PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
7.1.7 ID NUMBER AND ID DATA SETTING....................59 7.1.8 SEQUENCE AFTER POWER ON ......................62 7.1.9 DISASSEMBLY ............................. 63 7.2 IC ................................70 7.3 DISC / CONTENT FORMAT PLAYBACK COMPATIBILITY ..............84 7.4 CLEANING............................... 85 8. PANEL FACILITIES ............................86 u163 DV-363-S http://www.xiaoyu163.com...
Dolby Laboratories. • “DTS” and “DTS Digital Out” are registered trademarks of Digital Theater Systems, Inc. • TruSurround and the symbol are trademarks of SRS Labs, Inc. TruSurround tech- nology is incorporated under license from SRS Labs, Inc. u163 DV-363-S http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING 6, 7 "Operating Instructions" L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 7
Operating Instructions See Contrast table (2) (French) (2) CONTRAST TABLE DV-363-S/KUXU, KCXU, KUXQ, DV-363-K/KUXU, KCXU and KUXQ are constructed the same except for the fol- lowing : Mark No. Symbol and Description DV-363-S/KUXU DV-363-S/KCXU DV-363-S/KUXQ DV-363-K/KUXU DV-363-K/KCXU DV-363-K/KUXQ 7 Operating Instructions...
2.2 EXTERIOR SECTION 3 7 63 1515 0 Refer to "2.4 LOADING MECHA. ASSY". L 13942296513 u163 Refer to "2.3 FRONT PANEL SECTION". DV-363-S http://www.xiaoyu163.com...
Page 9
NSP 11 Base Chassis VNA2614 (2) CONTRAST TABLE DV-363-S/KUXU, KCXU, KUXQ, DV-363-K/KUXU, KCXU and KUXQ are constructed the same except for the fol- lowing : Mark No. Symbol and Description DV-363-S/KUXU DV-363-S/KCXU DV-363-S/KUXQ DV-363-K/KUXU DV-363-K/KCXU DV-363-K/KUXQ 12 Rear Panel VNA2536...
2.3 FRONT PANEL SECTION 3 7 63 1515 0 L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 11
VNE2300 Rubber Foot VEB1349 (2) CONTRAST TABLE DV-363-S/KUXU, KCXU, KUXQ, DV-363-K/KUXU, KCXU and KUXQ are constructed the same except for the fol- lowing : Mark No. Symbol and Description DV-363-S/KUXU DV-363-S/KCXU DV-363-S/KUXQ DV-363-K/KUXU DV-363-K/KCXU DV-363-K/KUXQ 6 Front Panel Assy VXA2561...
Z39-019 Flexible Cable (24P) VDA1945 Tray VNL1920 Connector Assy 2P VKP2253 Floating Rubber VEB1351 Belt VEB1330 Stabilizer VNE2253 Loading Base VNL1917 u163 Float Base DVD VNL1918 Drive Cam VNL1919 Gear Pulley VNL1921 Loading Gear VNL1922 Drive Gear VNL1923 DV-363-S http://www.xiaoyu163.com...
Page 13
Daifree No. 23 No. 23 GEM1036 GEM1036 Tray Tray Concave of unevenness Concave of unevenness Inner side of a ditch Daifree GEM1036 Top View Bottom View u163 Side of the rib Concave of unevenness Daifree Daifree GEM1036 GEM1036 DV-363-S http://www.xiaoyu163.com...
3 7 63 1515 0 Note : When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". POWER SUPPLY UNIT (VWR1365) ( or VWR1367) L 13942296513 DVDM ASSY (VWS1555) u163 DV-363-S http://www.xiaoyu163.com...
Page 21
: TRACKING SERVO LOOP LINE : STEPPING SERVO LOOP LINE FLKY ASSY PWSB ASSY (VWG2418) (VWG2424) PICKUP ASSY-S (OXX8005) L 13942296513 SPINDLE STEPPING MOTOR MOTOR : VXM1101 : VXM1099 LOADING MOTOR ASSY : VXX2872 u163 LOAB ASSY (VWG2426) DV-363-S http://www.xiaoyu163.com...
Page 25
: V SIGNAL ROUTE : S-VIDEO OUT C SIGNAL ROUTE B/Cb : S-VIDEO OUT Y SIGNAL ROUTE : R/Cr SIGNAL ROUTE R/Cr u163 : G/Y SIGNAL ROUTE : B/Cb SIGNAL ROUTE B/Cb : AUDIO SIGNAL ROUTE : AUDIO(DIGITAL) SIGNAL ROUTE DV-363-S http://www.xiaoyu163.com...
Page 27
: V SIGNAL ROUTE : S-VIDEO OUT C SIGNAL ROUTE : S-VIDEO OUT Y SIGNAL ROUTE : R/Cr SIGNAL ROUTE R/Cr : G/Y SIGNAL ROUTE : B/Cb SIGNAL ROUTE u163 B/Cb : AUDIO SIGNAL ROUTE : AUDIO(DIGITAL) SIGNAL ROUTE DV-363-S http://www.xiaoyu163.com...
CONTAINS LEAD IN SOLDER AND CERTAIN ELECTRICAL PARTS WARNING CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. u163 IC101 IC301 IC400 IC404 IC603 IC604 IC403 IC601 IC602 Q403 Q390 Q211 Q201 Q202 Q405 Q402 Q603 Q212 Q404 Q401 DV-363-S http://www.xiaoyu163.com...
SIDE A FLKY ASSY (VNP1901-B) CN102 D102 D101 PYKC F4X S102 FL DIM D104 S104 >> S103 FL101 << PWSB ASSY (VNP1901-B) L 13942296513 SIDE B PWSB ASSY (VNP1901-B) C154 R138 PWSB VWG2424- CN103 VWG2425- FLKY ASSY (VNP1901-B) u163 DV-363-S http://www.xiaoyu163.com...
Page 39
S108 EJECT IR101 /STOP VNP1901- /PLAY S110 S117 S118 S119 DC FC PLAY/>> PAUSE/<< DOWN RETURN S107 S106 C101 HOME MENU/PAUSE STOP/EJECT CN101 CN104 S105 CN101 CN105 L 13942296513 SIDE B CN101 C N 1 0 1 u163 DV-363-S http://www.xiaoyu163.com...
4.4 POWER SUPPLY UNIT [VWR1365] 3 7 63 1515 0 SIDE A SIDE B POWER SUPPLY UNIT AC IN [VWR1365] L 13942296513 P301 P101 u163 DV-363-S http://www.xiaoyu163.com...
Electrical adjustments are not required. L 13942296513 6.2 JIGS AND MEASURING INSTRUMENTS Test mode remote control Screwdriver (large) Screwdriver (medium) TV monitor unit (GGF1067) Screw tight (GYL1001) u163 DVD test disc Precise screwdriver Soldering iron (GGV1025) DV-363-S http://www.xiaoyu163.com...
Purpose: To set the sweep which was correct with the individual Traverse mechanism. Be sure to perform the following step finally when replaced Pickup, Traverse Mechanism and Spindle Motor. CLEAR GGF1067 Test mode remote control unit (It is necessary when performed adjustment procedure Ÿ.) u163 DV-363-S http://www.xiaoyu163.com...
< When playback with the target address of disc (DVD)> For example, when playback with # 30000 During PLAY CHP/TIM Press keys in order 030000 TEST MODE: OFF POWER u163 GGF1067 Test mode remote control unit DV-363-S http://www.xiaoyu163.com...
(Refer to "6.1 ADJUSTMENT ITEMS AND LOCATION".) Spacer for Height adjustment Note: Turn a flat side into bottom Before removing the flexible cable for the pickup, soldering of the pickup circuit is necessary. For details, see "7.1.9 DISASSEMBLY". L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 48
If error rate is OK, Disc playback normally. locks a root of • The measurement of block error rate tangential and radial adjustment screws with the Screw tight, and go to step Screw tight: GYL1001 Test mode end u163 DV-363-S http://www.xiaoyu163.com...
Page 49
3 7 63 1515 0 Purpose: To set the sweep which was correct with the individual Traverse mechanism. Turn on the Player POWER CLEAR Note: Be sure to perform this step when replaced the Pickup or Traverse mechanism. L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Perform only trace, video and audio outputs are nothing. = Screen display ON/OFF 1. Turn off the display by pressing the [AUDIO] (A8-1E) key of the remote control unit. 2. Turn on the display by pressing the [DISPLAY] (A8-43) key of the remote control unit. u163 DV-363-S http://www.xiaoyu163.com...
Page 51
• After the search, perform only trace and video and audio outputs are nothing. 4. Release the Search address input • Clear the address by pressing the [CLEAR] (A8-45) key. Release the address input mode when pressing the [CLEAR] key once again. L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Kinds of version / firmware of the FE. Scart terminal output [SK – ∗ ∗] RAM or ROM (Display only the WY model which can do the output setting of scart terminal.) VIDEO : [00] u163 S-VIDEO : [01] : [02] DV-363-S http://www.xiaoyu163.com...
After you press the AUDIO key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. DV-363-S http://www.xiaoyu163.com...
(version of ST core software) softwareVersion . softwareRevision / buildNumber 0 F.E VERSION Version of FRONT END (version of mechanism controller CHIP software) MainVersion / Kinds of firmware RAM or ROM - Remote control code = Key code of Main unit u163 DV-363-S http://www.xiaoyu163.com...
PLL lost timeout 0x93 DECODER ERROR 0xa∗ DECODER TIMEOUT 0xb∗ Note : 0 x & & ID lost error 0xa3 ID lost timeout 0xb3 DEVICE ERROR 0xd∗ u163 code SRAM error 0xd1 (Only this part is displayed to a display) DV-363-S http://www.xiaoyu163.com...
Page 57
1. Stepping motor of the stepping in the test mode? 2. Inside switch Stepping move timeout 0 x 54 Did timeout at stepping movement Do indicate "S-04" at the most inner 3. Driver periphery of the stepping? u163 DV-363-S http://www.xiaoyu163.com...
Page 58
0 x d1 Cannot access SRAM 2. Front End IC Is not bus line short-circuiting? 3. Front End-SRAM bus line FAILSAFE (0 x e∗) 1. software runaway Unexpected error 0 x e1 Unexpected error 3. Software bug u163 DV-363-S http://www.xiaoyu163.com...
(The SEARCH key is not accepted after all 9 digits have been entered.) Input ID Number ! [Player's ID Number Setting] ID Number ? > 0 0 0 0 0 0 0 0 1 OK ? <PLAY> Compare Mode <SEARCH> Enter Input ID Number ! u163 DV-363-S http://www.xiaoyu163.com...
Page 60
[Player's ID Number Setting] ID Number ? [ 0 0 0 0 0 0 0 0 1 ] Compare > 0 0 0 0 0 0 0 0 1 OK? <PLAY> Enter <STOP> Memory Clear Input ID Number ! u163 DV-363-S http://www.xiaoyu163.com...
Page 61
If no ID data are set after the ID number is changed, the message "NO ID DATA" flashes on the screen and FL display for a few seconds after the power is turned on or during Stop mode. u163 DV-363-S http://www.xiaoyu163.com...
Gear in the Loading Mecha. Assy in the direction of the arrow, as indicated in the photo. If the Tray pops out a little, fully pull it out by hand. Screwdriver (small) Projection Slit Drive Gear Loading Mecha.Assy Tray open u163 Screwdriver (small) DV-363-S http://www.xiaoyu163.com...
Page 64
Remove the front panel section. ×2 DVDM Assy 1 1 1 Remove the four screws. Remove the three screws. ×3 L 13942296513 DVDM Assy DVDM Assy Remove the DVDM Assy and stand it against the other parts. u163 DV-363-S http://www.xiaoyu163.com...
Page 65
Tray Drive Cam Note when reinserting the Tray When reinserting the Tray, first align the triangle printed on the Loading Base and the pin of the Drive Cam, then insert the Tray. Front Side Loading Base Triangle u163 DV-363-S http://www.xiaoyu163.com...
Page 66
Front Side placement. Flexible cable Flexible cable for the pickup for the stepping motor L 13942296513 Bottom View Remove the four hooks. Traverse Mecha. Assy-S × 2 Remove the Traverse Mecha. Assy-S. × 2 u163 DV-363-S http://www.xiaoyu163.com...
Page 67
Flexible cable for the pickup Bottom View L 13942296513 Adjustment screw Adjustment screw Remove the two adjustment screws and two adjustment springs. (Skew screw) (Skew screw) Remove the Pickup Assy-S. Pickup Assy-S Adjustment spring (Skew spring) Adjustment spring (Skew spring) u163 DV-363-S http://www.xiaoyu163.com...
Page 68
Joint 03 Silicone Adhesive GEM1037 Arrangement of the flexible cable Arrangement of the flexible cable for the spindle motor for the stepping motor L 13942296513 : Conductive surface : Conductive surface Hook Hook u163 Bottom View Bottom View DV-363-S http://www.xiaoyu163.com...
Page 69
Hook Fold the flexible cable as indicated in the photo. Fold the flexible cable along the hook. Hook the part folded in Step 1 to the hook. Reference Hook Pass the cable below the hook line Hook u163 DV-363-S http://www.xiaoyu163.com...
Page 70
• The information shown in the list is basic information and may not correspond exactly to that shown in the schematic diagrams. • List of IC STM6316ATXXA, STM5589CVA, M63108FP, PE5374A 7 STM6316ATXXA (DVDM ASSY : IC301) • FRONT END IC ¶ Block Diagram L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 71
3 7 63 1515 0 ¶ Pin Function t i c t i c t s i L 13942296513 t s i t s i t s i t s i t i s t i s u163 DV-363-S http://www.xiaoyu163.com...
Page 72
- t l l i c y t i - t l l i c y t i - t l l i c y t i d l l u163 DV-363-S http://www.xiaoyu163.com...
Page 73
3 7 63 1515 0 l l i l l i t i c l i b y t i L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 74
7 STM5589CVA (DVDM ASSY : IC601) 3 7 63 1515 0 • BACK END IC ¶ Pin Function . r i & l a i L 13942296513 l a i . t i . t i u163 DV-363-S http://www.xiaoyu163.com...
Page 75
3 7 63 1515 0 . r i t i s t i s t i s t i s t i s t i s t i s t i s t s i t s i L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 76
: ' L DV-363-S http://www.xiaoyu163.com...
Page 77
3 7 63 1515 0 . r i r i f ' L ' ' L ' ' L ' t i r ' L ' ' L ' L 13942296513 ' L ' ' L ' u163 DV-363-S http://www.xiaoyu163.com...
Page 78
3 7 63 1515 0 . r i L 13942296513 ' L ' l a i l a i u163 DV-363-S http://www.xiaoyu163.com...
Page 79
3 7 63 1515 0 . r i L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 81
3 7 63 1515 0 ¶ Pin Function L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Page 82
Destination (of player) Select (Set with a combinaition of this 3 ports) MS1_0 H" : No System Reset mode , "L" : General m H" : OEM Model , "L" : Pioneer Mo MIC IN Detection of Microphone "H" : Microphone connected CHECKER H"...
See below for notes about particular u163 software and formats. • Check the DVD-R/RW or CD-R/RW soft- ware disc boxes for additional compati- bility information. DV-363-S http://www.xiaoyu163.com...
3 7 63 1515 0 Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...
Press to display a DVD disc menu, or the Disc DVD-RW discs recorded on a DVD recorder in Navigator if a VR format DVD-RW, CD, Video Video Recording mode. CD , MP3, WMA or JPEG disc is loaded. u163 DV-363-S http://www.xiaoyu163.com...
Page 87
DIGITAL AUDIO OUT – OPTICAL This is a digital audio output for connection to a PCM, Dolby Digital, DTS and/or MPEG- compatible AV receiver that has an optical digital input. Connect using a commercially available optical digital audio cable. u163 DV-363-S http://www.xiaoyu163.com...
Page 88
CD or Video CD track number. Lights during multi-angle scenes on a DVD disc. 12 DTS Lights when a DTS soundtrack is playing. PRGSVE Lights when the player is set to output progressive scan video. u163 DV-363-S http://www.xiaoyu163.com...
Page 89
Press to pause playback; press again to restart. 12 PLAY MODE Press to display the Play Mode menu. (You can also get to the Play Mode menu by pressing HOME MENU and selecting Play Mode). u163 DV-363-S http://www.xiaoyu163.com...
Page 90
18 MENU Press to change the zoom level. Press to display a DVD disc menu, or the Disc Navigator if a VR format DVD-RW, CD, Video CD , MP3, WMA or JPEG disc is loaded. L 13942296513 u163 DV-363-S http://www.xiaoyu163.com...