS Wire P114 to panel is OK? Check inverter wire from power board to panel is Replace Inverter Wire Replace Panel ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
10. Exploded View And Exploded Parts List ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 86
ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...
Page 87
EXPLODED PARTS LIST (N3250w-1L) ViewSonic Model Number: VS11335-1L Rev: 1a Serial No. Prefix: QBA Item ViewSonic P/N Ref. P/N Description Q'ty 2024267902P FRONT BEZEL 32AA ABS HB BLACK C 2054256101P ORNAMENT JC32 FRONT BAR ABS HB AL-PLATE 2033150500P IR COVER...
Remark 1: Above listed items are examples, supplier can expand the rows to add more necessary items. Remark 2: All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to elimin ViewSonic Corporation...
Page 89
BOM LIST (N3250w-1L) ViewSonic Model Number: VS11335-1L Rev: 1e Serial No. Prefix: Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T C100 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T C101...
Page 90
Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2341110296P CAP,CHIP 125'C CS 0603/COG/50V 1000p J T C447 2346110396P CAP,CHIP 125'C CS 0603/X7R/50V 0.01u K T C608 E-C-0404-4424 2341150996P CAP,CHIP 125'C CS 0603/COG/50V 5.0 p J T C609 2346110396P CAP,CHIP 125'C CS 0603/X7R/50V 0.01u K T...
Page 103
Company: Add: Tel: Fax: E-mail: After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes (marc.maupin@viewsonic.com) ViewSonic Corporation N3250w-1L Confidential - Do Not Copy...