Page 2 RM-132; RM-133 Nokia Customer Care Amendment Record Sheet Amendment Record Sheet Amendment No Date Inserted By Comments Issue 1 06/2006 M. Hautaniemi Page ii COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 3 Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.
Page 4: Warnings And Cautions
WCDMA networks and cause problems to 3G cellular phone communication in a wide area. • During testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM or WCDMA PA may be damaged. Page iv COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 5 Nokia Customer Care ESD protection Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
Page 7 Our policy is of continuous development; details of all technical modifications will be included with service bulletins. While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e- mail. Please state: •...
Page 8: Battery Information
Batteries' performance is particularly limited in temperatures well below freezing. Do not dispose of batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. Page viii COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 9 4 Service Tools and Service Concepts 5 Disassembly/reassembly instructions 6 BB Troubleshooting and Manual Tuning Guide 7 RF Troubleshooting and Manual Tuning Guide 8 Camera Module Troubleshooting 9 System Module 10 Schematics Issue 1 COMPANY CONFIDENTIAL Page ix Copyright © 2006 Nokia. All rights reserved.
Page 13: Table Of Contents
Table 4 Data................................1–8 Table 5 Deskstands..............................1–9 Table 6 Imaging..............................1–9 Table 7 Messaging..............................1–9 Table 8 Positioning..............................1–9 Table 9 Power.................................1–9 List of Figures Figure 1 View of RM-133/RM-132..........................1–5 Issue 1 COMPANY CONFIDENTIAL Page 1 –3 Copyright © 2006 Nokia. All rights reserved.
Page 15: Rm-133/Rm-132 Product Selection
RM-133/RM-132 product selection The Nokia RM-133 is a GSM/WCDMA dual mode handportable phone supporting EGSM 850/900/1800/1900 and WCDMA 2100 (UMTS). The RM-132 variant does not support WCDMA radio interface and related services. Note: All subsequent references to WCDMA or related services concern RM-133 only.
Page 16: Memory Functions
*The availability of a memory card and memory capacity of the card in the sales package may vary depending on the market and/or your network operator/service provider. Connectivity • Bluetooth wireless technology Page 1 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 17: Sales Package
Bluetooth headset BH-800 HS-24W Bluetooth Headset BH-900 HS-25W Wireless Headset HS-26W Wireless Headset HS-11W Wireless Clip-on Headset HS-21W Wireless Headset HS-36W Wireless Headset HS-37W Wireless Headset HS-53W Issue 1 COMPANY CONFIDENTIAL Page 1 –7 Copyright © 2006 Nokia. All rights reserved.
Page 18: Table 1 Audio
Multicompatible carrying case CP-93 Inbox strap CP-134 Lens cloth CL-3 Table 4 Data Enhancement Type Mini SD card 128 MB MU-17 Mini SD card 256 MB MU-18 Page 1 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 19: Table 5 Deskstands
Wireless GPS Module LD-1W Wireless GPS Module update LD-3W Table 9 Power Enhancement Type Battery 1100 mAh Li-ion BP-6M Compact charger AC-3 Travel charger AC-4 Charging adapter CA-44 Issue 1 COMPANY CONFIDENTIAL Page 1 –9 Copyright © 2006 Nokia. All rights reserved.
Page 20: Technical Specifications
Number of RF channels GSM850: 124 GSM900: 174 GSM1800: 374 GSM1900: 299 Channel spacing 200 kHz Number of Tx power levels GSM850: 15 GSM900: 15 GSM1800: 16 GSM1900: 16 Page 1 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 21: Battery Endurance
No operation or storage No storage or operation: an <-40 C...>+85 attempt may damage the phone. Charging allowed C...+50 Long term storage conditions C...+85 Issue 1 COMPANY CONFIDENTIAL Page 1 –11 Copyright © 2006 Nokia. All rights reserved.
Page 25: Table Of Contents
Table 11 RM-132 component part list (1TR_11)....................2–26 List of Figures Figure 2 RM-133 component layout - bottom (1SU_11)...................2–45 Figure 3 RM-133 component layout - top (1SU_11)..................2–46 Figure 4 RM-132 component layout - bottom (1TR_11)...................2–47 Figure 5 RM-132 component layout - top (1TR_11)..................2–48 Issue 1 COMPANY CONFIDENTIAL Page 2 –3...
Page 27: Rm-132/133 Exploded View
RM-132; RM-133 Parts Lists and Component Layouts Nokia Customer Care RM-132/133 exploded view Issue 1 COMPANY CONFIDENTIAL Page 2 –5 Copyright © 2006 Nokia. All rights reserved.
Page 28: Mechanical Spare Parts List
• I3xx = ITEM codes for soldered spare parts in the upper hinge or lower block and not exchangeable Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.
Page 29: Component Parts Lists And Layouts
Table 10 RM-133 component part list (1SU_11) Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.
Page 30: Rm-132;
0402C 0402 CHIP ARRAY X5R 2X1U K C2220 0405_GNM23 6V3 MA 0405 2x1u 6.3V CHIP ARRAY X5R 2X1U K C2222 0405_GNM23 6V3 MA 0405 2x1u 6.3V Page 2 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 31 CHIP ARRAY X5R 2X1U K C3503 0405_GNM23 6V3 MA 0405 2x1u 6.3V CHIPCAP X5R 10U M 6V3 C4201 0805C_H0.95 T=0.95mm 0805 C4401 0402C Chipcap 5% NP0 Issue 1 COMPANY CONFIDENTIAL Page 2 –9 Copyright © 2006 Nokia. All rights reserved.
Page 32 0402C 0402 C6039 0402C Chipcap 5% NP0 C6051 0402C Chipcap +-0.25pF NP0 C6052 0402C Chipcap +-0.25pF NP0 CHIPCAP X5R 4U7 K 6V3 C6055 0603C 0603 6.3V Page 2 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 33 CHIPCAP X5R 1U5 K 4V C6590 0402C 0402 CHIP ARRAY X5R 2X1U K C6592 0405_GNM23 6V3 MA 0405 2x1u 6.3V CHIPCAP X5R 10U M 6V3 C6593 0805C_H0.95 T=0.95mm 0805 Issue 1 COMPANY CONFIDENTIAL Page 2 –11 Copyright © 2006 Nokia. All rights reserved.
Page 34 CHIPCAP X5R 4U7 K 6V3 C7518 0603C 0603 6.3V C7519 0402C Chipcap 5% NP0 Chipcap X7R 10% 50V C7520 0402C 0402 Chipcap X7R 10% 50V C7521 0402C 0402 Page 2 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 35 6V3 MA 0405 2x1u 6.3V CHIPCAP X5R 22U M 6V3 C7549 0805C 0805 CHIPCAP X5R 22U M 6V3 C7550 0805C 0805 Chipcap X7R 10% 16V C7551 0402C 0402 Issue 1 COMPANY CONFIDENTIAL Page 2 –13 Copyright © 2006 Nokia. All rights reserved.
Page 36 Chipcap 5% NP0 C9077 0402C Chipcap 5% NP0 C9078 0402C Chipcap 5% NP0 C9079 0402C Chipcap 5% NP0 CHIPCAP X5R 1U5 K 4V C9080 0402C 0402 Page 2 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 37 SPACER PAD SM CONN ANTENNA J7590 SMK_T_314849D SPACER PAD FERR.BEAD 220R/100M 220R/ L2000 0603_BLM 2A 0R05 0603 100MHz FERRITE BEAD 0.6R 600R/ L2002 FERRITE_0402 600R/100MHZ 0402 100MHz Issue 1 COMPANY CONFIDENTIAL Page 2 –15 Copyright © 2006 Nokia. All rights reserved.
Page 38 CHIP COIL 33N J L6518 0402L Q23/800M 0402 33nH CHIP COIL 33N J L6519 0402L Q23/800M 0402 33nH CHIP COIL 33N J L6520 0402L Q23/800M 0402 33nH Page 2 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 39 CHIP COIL 4N7 +-0N1 L7599 0402L_H0.45 Q29/1GHZ 0402 4n7H CHIP COIL 8N2 J L7601 0402L Q28/800MHZ 0402 8n2H CHIP COIL 18N J L7603 0402L Q29/800M 0402 18nH Issue 1 COMPANY CONFIDENTIAL Page 2 –17 Copyright © 2006 Nokia. All rights reserved.
Page 40 PBGA-N20 *FOR NRC USE N3501 PBGA_N20_P0.5 ONLY* HELEN3 PS2.0 N3 N4800 uBGA_289 F761909 C27 UBGA289 CSP_47_3.85X4.0 N6030 BC4-ROM1.0RDL WFBGA34_2_3.57 FM RECEIVER N6100 X3.57 TEA5761UK N4B CSP (TI) Page 2 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 41 4_H0.675 NOPB USMD5 WHITE LED DRIVER USMD8_1.69X1.6 4LEDS 500MW 8BUMP N9002 USMD8 uBGA_6_1.45X0.9 TI ANALOG SWITCH N9003 TS5A3159YZTR WCSP06 uBGA_6_1.45X0.9 TI ANALOG SWITCH N9004 TS5A3159YZTR WCSP06 Issue 1 COMPANY CONFIDENTIAL Page 2 –19 Copyright © 2006 Nokia. All rights reserved.
Page 42 CHIPRES 0W06 2R2 J R6032 0402R 0402 R6034 0402R Resistor 5% 63mW R6037 0402R Resistor 5% 63mW 100k R6100 0402R Resistor 5% 63mW R6101 0402R Resistor 5% 63mW 100k Page 2 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 43 CHIPRES 0W06 1K0 F R7517 0402R 200PPM 0402 R7518 0402R Resistor 5% 63mW CHIPRES 0W06 1K2 F R7520 0402R 250PPM 0402 Chipres 0W06 jumper R7521 0402R 0402 Issue 1 COMPANY CONFIDENTIAL Page 2 –21 Copyright © 2006 Nokia. All rights reserved.
Page 44 VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7722 0402_VAR VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7723 0402_VAR VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7724 0402_VAR VWM14V VC50V 0402 14V/50V Page 2 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 45 R9123 0402R 0402 Chipres 0W06 jumper R9125 0402R 0402 R9127 0402R Resistor 5% 63mW R9128 0402R Resistor 5% 63mW 100k R9129 0402R Resistor 5% 63mW 100k Issue 1 COMPANY CONFIDENTIAL Page 2 –23 Copyright © 2006 Nokia. All rights reserved.
Page 46 V6514 VMT3 0A1 0W15 VMT3 V6515 SOD323F SCH DI 30V 2A SOD323F LED BLUE 26MCD 5MA V6516 LED_CL_270 0603 LED BLUE 26MCD 5MA V6518 LED_CL_270 0603 Page 2 –24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 47 SPRING_WN9149 C-SPRING ANTENNA X6526 _N10 active SPRING_WN9149 C-SPRING ANTENNA X6527 _N10 active SM CONN ANTENNA X6530 SMK_T_314849D SPACER PAD SM CONN ANTENNA X6531 SMK_T_314849D SPACER PAD Issue 1 COMPANY CONFIDENTIAL Page 2 –25 Copyright © 2006 Nokia. All rights reserved.
Page 48: Shield
Table 11 RM-132 component part list (1TR_11) Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.
Page 49 6.3V CHIPCAP X5R 4U7 M 25V C2314 0805C 0805 CHIPCAP X5R 4U7 K 6V3 C2316 0603C 0603 6.3V CHIPCAP X5R 1U5 K 4V C2317 0402C 0402 Issue 1 COMPANY CONFIDENTIAL Page 2 –27 Copyright © 2006 Nokia. All rights reserved.
Page 50 CHIPCAP X5R 1U5 K 4V C4801 0402C 0402 CHIPCAP X5R 100N M C4803 0402C_H0.6 16V 0402 100n CHIPCAP X5R 100N M C4808 0402C_H0.6 16V 0402 100n Page 2 –28 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 51 0402 CHIPCAP X7R 33N K 10V C6108 0402C 0402 C6109 0402C Chipcap 5% NP0 C6110 0402C Chipcap 5% NP0 Chipcap X7R 10% 16V C6112 0402C 0402 Issue 1 COMPANY CONFIDENTIAL Page 2 –29 Copyright © 2006 Nokia. All rights reserved.
Page 52 6.3V C7504 0402C Chipcap +-0.25pF NP0 CHIPCAP X7R 33N K 10V C7505 0402C 0402 C7507 0402C Chipcap +-0.25pF NP0 Chipcap X7R 10% 16V C7508 0402C 0402 Page 2 –30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 53 Chipcap 5% NP0 CHIPCAP X5R 1U K 6V3 C7539 0603C 0603 6.3V CHIPCAP X5R 4U7 K 6V3 C7540 0603C 0603 6.3V Chipcap X7R 10% 16V C7542 0402C 0402 Issue 1 COMPANY CONFIDENTIAL Page 2 –31 Copyright © 2006 Nokia. All rights reserved.
Page 54 Chipcap X7R 10% 50V C7592 0402C 0402 CHIPCAP X5R 4U7 K 6V3 C9059 0603C 0603 6.3V Chipcap X7R 10% 50V C9060 0402C 0402 C9070 0402C Chipcap 5% NP0 Page 2 –32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 55 GATE WCSP06 0603_FUSE_AVX2 F2000 MATS SM FUSE F 2.0A 32V RTC BACUP CAPAC 311 G1000 BATTER_EECEP SIZE FOR 2.6V 4UAH 2.6V VCTCXO 38.4MHZ 2.5V G7500 NKG3176B_H1.0 38.4MHz Issue 1 COMPANY CONFIDENTIAL Page 2 –33 Copyright © 2006 Nokia. All rights reserved.
Page 56 INDUCT WW 2.2UH 1A2 L6500 CHOKE_SER300 310 CASE SIZE 2u2H CHOKE_SER300_H CHOKE 3U3 1.2A 0R096 L6501 3X3X1.5 3u3H INDUCT WW 2.2UH 1A2 L6502 CHOKE_SER300 310 CASE SIZE 2u2H Page 2 –34 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 57 CHIP COIL 68N J L7548 0402L_XL Q17/300M 0402 68nH CHIP COIL 68N J L7549 0402L_XL Q17/300M 0402 68nH CHIP BEAD ARRAY 2x600R/ L7551 0405_2_DLM11G 2X600R 0405 100MHz Issue 1 COMPANY CONFIDENTIAL Page 2 –35 Copyright © 2006 Nokia. All rights reserved.
Page 58 MODULE TFBGA105 N2300 TFBGA64_H1.2 BETTY V2.1 LF TFBGA64 USMD5_1.47X1.0 VREG LP3985ITLX-3.0 N3500 4_H0.675 NOPB USMD5 LEVEL SHIFT SN74AVCA406LZXYR S- PBGA-N20 *FOR NRC USE N3501 PBGA_N20_P0.5 ONLY* Page 2 –36 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 59 N7520 RF9282E3.6 850/900/1800/1900 USMD5_1.47X1.0 VREG LP3985ITLX-2.8 N7542 4_H0.675 NOPB USMD5 WHITE LED DRIVER USMD8_1.69X1.6 4LEDS 500MW 8BUMP N9002 USMD8 TI ANALOG SWITCH uBGA_6_1.45X0.9 TS5A3159AYZTR N9003 WCSP06 Issue 1 COMPANY CONFIDENTIAL Page 2 –37 Copyright © 2006 Nokia. All rights reserved.
Page 60 Resistor 5% 63mW R6031 0402R Resistor 5% 63mW CHIPRES 0W06 2R2 J R6032 0402R 0402 R6034 0402R Resistor 5% 63mW R6037 0402R Resistor 5% 63mW 100k Page 2 –38 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 61 CHIPRES 0W06 8K2 F R7516 0402R 0402 CHIPRES 0W06 1K0 F R7517 0402R 200PPM 0402 R7541 0402R Resistor 5% 63mW CHIP VARISTOR R7634 0402_VAR VWM14V VC50V 0402 14V/50V Issue 1 COMPANY CONFIDENTIAL Page 2 –39 Copyright © 2006 Nokia. All rights reserved.
Page 62 VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7723 0402_VAR VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7724 0402_VAR VWM14V VC50V 0402 14V/50V CHIP VARISTOR R7725 0402_VAR VWM14V VC50V 0402 14V/50V Page 2 –40 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 63 Resistor 5% 63mW R9128 0402R Resistor 5% 63mW 100k R9129 0402R Resistor 5% 63mW 100k R9130 0402R Resistor 5% 63mW 100k R9131 0402R Resistor 5% 63mW 100k Issue 1 COMPANY CONFIDENTIAL Page 2 –41 Copyright © 2006 Nokia. All rights reserved.
Page 64 LED BLUE 26MCD 5MA V6516 LED_CL_270 0603 LED BLUE 26MCD 5MA V6518 LED_CL_270 0603 TRX2 EMX1/PEMX1 P V6519 SOT_666 40V 0A1 SOT666 LED BLUE 26MCD 5MA V6520 LED_CL_270 0603 Page 2 –42 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 65 SMK_T_314849D SPACER PAD SM CONN ANTENNA X6531 SMK_T_314849D SPACER PAD uBGA25_2.47X2. ASIP 10-CH ESD EMI Z4400 FILTER BGA25 LTCC FILT 2441.75 2441.75M Z6030 EZFVQ42NM61S +-41.75MHZ 2.5X2 Issue 1 COMPANY CONFIDENTIAL Page 2 –43 Copyright © 2006 Nokia. All rights reserved.
Page 66 Description and value MODULE_SP_LMZ_ TX SAW MODULE GSM 850/900 Z7500 850/900MHZ 880-960/ RF SWITCH SP3T 1710-199 Z7541 CQF12_N2 850/1800/1900MHZ 0MHz FLIP_CHIP_16_2.0 MMC ASP HIGH SPEED Z7542 1X2.02_H0.715 BGA16 Page 2 –44 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 67: Rm-133 Component Layouts
RM-132; RM-133 Parts Lists and Component Layouts Nokia Customer Care Component layouts RM-133 component layouts Figure 2 RM-133 component layout - bottom (1SU_11) Issue 1 COMPANY CONFIDENTIAL Page 2 –45 Copyright © 2006 Nokia. All rights reserved.
Page 68: Figure 3 Rm-133 Component Layout - Top (1Su_11)
RM-132; RM-133 Nokia Customer Care Parts Lists and Component Layouts Figure 3 RM-133 component layout - top (1SU_11) Page 2 –46 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 69: Figure 4 Rm-132 Component Layout - Bottom (1Tr_11)
RM-132; RM-133 Parts Lists and Component Layouts Nokia Customer Care RM-132 component layouts Figure 4 RM-132 component layout - bottom (1TR_11) Issue 1 COMPANY CONFIDENTIAL Page 2 –47 Copyright © 2006 Nokia. All rights reserved.
Page 70: Figure 5 Rm-132 Component Layout - Top (1Tr_11)
RM-132; RM-133 Nokia Customer Care Parts Lists and Component Layouts Figure 5 RM-132 component layout - top (1TR_11) Page 2 –48 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 72 RM-132; RM-133 Nokia Customer Care Phoenix Service Software Instructions (This page left intentionally blank.) Page 3 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 73 Figure 27 Finish flash update..........................3–22 Figure 28 Flash directory window........................3–22 Figure 29 Prommer software update finished....................3–23 Figure 30 Prommer Maintenance window......................3–23 Figure 31 Box activation............................3–24 Figure 32 Deactivation warning.........................3–24 Issue 1 COMPANY CONFIDENTIAL Page 3 –3 Copyright © 2006 Nokia. All rights reserved.
Page 74 RM-132; RM-133 Nokia Customer Care Phoenix Service Software Instructions (This page left intentionally blank.) Page 3 –4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 75: Phoenix Installation Steps In Brief
• Activate SX-4 smart card, if you need tuning and testing functions. Note: When FPS-10 is used only for product software updates, SX-4 smart card is not needed. Issue 1 COMPANY CONFIDENTIAL Page 3 –5 Copyright © 2006 Nokia. All rights reserved.
Page 76: Installing Phoenix
Press the F1 key or the feature’s Help button to activate a Help file. Steps phoenix_service_sw_2004_39_x_xx.exe ). 1. To start the installation, run the application file (for example, Welcome dialogue, click Next. 2. In the Page 3 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 77 Select Yes... to reboot the PC immediately or No... to reboot the PC manually afterwards. After the reboot, all components are registered. Phoenix does not work, if the components have not been registered. Note: Issue 1 COMPANY CONFIDENTIAL Page 3 –7 Copyright © 2006 Nokia. All rights reserved.
Page 78: Updating Phoenix Installation
Windows Control Panel. the application from the • If you try to install an older version (for example, downgrade from a15_2004_24_7_55 to a14_2004_16_4_47), installation will be interrupted. Page 3 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 79: Uninstalling Phoenix
Phoenix Uninstalling Context Phoenix service software manually from the Windows Control Panel. You can uninstall Steps 1. Open the Windows Control Panel, and choose Add/Remove Programs. Issue 1 COMPANY CONFIDENTIAL Page 3 –9 Copyright © 2006 Nokia. All rights reserved.
Page 80 Figure 10 Remove program The progress of the uninstallation is shown. 3. If the operating system does not require rebooting, click Finish to complete. Figure 11 Finish uninstallation Page 3 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 81: Repairing Phoenix Installation
Phoenix service software and tools usable with a certain phone model. The phone data package contains the following: • Product software binary files Issue 1 COMPANY CONFIDENTIAL Page 3 –11 Copyright © 2006 Nokia. All rights reserved.
Page 82: Installing Phone Data Package
• Files for type label printing • Validation file for the fault log repair data reporting system • All product-specific configuration files for Phoenix software components Data files are stored in C:\Program Files\Nokia\Phoenix (default). Installing phone data package Prerequisites Phoenix service software and service tools •...
Page 83 3. In the following view you can see the contents of the data package. Read the text carefully. There is Phoenix version required with this data package. information about the Figure 13 Data package setup information 4. To continue, click Next. Issue 1 COMPANY CONFIDENTIAL Page 3 –13 Copyright © 2006 Nokia. All rights reserved.
Page 84 Figure 14 Data package destination folder Phoenix is installed, and the directory is shown. The InstallShield Wizard checks where 6. To start copying the files, click Next. Page 3 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 85: Uninstalling Phone Data Package
Steps XX-XX_dp_EA_v_1_0.exe ) from your computer. 1. Locate the data package installation file (e.g. 2. To start the uninstallation procedure, double-click the data package installation file. Issue 1 COMPANY CONFIDENTIAL Page 3 –15 Copyright © 2006 Nokia. All rights reserved.
Page 86 Figure 17 Finishing data package uninstallation Alternative steps • You can also uninstall the data package manually from Control Panel→Add/Remove Programs→xx-xx* Phone Data Package . (*= type designator of the phone). Page 3 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 87: Configuring Users In Phoenix
Windows Control Panel. If the problem persists, contact the local PC support. Steps Phoenix , and log in. 1. Start 2. Choose File→Manage Connections..Issue 1 COMPANY CONFIDENTIAL Page 3 –17 Copyright © 2006 Nokia. All rights reserved.
Page 88 For a plain USB connection, choose the following connection settings: Note: First connect the DKU-2 USB cable between the PC USB port and phone. • Media: USB 5. To complete the configuration, click Finish. Page 3 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 89: Installing Flash Support Files For Fps-8 And Fps-10
If you are not using a separate installation package, you can skip this section and continue with "Updating FPS-8 and FPS-10 flash prommer software" (page 3–22) after installing a new phone data package. Issue 1 COMPANY CONFIDENTIAL Page 3 –19 Copyright © 2006 Nokia. All rights reserved.
Page 90 Figure 25 Flash installation interrupted If an older version exists on your PC and it needs to be updated, click Next to continue installation. Page 3 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 91 To continue, click Next. Figure 26 Flash destination folder When installing the flash update files for the first time, you may choose another location by selecting Browse (not recommended). Issue 1 COMPANY CONFIDENTIAL Page 3 –21 Copyright © 2006 Nokia. All rights reserved.
Page 92: Updating Fps-8 And Fps-10 Flash Prommer Software
2. Choose the correct connection for your flash prommer: File→Manage Connections... 3. Choose Flashing→Prommer maintenance . fps8upd.ini (for FPS-8) 4. To update the FPS-8/FPS-10 software, click Update, and select the appropriate file fpsxupd.ini (for FPS-10) from C:\Program Files\Nokia\Phoenix\Flash . Figure 28 Flash directory window Page 3 –22 COMPANY CONFIDENTIAL Issue 1 Copyright ©...
Page 93: Activating Fps-8
FPS-8 activation request sheet in the FPS-8 sales package, and follow the instructions given. First fill in the 00000.in ), copy it to the C:\ProgramFiles\Nokia\Phoenix When activation file is received (for example, \BoxActivation directory on your computer (this directory is created when Phoenix is installed).
Page 94: Deactivating Fps-8
1. Start 2. Choose Flashing→Prommer Maintenance . Prommer Maintenance window, click Deactivate. 3. In the 4. To confirm the deactivation, click Yes. Figure 32 Deactivation warning Page 3 –24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 95 RM-132; RM-133 Phoenix Service Software Instructions Nokia Customer Care The box is deactivated. 5. To complete the deactivation, restart FPS-8. Issue 1 COMPANY CONFIDENTIAL Page 3 –25 Copyright © 2006 Nokia. All rights reserved.
Page 96 RM-132; RM-133 Nokia Customer Care Phoenix Service Software Instructions (This page left intentionally blank.) Page 3 –26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 99 POS flash concept............................4–17 Flash concept with FPS-10 and LAN.......................4–18 CU-4 flash concept with FPS-10........................4–19 RF testing and BB testing/tuning........................4–20 List of Tables Table 12 Attenuation values..........................4–5 Issue 1 COMPANY CONFIDENTIAL Page 4 –3 Copyright © 2006 Nokia. All rights reserved.
Page 101: New Service Tools
Nokia Customer Care New service tools The table below gives a short overview of service tools that can be used for testing, error analysis and repair of product RM-132; RM-133, refer to various concepts. FS-19 Flash adapter Flash adapter FS-19 is used for phone testing and flashing.
Page 102: Common Service Tools
22.2 Common service tools The table below gives a short overview of service tools that can be used for testing, error analysis and repair of product RM-132; RM-133, refer to various concepts. CA-31D USB cable The CA-31D USB cable is used to connect FPS-10 or FPS-11 to a PC. It is included in the FPS-10 and FPS-11 sales packages.
Page 103 Service Tools and Service Concepts Nokia Customer Care CA-35S Power cable CA-35S is a power cable for connecting, for example, the FPS-10 flash prommer to the Point-Of-Sales (POS) flash adapter. Issue 1 COMPANY CONFIDENTIAL Page 4 –7 Copyright © 2006 Nokia. All rights reserved.
Page 104 4 Connect an FBUS cable (if necessary). 5 Start Phoenix service software. Note: Phoenix enables CU-4 regulators via USB when it is started. Reconnecting the power supply requires a Phoenix restart. Page 4 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 105 • LAN to FBUS/Flashbus and USB conversion • Vusb output switchable by PC command FPS-10 sales package includes: • FPS-10 prommer • Power Supply with 5 country specific cords • USB cable Issue 1 COMPANY CONFIDENTIAL Page 4 –9 Copyright © 2006 Nokia. All rights reserved.
Page 106 Printer or any such device can be connected to the PC through the device if needed. RJ-114 Rework jig RJ-114 is a rework jig used with ST-41. RJ-57 Rework jig RJ-57 is a rework jig used with ST-22. Page 4 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 107 The SB-6 test box is a generic device to perform Bluetooth bit error rate testing and doing cordless FBUS connection via Bluetooth. SPS-2 Soldering paste spreader Issue 1 COMPANY CONFIDENTIAL Page 4 –11 Copyright © 2006 Nokia. All rights reserved.
Page 108 • provides standardised interface towards Control Unit • provides RF connection using galvanic connector or coupler • multiplexing between USB and FBUS media, controlled by VUSB Page 4 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 109 ST-41 Rework stencil ST-41 is a rework stencil used with rework jig RJ-114. ST-44 Rework stencil ST-44 is a rework stencil used with rework jig RJ-57. Issue 1 COMPANY CONFIDENTIAL Page 4 –13 Copyright © 2006 Nokia. All rights reserved.
Page 110 The RF cable is used to connect, for example, a module repair jig to the RF measurement equipment. SMA to N-Connector approximately 610 mm. Attenuation for: • GSM850/900: 0.3+-0.1 dB • GSM1800/1900: 0.5+-0.1 dB • WLAN: 0.6+-0.1dB Page 4 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 111: Fps-10
Standard USB cable Standard USB cable GPIB control cable XRS-6 RF cable PKD-1 SW security device RF shield box Note: Item 12 not shown in the picture. Issue 1 COMPANY CONFIDENTIAL Page 4 –15 Copyright © 2006 Nokia. All rights reserved.
Page 112: Service Concept For Rf/Bb Testing And Tuning
Standard USB cable + smart card reader SX-4 Smart card XRS-6 RF cable GPIB control cable PKD-1 SW security device RF shield box Note: Item 10 not shown in the picture. Page 4 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 113: Pos Flash Concept
Nokia Customer Care POS flash concept Item Type Description RM-133/132 with BP-6MS Transceiver with a battery CA-53 USB connectivity cable FLS-4S POS flash device ACF-8 Charger Issue 1 COMPANY CONFIDENTIAL Page 4 –17 Copyright © 2006 Nokia. All rights reserved.
Page 114: Flash Concept With Fps-10 And Lan
Flash concept with FPS-10 and LAN Item Type Description FS-19 Flash adapter SS-46 Interface adapter CA-35S Power cable XCS-4 Modular cable FPS-10 Flash prommer Standard USB cable PKD-1 SW security device Page 4 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 115: Flash Concept With Fps-10
BB5 products CU-4 Control unit XCS-4 Modular cable PCS-1 Power cable FPS-10 Flash prommer Standard USB cable Standard USB cable PKD-1 SW security device Issue 1 COMPANY CONFIDENTIAL Page 4 –19 Copyright © 2006 Nokia. All rights reserved.
Page 116: Rf Testing And Bb Testing/Tuning
Standard USB cable SX-4 Smart card GBIP control cable XRS-6 RF cable PKD-1 SW security device RF shield box Note: Item 11 not shown in the picture. Page 4 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 118 RM-132; RM-133 Nokia Customer Care Disassembly/reassembly instructions (This page left intentionally blank.) Page 5 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 119 SRT-6........................5–5 Figure 34 Needed tools: a Torque driver, a Torx size 6 plus bit, metal tweezers and the SS-93 opening tool................................5–22 Issue 1 COMPANY CONFIDENTIAL Page 5 –3 Copyright © 2006 Nokia. All rights reserved.
Page 120 RM-132; RM-133 Nokia Customer Care Disassembly/reassembly instructions (This page left intentionally blank.) Page 5 –4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 121: Disassembly Instructions
Figure 33 Needed tools: a Torx Plus size 6 screwdriver, metal tweezers, a DC plug, the SS-93 opening tool, a dental pick and the SRT-6. Steps Cover the window with a protective film. Issue 1 COMPANY CONFIDENTIAL Page 5 –5 Copyright © 2006 Nokia. All rights reserved.
Page 122 Cover the CAMERA WINDOW with a protective film. Place the SS-93 between the KEYMAT and the edge of the A-COVER and unlock the button clip first. Page 5 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 123 Hold the SS-93 in the shown position and unlock the side clip with SRT-6 by pressing it between the A- COVER and the B-COVER. Do the same on the other side. Slide the SRT-6 along the marked edges to unlock the snaps. Issue 1 COMPANY CONFIDENTIAL Page 5 –7 Copyright © 2006 Nokia. All rights reserved.
Page 124 Lift the A-COVER a bit and unlock its top side from the BCOVER with the SS-93. 10. Remember to protect the inner side of the window with a protective film. Page 5 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 125 11. Unlock and remove the KEYMAT. 12. Carefully unlock and remove the DISPLAY SHIELD by using the dental tool. 13. Cover the DISPLAY with a protective film. Issue 1 COMPANY CONFIDENTIAL Page 5 –9 Copyright © 2006 Nokia. All rights reserved.
Page 126 14. Gently lift out the DISPLAY with the SS-93 from the UI FRAME… 15. …and disconnect it from the ENGINE MODULE. 16. Open the FRONT CAMERA connector. Page 5 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 127 18. The CAMERA BOOT can now be separated from the FRONT CAMERA. 19. Carefully open the UI MODULE connector taking special care to the surrounding components. Issue 1 COMPANY CONFIDENTIAL Page 5 –11 Copyright © 2006 Nokia. All rights reserved.
Page 128 20. Undo the screws in the order shown. 21. Remove the screws and discard them. 22. The UI FRAME is attached with two snaps to the B-COVER. Page 5 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 129 23. Unlock the UI FRAME with the SS-93. 24. Open the SD DOOR but do not remove it yet. 25. Lift the UI FRAME a bit and unsnap the LIGHT GUIDE. Issue 1 COMPANY CONFIDENTIAL Page 5 –13 Copyright © 2006 Nokia. All rights reserved.
Page 130 26. Now remove the SD DOOR. 27. Remove the UI FRAME with the UI MODULE from the B-COVER. 28. Take special care to the BASEBAND GASKET. Page 5 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 131 29. Open the snap if it snapped back and remove the LIGHT GUIDE. 30. Place the UI MODULE over the JOYSTICK HAT and carefully lever out the MODULE from the UI FRAME with SS-93. Issue 1 COMPANY CONFIDENTIAL Page 5 –15 Copyright © 2006 Nokia. All rights reserved.
Page 132 31. Move the UI MODULE to the primary position and then remove the UI MODULE by using the SS-93 as a support. 32. Gently, unlock the BASEBAND GASKET as shown and remove it from the UI FRAME. Page 5 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 133 34. Disconnect the MAIN CAMERA from the ENGINE MODULE and remove it carefully from its housing. 35. The ENGINE MODULE is snapped to the B-COVER with two snaps. Issue 1 COMPANY CONFIDENTIAL Page 5 –17 Copyright © 2006 Nokia. All rights reserved.
Page 134 36. Unlock the ENGINE MODULE with the SS-93 and remove it as shown taking care to all spring contacts. 37. Unlock the ANTENNA MODULE ASSEMBLY with the SS-93... 38..and remove it from the B-COVER. Page 5 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 135 39. Lift the IHF SPEAKER from its housing and remove it easily. 40. Gently push down the FLASH LED from the ANTENNA MOULDING. 41. Remove the GASKET IHF HOUSING. Issue 1 COMPANY CONFIDENTIAL Page 5 –19 Copyright © 2006 Nokia. All rights reserved.
Page 136 42. Remove the IHF SPEAKER 2 remember to remove whole IHF GASKET 2 residues. 43. Remove the MICROPHONE with the dental pick. 44. Use the DC plug to release the DC-JACK. Page 5 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 137 RM-132; RM-133 Disassembly/reassembly instructions Nokia Customer Care 45. The DC-JACK drops out easily when turning the B-COVER. The disassembly procedure is now finished. Issue 1 COMPANY CONFIDENTIAL Page 5 –21 Copyright © 2006 Nokia. All rights reserved.
Page 138 Figure 34 Needed tools: a Torque driver, a Torx size 6 plus bit, metal tweezers and the SS-93 opening tool. Steps Insert the MICROPHONE exactly as shown, avoid bending the spring contacts. Page 5 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 139 Take a special attention to the right position of the spring contacts to avoid short-circuit or malfunction of the MICROPHONE.. Place the DC-JACK with tweezers into its housing ... Issue 1 COMPANY CONFIDENTIAL Page 5 –23 Copyright © 2006 Nokia. All rights reserved.
Page 140 Ensure the correct position of the new IHF GASKET 2. Place the IHF SPEAKER 2 into the B-COVER and press it lightly to stick it on correctly. Page 5 –24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 141 Position the GASKET IHF HOUSING onto its place paying attention to the spring contacts of the IHF SPEAKER. Place the FLASH LED into its socket and secure it carefully with the SS-93. 10. Insert the ANTENNA MOULDING in the B-COVER... Issue 1 COMPANY CONFIDENTIAL Page 5 –25 Copyright © 2006 Nokia. All rights reserved.
Page 142 11..and press it lightly into place. 12. Insert the IHF SPEAKER paying attention to its spring contacts. 13. Insert the ENGINE MODULE under the shown angle. Page 5 –26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 143 Nokia Customer Care 14. Pay special attention to the SWITCHES when inserting the ENGINE MODULE into the B-COVER. 15. Secure the ENGINE MODULE. 16. Clean the camera window. Issue 1 COMPANY CONFIDENTIAL Page 5 –27 Copyright © 2006 Nokia. All rights reserved.
Page 144 Nokia Customer Care Disassembly/reassembly instructions 17. and the MAIN CAMERA with compressed air. 18. Insert the MAIN CAMERA into its housing... 19..and carefully close the connector. Page 5 –28 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 145 21. Place the EARPIECE with a new EARPIECE ADHESIVE into its frame, avoid bending the spring contacts. 22. Ensure the correct position of the CAMERA BOOT when putting it onto the FRONT CAMERA. Issue 1 COMPANY CONFIDENTIAL Page 5 –29 Copyright © 2006 Nokia. All rights reserved.
Page 146 24. Position the UI MODULE onto the UI FRAME and slightly press on the JOYSTICK HAT to ensure that it is glued. 25. Check the right positioning of the UI MODULE. Page 5 –30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 147 26. Place the LIGHT GUIDE over the UI MODULE and carefully fit it to the UI FRAME. 27. Put the UI FRAME into the B-COVER and press it into place. 28. Gently, close the connectors. Issue 1 COMPANY CONFIDENTIAL Page 5 –31 Copyright © 2006 Nokia. All rights reserved.
Page 148 30. Set the torque driver to the torque of 28 Newton centimeter. 31. To avoid damaging the plastic threads, first turn the screws slightly left to engage the thread and then tighten them lightly. Page 5 –32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 149 32. Tighten the screws to the correct torque in the order shown. 33. Connect the DISPLAY to the ENGINE MODULE... 34..and place it carefully onto the UI FRAME. Issue 1 COMPANY CONFIDENTIAL Page 5 –33 Copyright © 2006 Nokia. All rights reserved.
Page 150 35. After removal of the plastic film check the surface of the DISPLAY for cleanliness. 36. Fit the DISPLAY SHIELD to the UI FRAME. 37. Insert the SD DOOR but do not close it yet. Page 5 –34 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 151 Disassembly/reassembly instructions Nokia Customer Care 38. Put the KEYMAT into the A-COVER. 39. Check the window for cleanliness. 40. And fit the A-COVER to the B-COVER. Issue 1 COMPANY CONFIDENTIAL Page 5 –35 Copyright © 2006 Nokia. All rights reserved.
Page 152 41. Now, close the SD DOOR. 42. Fit the SLIDE COVER ASSEMBLY 43. Finally, check the functionality of the keys and ensure that there are no gaps between the covers. Page 5 –36 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 154 RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide (This page left intentionally blank.) Page 6 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 155 Vibra troubleshooting............................6–64 Baseband manual tuning guide.........................6–65 Energy management calibration........................6–65 List of Tables Table 13 Display module troubleshooting cases....................6–41 Table 14 Pixel defects............................6–42 Table 15 Calibration value limits........................6–65 Issue 1 COMPANY CONFIDENTIAL Page 6 –3 Copyright © 2006 Nokia. All rights reserved.
Page 156 Figure 48 Differential output waveform of the Ext_in_IHF_out out loop measurement when speaker is connected..............................6–57 Figure 49 Single-ended output waveform of the HP_in_Ext_out loop when microphone is connected..6–58 Page 6 –4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 157: Baseband Troubleshooting
This section is intended to be a guide for localising and repairing electrical faults. The fault repairing is divided into troubleshooting paths. The following main troubleshooting tree describes the different baseband troubleshooting paths to be followed in fault situations. Issue 1 COMPANY CONFIDENTIAL Page 6 –5 Copyright © 2006 Nokia. All rights reserved.
Page 160: Dead Or Jammed Device Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Dead or jammed device troubleshooting Troubleshooting flow Page 6 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 162: General Power Checking Troubleshooting - Cmt
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide General power checking troubleshooting - CMT Troubleshooting flow Page 6 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 163: General Power Checking Troubleshooting - Application Processor
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care General power checking troubleshooting - application processor Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –11 Copyright © 2006 Nokia. All rights reserved.
Page 164: Cmt Clocking Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide CMT clocking troubleshooting Troubleshooting flow Page 6 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 165: Application Processor Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Application processor troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –13 Copyright © 2006 Nokia. All rights reserved.
Page 166: Charging Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Charging troubleshooting Troubleshooting flow Page 6 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 167: Battery Current Measuring Fault Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Battery current measuring fault troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –15 Copyright © 2006 Nokia. All rights reserved.
Page 168: Flash Programming Fault Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Flash programming fault troubleshooting Troubleshooting flow Page 6 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 170 Figure 35 Flashing pic 1. Take single trig measurement for the rise of the BSI signal. Figure 36 Flashing pic 2. Take single trig measurement for the rise of the BSI signal. Page 6 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 171: Cmt Sdram Memory Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care CMT SDRAM memory troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –19 Copyright © 2006 Nokia. All rights reserved.
Page 172: Cmt Nor Flash Fault Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide CMT NOR flash fault troubleshooting Troubleshooting flow Page 6 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 173: Application Processor Memory Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Application processor memory troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –21 Copyright © 2006 Nokia. All rights reserved.
Page 174: Power Key Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Power key troubleshooting Troubleshooting flow Page 6 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 175: Usb Interface Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care USB interface troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –23 Copyright © 2006 Nokia. All rights reserved.
Page 176 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Figure 37 USB 1: D-TXD (system connector pin6) and D+RXD (system connector pin7) voltage levels when USB connected. Page 6 –24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 177: Sim Card Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care SIM card troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –25 Copyright © 2006 Nokia. All rights reserved.
Page 178 BB Troubleshooting and Manual Tuning Guide SIM CLK frequency = 3.2MHz (Take single triggered measurement in boot on the VSIM1 line). Figure 38 SIM interface signals Page 6 –26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 179: Sd Card Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care SD card troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –27 Copyright © 2006 Nokia. All rights reserved.
Page 181 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Figure 39 SD clk cdm diagram Figure 40 SD data 0_1 diagram Figure 41 SD data 2_3 diagram Issue 1 COMPANY CONFIDENTIAL Page 6 –29 Copyright © 2006 Nokia. All rights reserved.
Page 182: Irda Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide IrDA troubleshooting Troubleshooting flow Page 6 –30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 183 RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Figure 42 IR TX diagram Figure 43 IR RX diagram Issue 1 COMPANY CONFIDENTIAL Page 6 –31 Copyright © 2006 Nokia. All rights reserved.
Page 184: Display Controller Troubleshooting
• One or more keys can be stuck, so that the key does not react when a keydome is pressed. This kind of failure is caused by mechanical reasons (dirt, corrosion). Page 6 –32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 185 (shortcut or open connection). For a more detailed description of the keyboard and keymatrix, see section Keyboard. Phoenix . If the failure mode is not clear, start with the Keyboard Test in Issue 1 COMPANY CONFIDENTIAL Page 6 –33 Copyright © 2006 Nokia. All rights reserved.
Page 187: Slider Switch Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Slider switch troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –35 Copyright © 2006 Nokia. All rights reserved.
Page 188: Certificate Restoring For Bb5.0 Products
Note: USB flashing does not work for a dead BB5.0 phone. • Create a request file. • Send the file to Nokia by e-mail. Use the following addresses depending on your location: • APAC: sydney.service@nokia.com • CHINA: repair.ams@nokia.com • E&A: salo.repair@nokia.com •...
Page 189 Flash Type must be set to Phone as Manufactured. To continue, click Start. Progress bars and messages on the screen show actions during phone programming, please wait. Issue 1 COMPANY CONFIDENTIAL Page 6 –37 Copyright © 2006 Nokia. All rights reserved.
Page 190 Phoenix , choose File→Scan Product . To connect the phone with ii Choose Tools→Certificate Restore . iii To choose a location for the request file, click Browse. Page 6 –38 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 191 Request file, click Start. To create the vi When the file for certificate restore has been created, send it to Nokia as an e-mail attachment. 3. Restore certificate. For this procedure, you must supply +12 V to CU-4 from an external power supply.
Page 192 To write the file to phone, click Start. Next actions Phoenix tuning functions. After a successful rewrite, you must retune the phone completely by using Important: Perform all tunings: RF, BB, and UI. Page 6 –40 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 193: Display Module Troubleshooting
The criteria when pixel defects are regarded as a display failure, resulting in a replacement of the display, are presented the table below. Issue 1 COMPANY CONFIDENTIAL Page 6 –41 Copyright © 2006 Nokia. All rights reserved.
Page 194 Two single dot defects that are within 5 mm of each other should counts be interpreted as combined dot defect. Note: Blinking pixels are not allowed in normal operating temperatures and light conditions. Page 6 –42 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 195: Display Fault Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Display fault troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –43 Copyright © 2006 Nokia. All rights reserved.
Page 196: Display And Keyboard Backlight Troubleshooting
• If a phototransistor is broken, replace it with a typical phototransistor. • If the phototransistor is changed, the calibration value in the phone memory has to be changed to the default value ‘1’. Page 6 –44 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 199: Led Driver Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care LED driver troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –47 Copyright © 2006 Nokia. All rights reserved.
Page 200: Bluetooth Troubleshooting
The main issue is to find out if the problem is related to the BT antenna or related to the BT system or the phone’s BB and then replace/fix the faulty component. Location of the BT antenna Page 6 –48 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 201: Bluetooth Settings For Phoenix
7. Place the JBT-9 box near (within 10 cm) the BT antenna and click Run BER Test. Results Bit Error Rate (BER) Tests pane in the Bluetooth LOCALS window. Bit Error Rate test result is displayed in the Issue 1 COMPANY CONFIDENTIAL Page 6 –49 Copyright © 2006 Nokia. All rights reserved.
Page 202: Bluetooth Self Tests In Phoenix
4. From the Mode drop-down menu, set mode to Local. 5. Choose Testing→Self Tests. Self Tests window check the following Bluetooth related tests: 6. In the • ST_LPRF_IF_TEST • ST_LPRF_AUDIO_LINES_TEST • ST_BT_WAKEUP_TEST Page 6 –50 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 203 RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care 7. To run the tests, click Start. Figure 46 Bluetooth self tests in Phoenix Issue 1 COMPANY CONFIDENTIAL Page 6 –51 Copyright © 2006 Nokia. All rights reserved.
Page 204: Bluetooth Ber Failure Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Bluetooth BER failure troubleshooting Troubleshooting flow Page 6 –52 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 206: Bt Audio Failure Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide BT audio failure troubleshooting Troubleshooting flow Page 6 –54 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 207: Audio Troubleshooting
Earpiece, internal microphone and speaker are in place during measurement. Applying a headset accessory during measurement causes a significant drop in measured quantities. The gain values presented in the table apply for a differential output vs. single-ended/differential input. Issue 1 COMPANY CONFIDENTIAL Page 6 –55 Copyright © 2006 Nokia. All rights reserved.
Page 208 1360 Earpiece GND) HSEAR R N and GND HSEAR P, HSEAR N and HSEAR R P, HSEAR R N and GND HSEAR P, HSEAR N and Page 6 –56 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 209 If a special low-pass filter designed for measuring digital amplifiers is unavailable, the measurement must be performed with a current probe and the input signal frequency must be 2kHz. Figure 48 Differential output waveform of the Ext_in_IHF_out out loop measurement when speaker is connected. Issue 1 COMPANY CONFIDENTIAL Page 6 –57 Copyright © 2006 Nokia. All rights reserved.
Page 210 RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Figure 49 Single-ended output waveform of the HP_in_Ext_out loop when microphone is connected. Page 6 –58 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 211: Internal Earpiece Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care Internal earpiece troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –59 Copyright © 2006 Nokia. All rights reserved.
Page 212: Internal Microphone Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Internal microphone troubleshooting Troubleshooting flow Page 6 –60 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 213: Ihf Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care IHF troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –61 Copyright © 2006 Nokia. All rights reserved.
Page 214: External Microphone Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide External microphone troubleshooting Troubleshooting flow Page 6 –62 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 215: External Earpiece Troubleshooting
RM-132; RM-133 BB Troubleshooting and Manual Tuning Guide Nokia Customer Care External earpiece troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 6 –63 Copyright © 2006 Nokia. All rights reserved.
Page 216: Vibra Troubleshooting
RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide Vibra troubleshooting Troubleshooting flow Page 6 –64 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 217: Baseband Manual Tuning Guide
Write and/or repeat the procedure again. Energy Management Calibration window. 10. To end the procedure, close the Issue 1 COMPANY CONFIDENTIAL Page 6 –65 Copyright © 2006 Nokia. All rights reserved.
Page 218 RM-132; RM-133 Nokia Customer Care BB Troubleshooting and Manual Tuning Guide (This page left intentionally blank.) Page 6 –66 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 220 RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide (This page left intentionally blank.) Page 7 –2 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 221 Table 16 RF channel filter calibration tuning limits..................7–28 Table 17 Temperature sensor calibration tuning limits..................7–29 Table 18 RF tuning limits in Rx calibration......................7–31 List of Figures Issue 1 COMPANY CONFIDENTIAL Page 7 –3 Copyright © 2006 Nokia. All rights reserved.
Page 222 RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide Figure 50 RM-132 RF key component placement....................7–6 Figure 51 RM-133 RF key component placement....................7–7 Figure 52 RSSI Reading window.........................7–12 Figure 53 Rx Control window..........................7–13 Figure 54 RF Controls window..........................7–19 Figure 55 Tx Control window..........................7–20...
Page 223: Introduction To Rf Troubleshooting
If measurements are performed in a product specific module jig, then “GND” pads should be used for the probe ground. Issue 1 COMPANY CONFIDENTIAL Page 7 –5 Copyright © 2006 Nokia. All rights reserved.
Page 224: Rf Key Component Placement
RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide RF key component placement Figure 50 RM-132 RF key component placement Page 7 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 225 RM-132; RM-133 RF Troubleshooting and Manual Tuning Guide Nokia Customer Care Figure 51 RM-133 RF key component placement Issue 1 COMPANY CONFIDENTIAL Page 7 –7 Copyright © 2006 Nokia. All rights reserved.
Page 226: Self Test Troubleshooting
RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide Self test troubleshooting Troubleshooting flow Page 7 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 227: Rf Asic Troubleshooting
RM-132; RM-133 RF Troubleshooting and Manual Tuning Guide Nokia Customer Care RF ASIC troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 7 –9 Copyright © 2006 Nokia. All rights reserved.
Page 228: Synthesizer Troubleshooting
RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide Synthesizer troubleshooting Troubleshooting flow Page 7 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 229: Synthesizer Test Points
For service tool usage instructions, refer to section Service Tools and Service Concepts. Related information • WCDMA Rx chain activation for manual measurement (page 7–12) Issue 1 COMPANY CONFIDENTIAL Page 7 –11 Copyright © 2006 Nokia. All rights reserved.
Page 230: Wcdma Rx Chain Activation For Manual Measurement
(-80 dBm). WCDMA Rx chain activation for manual measurement Steps Phoenix service software. 1. Start 2. Choose Testing→WCDMA→Rx Control . Rx Control window: 3. In the Page 7 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 231: Wcdma Rssi Measurement
Phoenix service software. 1. Start 2. Choose Testing→WCDMA→Rx Power Measurement . Rx Power Measurement window, choose the following settings: 3. In the • Mode: RSSI • Continuous Mode Issue 1 COMPANY CONFIDENTIAL Page 7 –13 Copyright © 2006 Nokia. All rights reserved.
Page 232 RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide 4. To perform the measurement, click Start. Page 7 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 233: Gsm Receiver Troubleshooting
RM-132; RM-133 RF Troubleshooting and Manual Tuning Guide Nokia Customer Care GSM receiver troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 7 –15 Copyright © 2006 Nokia. All rights reserved.
Page 234: Wcdma Receiver Troubleshooting
RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide WCDMA receiver troubleshooting Troubleshooting flow Page 7 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 235: Receiver Test Points
1. Connect a module jig to a computer with a DAU-9S cable or to a FPS-10 flash prommer with a modular cable. Make sure that you have a PKD-1 dongle connected to the computer parallel port. Issue 1 COMPANY CONFIDENTIAL Page 7 –17 Copyright © 2006 Nokia. All rights reserved.
Page 236 • Set Tx Power Level in the following way: • GSM900: 5 (Default = 19) • GSM1800: 0 (Default = 15) • GSM1900: 0 (Default = 15) Page 7 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 237 • For DPCCH set the following values: • Code number: 0 • Code class: 2 • Weight: 8 • Set Channel to 9750. • Check the DPDCH enabled check box (Default). Issue 1 COMPANY CONFIDENTIAL Page 7 –19 Copyright © 2006 Nokia. All rights reserved.
Page 238 When settings are done, click Send to enable them. If you change the settings (e.g. give a new channel number), you need to click Stop and Send again. Page 7 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 239: Gsm Transmitter Troubleshooting
RM-132; RM-133 RF Troubleshooting and Manual Tuning Guide Nokia Customer Care GSM transmitter troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 7 –21 Copyright © 2006 Nokia. All rights reserved.
Page 240: Wcdma Transmitter Troubleshooting
RM-132; RM-133 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide WCDMA transmitter troubleshooting Troubleshooting flow Page 7 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 241: Power Amplifier (Pa) And Switch Mode Power Supply (Smps) Troubleshooting
Phone RF is tuned in production. There is no reason to do the re-calibration unless: • One or more of the RF components is changed • FLASH memory chip (D5000) is changed or otherwise corrupted. Issue 1 COMPANY CONFIDENTIAL Page 7 –23 Copyright © 2006 Nokia. All rights reserved.
Page 242: Rf Autotuning
Before you can use the autotuning feature, the GPIB driver from the GPIB card vendor must be installed and running. The autotune .xml file must be in a correct place: C:\Program Files\Nokia\Phoenix\products\xx-x* *= indicates the type designator of the phone, e.g. RM-1 ) \rfconf_xx-x*.xml (...
Page 243 Auto-Tune window, click Options. In the Auto-Tune options window, ensure the Enable showing of message boxes check box is checked, 10. In the and click OK. Issue 1 COMPANY CONFIDENTIAL Page 7 –25 Copyright © 2006 Nokia. All rights reserved.
Page 244 12. Change the phone RF adapter from WCDMA port to GSM port. 13. To complete the RF autotuning, click OK. Results Autotuning completed successfully! message appears. Page 7 –26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 245: Rf Manual Tuning Guide
Rx Calibration, RX Band Filter Response Compensation Any component in the WCDMA RX chain Rx AGC Alignment, RX Band Response Calibration VCTCXO G7500 Rx Calibration (GSM900 band) Issue 1 COMPANY CONFIDENTIAL Page 7 –27 Copyright © 2006 Nokia. All rights reserved.
Page 246: System Mode Independent Manual Tunings
If a PA is changed or if the permanent memory (PMM) data is corrupted, PA detection has to be performed before Tx tunings. Steps 1. From the Operating mode drop-down menu, set mode to Local. 2. Choose Tuning→PA Detection . 3. Click Tune. Page 7 –28 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 247: Temperature Sensor Calibration
AFC system (AFC D/A init value and AFC slope) Steps Connect the module jig’s GSM connector to signal generator. From the "Operating mode" dropdown menu, set mode to "Local". Issue 1 COMPANY CONFIDENTIAL Page 7 –29 Copyright © 2006 Nokia. All rights reserved.
Page 248 Check the “Load from Phone” check box and clear the “Save to Phone” check box. From the Band dropdown menu, choose GSM900. Click Start (if not active already). Click Calibrate. Page 7 –30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 249 Table 18 RF tuning limits in Rx calibration Unit GSM850 RSSI0 109...110 GSM900 AFC Value -200 -105...62 AFC slope RSSI0 107...110 GSM1800 RSSI0 104...109 GSM1900 RSSI0 104...109 Issue 1 COMPANY CONFIDENTIAL Page 7 –31 Copyright © 2006 Nokia. All rights reserved.
Page 250 RF Troubleshooting and Manual Tuning Guide 11. To save values to the phone, click "Save & Continue". 12. Repeat steps 3 to 8 for GSM850, GSM1800 and GSM1900. Page 7 –32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 251: Rx Band Filter Response Compensation (Gsm)
The calibration has to be repeated for each GSM band. Steps Connect the module jig’s GSM connector to the signal generator. From the "Operating mode" dropdown menu, set mode to "Local". Select GSM900 band. Issue 1 COMPANY CONFIDENTIAL Page 7 –33 Copyright © 2006 Nokia. All rights reserved.
Page 252 RF Troubleshooting and Manual Tuning Guide From the Tuning menu, choose GSM -> Rx Band Filter Response Compensation. Tuning mode pane, select Manual. In the Click Start. Page 7 –34 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 253 Connect the signal generator to the phone and set frequency and amplitude as instructed in the "Rx Band Filter Response Compensation for EGSM900" popup window. To perform tuning, click OK. 10. Go through all 9 frequencies. Issue 1 COMPANY CONFIDENTIAL Page 7 –35 Copyright © 2006 Nokia. All rights reserved.
Page 254 Ch. 870 / 1876.86771 MHz Ch. 885 / 1879.86771 MHz Ch. 908 / 1884.46771 MHz GSM1900 Ch. 496 / 1927.06771 MHz Ch. 512 / 1930.26771 MHz Page 7 –36 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 255 Ch. 835 / 1994.86771 MHz 12. If the values are within the limits, click "Save & Continue". 13. Repeat the steps 4 to 10 for GSM850, GSM1800 and GSM1900. Issue 1 COMPANY CONFIDENTIAL Page 7 –37 Copyright © 2006 Nokia. All rights reserved.
Page 256: Gsm Transmitter Tunings
• Tx IQ tuning must be performed on all GSM bands. Steps 1. From the dropdown menus, set "Operating mode" to Local, "System mode" to GSM, and "Band" to GSM900. Page 7 –38 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 257 3. Set "Mode" to Automatic and "Edge" to Off. 4. Click Start. Wait until automatic tuning has finished and moved the sliders. Values are written to the phone memory automatically. Issue 1 COMPANY CONFIDENTIAL Page 7 –39 Copyright © 2006 Nokia. All rights reserved.
Page 258: Tx Power Level Tuning (Gsm)
Tx power level tuning is used to find out mapping factors called 'power coefficients’. These adjust the GSM transmitter output power to fulfill the specifications. Page 7 –40 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 259 GSM1800 Frequency (MHz) 1747.8 GSM1900 Frequency (MHz) 1880 Resolution Bandwidth (MHz) Video Bandwidth (MHz) Trigger Video Sweeptime (ms) Span zero Average (for non-EDGE) Average (for EDGE) Issue 1 COMPANY CONFIDENTIAL Page 7 –41 Copyright © 2006 Nokia. All rights reserved.
Page 260 Nokia Customer Care RF Troubleshooting and Manual Tuning Guide Click Start. Select band. Set power meter or VSA to the correct frequency. Click Read and then Tune. Page 7 –42 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 261 PL8 coefficient 0.35 0.466 PL15 coefficient 0.258 PL19 coefficient 0.12 0.201 GSM900 PL5 coefficient 0.45 0.648 0.73 PL15 coefficient 0.241 PL19 coefficient 0.12 0.188 GSM900 EDGE Issue 1 COMPANY CONFIDENTIAL Page 7 –43 Copyright © 2006 Nokia. All rights reserved.
Page 263 7. Repeat step 6. for Middle and High channels. 8. Ensure Tuning Results are within limits specified in the table below: If values are OK, click Write to save the values. Issue 1 COMPANY CONFIDENTIAL Page 7 –45 Copyright © 2006 Nokia. All rights reserved.
Page 264: Wcdma Transmitter Tunings
There are two ways to perform the tuning. For an alternative method, see Alternative steps (page 7–52). Steps From the Operating mode drop-down menu, set mode to Local. Page 7 –46 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 265 It must be possible to measure power levels down to –68 dBm. The measured power levels must be monotonously decreasing. Make sure that the marker is not measuring the level of noise spike on lower levels. Issue 1 COMPANY CONFIDENTIAL Page 7 –47 Copyright © 2006 Nokia. All rights reserved.
Page 267 Fill in the power level values (in dBm) to the Wide Range pane, click Calculate. In the High Burst pane, click Tune. 10. In the 11. Adjust the spectrum analyzer according to the following settings: Issue 1 COMPANY CONFIDENTIAL Page 7 –49 Copyright © 2006 Nokia. All rights reserved.
Page 268 14. Check that the calculated values are within the limits specified in the following table: C0-high -0.5 C1-high C2-high C0-mid -0.7 C1-mid C2-mid C0-low C1-low -400 C2-low -10000 15000 Page 7 –50 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 269 Reference level: 24 dBm or -20 dBm depending on the level measured Input attenuation: Automatic Resolution bandwidth: 5 MHz Video bandwidth: 5 MHz Sweep time: 20 ms Issue 1 COMPANY CONFIDENTIAL Page 7 –51 Copyright © 2006 Nokia. All rights reserved.
Page 270: Tx Band Response Calibration (Wcdma)
• Read button reads the tuned values in the PM of the terminal, and displays them in the Current column. in in the Steps Phoenix service software. Start Page 7 –52 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 271 The tuned values are shown in the 16. Check that the tuned values are within the limits presented in the following table. If they are OK, click Yes. Issue 1 COMPANY CONFIDENTIAL Page 7 –53 Copyright © 2006 Nokia. All rights reserved.
Page 272: Tx Lo Leakage (Wcdma)
4. To end the tuning, click Close. Antenna troubleshooting Context The antennas have contacts with the engine PWB via three pogo pins. The mechanical construction and antenna are described below. Page 7 –54 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 273: Table 9 Power
Band Channel Attenuation Tolerance RX Attenuation Tolerance TX Reported power Low 128 11.8 14.2 Mid 189 11.1 13.6 GSM 850 High 251 +/-4.5dB 12.9 +/-4.5dB 31.7'+/-4.5dB Issue 1 COMPANY CONFIDENTIAL Page 7 –55 Copyright © 2006 Nokia. All rights reserved.
Page 274 4. Repeat steps 2 and 3. If the power level is within the target range, the replaced antenna was broken; otherwise, other RF part might not function properly. In this case RF troubleshooting should be carried out. Page 7 –56 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 277 Figure 73 Image of point light sources taken with a dirty (finger print) protective window.....8–14 Figure 74 Enlargement of a hot pixel.........................8–15 Figure 75 Light from the flash has reflected on particles in front of the camera.........8–15 Issue 1 COMPANY CONFIDENTIAL Page 8 –3 Copyright © 2006 Nokia. All rights reserved.
Page 279: Introduction To Camera Module Troubleshooting
Variation of response between pixels with same level of input illumination. Resolution Usually the amount of pixels in the camera sensor. In some occasions the term resolution is used for describing the sharpness of the images. Issue 1 COMPANY CONFIDENTIAL Page 8 –5 Copyright © 2006 Nokia. All rights reserved.
Page 280: The Effect Of Image Taking Conditions On Image Quality
See the figure below for an example. This is normal; do not change the camera module. Page 8 –6 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 282: Phone Display
Flickering occurs also under high artificial illumination level. Flickering only occurs when the rolling shutter is used. This is normal behaviour; do not change the camera module. Page 8 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 283 Generally this kind of reflections are common in all optical systems. This is normal behaviour; do not change the camera module. Figure 66 A lens reflection effect caused by sunshine Issue 1 COMPANY CONFIDENTIAL Page 8 –9 Copyright © 2006 Nokia. All rights reserved.
Page 284: Image Quality Analysis
In addition, there are many other kinds of possibilities for bad image quality, but those are ruled out from the scope of this document since the probability of their appearance is small. Page 8 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 285: Testing For Dust In Camera Module
Any particles inside the cavity between the protection window and lens have most probably been trapped there in the assembly phase at a Nokia factory. Unauthorized disassembling of the product can also be the root of the problem. However, in most cases it should be possible to remove the particle(s) by using clean compressed air.
Page 286: Testing Camera Image Sharpness
• If possible, compare the image to another image of the same scene, taken with a different device. Note that the reference device has to be a similar Nokia phone. There are several conditions in which AF operation is challenging for the camera module, i.e. failing from time to time.
Page 287: Effects Of Dirty Or Defective Camera Lens Protection Window
A smeared fingerprint may be hard to see on the protective window but if will affect the image quality. These flares can be avoided by cleaning the window with a suitable cloth. Issue 1 COMPANY CONFIDENTIAL Page 8 –13 Copyright © 2006 Nokia. All rights reserved.
Page 288: Faulty Pixels In Images
When examining an image for defect pixels, test images should be viewed as 100% enlargements on a PC monitor. Page 8 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 289: Flash Photography Problems
• Dust reflections. Dust or water drops in front of the flash unit may reflect strongly to the camera sensor. See the following figure. Figure 75 Light from the flash has reflected on particles in front of the camera Issue 1 COMPANY CONFIDENTIAL Page 8 –15 Copyright © 2006 Nokia. All rights reserved.
Page 290: Main Camera Troubleshooting Flowcharts
RM-132; RM-133 Nokia Customer Care Camera Module Troubleshooting Main camera troubleshooting flowcharts Camera hardware failure troubleshooting Troubleshooting flow Page 8 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 291: No Recognizable Viewfinder Image
RM-132; RM-133 Camera Module Troubleshooting Nokia Customer Care No recognizable viewfinder image Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 8 –17 Copyright © 2006 Nokia. All rights reserved.
Page 292: Bad Camera Image Quality Troubleshooting
RM-132; RM-133 Nokia Customer Care Camera Module Troubleshooting Bad camera image quality troubleshooting Troubleshooting flow Page 8 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 293: Camera Autofocus Troubleshooting
RM-132; RM-133 Camera Module Troubleshooting Nokia Customer Care Camera autofocus troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 8 –19 Copyright © 2006 Nokia. All rights reserved.
Page 294: Led Flash Troubleshooting
RM-132; RM-133 Nokia Customer Care Camera Module Troubleshooting LED flash troubleshooting Troubleshooting flow Page 8 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 295: Front Camera Troubleshooting Flowcharts
RM-132; RM-133 Camera Module Troubleshooting Nokia Customer Care Front camera troubleshooting flowcharts Front camera troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 8 –21 Copyright © 2006 Nokia. All rights reserved.
Page 296: Front Camera Hw Troubleshooting
RM-132; RM-133 Nokia Customer Care Camera Module Troubleshooting Front camera HW troubleshooting Troubleshooting flow Page 8 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 297: Bad Image Quality Troubleshooting
RM-132; RM-133 Camera Module Troubleshooting Nokia Customer Care Bad image quality troubleshooting Troubleshooting flow Issue 1 COMPANY CONFIDENTIAL Page 8 –23 Copyright © 2006 Nokia. All rights reserved.
Page 301 Baseband technical specifications........................9–26 External interfaces............................9–26 External interfaces.............................9–26 VOUT electrical characteristics........................9–26 SIM IF connections............................9–26 Charger connector and charging interface connections & electrical characteristics......9–27 Internal interfaces............................9–28 Internal interfaces............................9–28 Issue 1 COMPANY CONFIDENTIAL Page 9 –3 Copyright © 2006 Nokia. All rights reserved.
Page 302 Table 31 Back-up battery electrical characteristics..................9–33 List of Figures Figure 76 System level block diagram........................9–7 Figure 77 Power distribution diagram.........................9–9 Figure 78 SIM interface............................9–11 Figure 79 Battery pin order..........................9–12 Page 9 –4 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 303 Figure 93 Charger connector..........................9–27 Figure 94 Back side of the board........................9–29 Figure 95 Front side of the board........................9–30 Figure 96 RM-133 RF block diagram........................9–34 Figure 97 RM-132 RF block diagram........................9–35 Figure 98 RF frequency plan..........................9–36 Issue 1 COMPANY CONFIDENTIAL Page 9 –5...
Page 305: System Module Block Diagram
128 Mbits of memory. RAP operates with the system clock of 38.4 MHz, which comes from the VCTCXO. The application section includes an application processor ASIC with DDR/NAND combo memory as the core. Issue 1 COMPANY CONFIDENTIAL Page 9 –7 Copyright © 2006 Nokia. All rights reserved.
Page 306: Application Processor
VMSTR+ Threshold for charging, rising (N2300) 2.1 V (typ.) VMSTR- Threshold for charging, falling (N2300) 1.9 V (typ.) VCOFF+ Hardware cut off (rising) 2.9 V (typ.) Page 9 –8 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 307: Power Distribution
SW). Power on key is connected to the EM ASIC N2200 via PWRONX signal. Power distribution Figure 77 Power distribution diagram Power supply components • EM ASIC N2200 • EM ASIC N2300 • Application processor VCORE SMPS, N4200 Issue 1 COMPANY CONFIDENTIAL Page 9 –9 Copyright © 2006 Nokia. All rights reserved.
Page 308: Clocking Scheme
RS MMC, SIM, CCP, I2C and memories. 32k Sleep Clock is always powered on after startup. Sleep clock is used by RAP and the application processor for low-power operation. Page 9 –10 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 310: Sd Card Interface
This section describes the mechanical construction of the camera module for getting a better understanding of the actual mechanical structure of the module. Table 20 Camera specifications Sensor type CMOS Page 9 –12 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 311: Flash Led
The FLED has four white LEDs connected in series in one module. The module also includes a lens with its plastic housing to ensure a proper light pattern at the target. The dimensions of the FLED are 6.5 x 7.5 x 3.5 mm. Issue 1 COMPANY CONFIDENTIAL Page 9 –13 Copyright © 2006 Nokia. All rights reserved.
Page 312: Front Camera
128 kbps in maximum mode) Exposure: Automatic and manual White Balance: Automatic or adjustable Capture Modes: Still capture mode, video mode, sequence mode 10,20 or 30 seconds. Page 9 –14 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 313: User Interface
Navi left Navi up Navi down Navi right ROW_2 Volume up ROW_3 Imaging ROW_4 Operator ROW_5 Camera half Camera full ROW_6 Edit Clear Apps Volume down Issue 1 COMPANY CONFIDENTIAL Page 9 –15 Copyright © 2006 Nokia. All rights reserved.
Page 314: Main Display
Figure 83 General diagram of the LCD module Display features: • Module size (width x height x thickness) 41.92 mm, 60.55 mm, 2.72 mm • Resolution QVGA Page 9 –16 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 315: Display And Keyboard Backlight
• Normal mode, Full screen, 262k colors • Partial idle mode, 8 colours but only part of the display is active The interconnection between the LCD module and the Nokia engine is implemented with a 24-pin board-to- board connector. The display is controlled via a MeSSi-16 interface with an 8-bit bus by the application processor. All MeSSi-16 signals go through the EMC filtering ASIPs.
Page 316 Figure 84 Connections on the engine board Figure 85 Connections on the UI board The left-hand end of the chain connects to VLEDOUT, and the right-hand end connects to VLEDRETURN. Page 9 –18 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 317: Als Interface
• Charge control circuitry • Level shifter and regulator for USB/FBUS • Current gauge for battery current measuring • LED driver for backlights • Digital interface (CBUS) Issue 1 COMPANY CONFIDENTIAL Page 9 –19 Copyright © 2006 Nokia. All rights reserved.
Page 318: Device Memories
All galvanic audio accessories are connected to the system connector accessory connector. A Bluetooth audio module that is connected to RAP supports Bluetooth audio functionality. There is a separate application processor for Symbian applications. Page 9 –20 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 319: Internal Microphone
The microphone is biased by the EM ASIC MicB1 bias voltage output. Figure 87 Internal microphone circuitry External microphone Galvanic accessories are connected to the system connector. Issue 1 COMPANY CONFIDENTIAL Page 9 –21 Copyright © 2006 Nokia. All rights reserved.
Page 320: Internal Earpiece
EM ASIC (N2200) differential outputs EarP and EarN. Internal speaker The internal speakers are used in Internal HandsFree (IHF) call mode. Two dynamic speakers are connected to the N6509 dual amplifier. Page 9 –22 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 321: External Earpiece
XearRC are the ground pins if using single-ended mode. On the system connector side, HSEAR_P and HSEAR_N form the left channel output, and HSEAR_R_P and HSEAR_R_N the right channel output. HSEAR_N and HSEAR_R_N are the ground pins in single-ended mode. Issue 1 COMPANY CONFIDENTIAL Page 9 –23 Copyright © 2006 Nokia. All rights reserved.
Page 322: Vibra Circuitry
The system connector provides a fully differential 4–wire stereo line-level output connection and a fully differential 2-wire mono line-level or microphone level input connection. The handsfree driver in one of the EM ASICs is meant for the headset. Page 9 –24 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 323 13 / HEAR R N Audio out 20-20k 1Vpp 10Ω Not conn. in mono 14 / HEAR R P Audio out 20-20k 1Vpp 10Ω Not conn. in mono Issue 1 COMPANY CONFIDENTIAL Page 9 –25 Copyright © 2006 Nokia. All rights reserved.
Page 324: Baseband Technical Specifications
EM ASIC N2200 SIM1ClkC Clock signal to SIM card Ground SIMDATA In/Out EM ASIC N2200 SIM1DaC Data input / output SIM_DET EM ASIC N2200 SIMDetX Removal detection Page 9 –26 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 325: Charger Connector And Charging Interface Connections & Electrical Characteristics
Center pin Vchar I Charge 0.85 Center pin Charge GND 0.85 Threshold for Typical value MSTR+ charging, rising (N2300) Threshold for Typical value MSTR- charging, falling (N2300) Issue 1 COMPANY CONFIDENTIAL Page 9 –27 Copyright © 2006 Nokia. All rights reserved.
Page 326: Internal Interfaces
Name of connection Connector reference UI connector X6515 Back camera X6523 Front camera X6522 Flash connector X6501 Power key X6526, X6527 Display connector X6507 Slide switch X6530, X6531 Page 9 –28 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 327: Ui Module Connector And If Connections
RM-132; RM-133 System Module Nokia Customer Care UI module connector and IF connections Figure 94 Back side of the board Issue 1 COMPANY CONFIDENTIAL Page 9 –29 Copyright © 2006 Nokia. All rights reserved.
Page 328: Keyboard Interface Electrical Characteristics
Keyboard interface electrical characteristics Description Parameter Unit Notes High-level 0.65* V 0.3+ V input voltage Low-level -0.3 0.35* V input voltage High-level 1.62 1.98 Column output voltage Page 9 –30 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 329: Keyboard Connector And Interface Connections
Power MiniSD Column 4 Column 3 Row 4 Column 0 Row 5 Row 6 Row 2 Row 1 Row 3 Column 1 VLED return Column 2 Issue 1 COMPANY CONFIDENTIAL Page 9 –31 Copyright © 2006 Nokia. All rights reserved.
Page 330: Front Camera Electrical Characteristics
D converter voltage Flash LED interface and electrical characteristics Table 28 Flash LED interface connections Signal name From Description GPIO28 D4800 N1471 Indicator mode enable signal Page 9 –32 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 331: Slider Switch Electrical Characteristics
In addition to RFBus there are also several other interface signals coming from BB. TX power control (TXC), VCTCXO frequency control (AFC) and some other control signals (voltage and current references, WCDMA TX power detection, PA combination detection). Issue 1 COMPANY CONFIDENTIAL Page 9 –33 Copyright © 2006 Nokia. All rights reserved.
Page 332: Regulators
The RF block diagram for RM-133 uses RF ASIC N7500 as illustrated by the red border in the block diagram. Figure 96 RM-133 RF block diagram The RF block diagram for RM-132 is the same as for RM-133 except all WCDMA specific components have been removed.
Page 333: Frequency Plan
In RM-133, the single feed antenna switch directs the received signal from the multiband antennas to either the GSM or the WCDMA section. In the case of RM-132, the WCDMA switch output is terminated by a matched load. The GSM section covers the four GSM bands USGSM850, EGSM900, GSM1800 and the GSM1900. The WCDMA section operates at the 2100 MHz band.
Page 335: Gsm Receiver
In production the PA quiescent current can be tuned to target value by adjusting the bias current of PA output stage. The bias current is also used as PA on/off controls. Issue 1 COMPANY CONFIDENTIAL Page 9 –37 Copyright © 2006 Nokia. All rights reserved.
Page 336: Gsm Transmitter
The frequency of the reference oscillator is locked into the frequency of the base station with the help of an AFC voltage, which is generated in BB by DSP and converted by dedicated DAC. Page 9 –38 COMPANY CONFIDENTIAL Issue 1 Copyright © 2006 Nokia. All rights reserved.
Page 345 Nokia Customer Care Table of Contents System connector..............................10–4 AVILMA & BETTY..............................10–5 RAP3GS & FM radio...............................10–6 OMAP, BT & IrDA..............................10–7 User interface................................10–8 Camera...................................10–9 RF part.................................10–10 Signal overview..............................10–11 Component finder..............................10–12 Issue 1 COMPANY CONFIDENTIAL Page 10 –3 Copyright © 2006 Nokia. All rights reserved.

This manual is also suitable for:

Rm-133 N73 - smartphone 42 mb

Nokia RM-132 Service Manual & Parts Manual

Table of Contents

List of Tables

Table of Contents

List of Figures

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Audio Concept/Baseband Technical Specifications

Quick Links

Chapters

Troubleshooting

Related Manuals for Nokia RM-132

Summary of Contents for Nokia RM-132